Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
• Pump control
• Pressure Management
• Flow control
• Relief-Sustaining-Surge Control
• Water Loss Management
• Level control
• SCADA Electronic Control
• High Performance Solutions
MAIN VALVES 106 series - FULL PORT 206 series - REDUCED PORT
We offer two distinct main body model series:
- 106 series - Full Port,
- 206 series - Reduced Port.
The model 206 series valves are similar to the model 106
series except that the series are typically one standard pipe size
smaller than the flange sizes (consult with us on larger sizes). FLANGE BORE
For example, a 6’’ (150mm) 206-PG valve has a 4’’ (100mm) seat 6” (150mm)
/ 250mm) are Flat Diaphragm design. All larger sized valves are
Rolling Diaphragm design.
Rolling Diaphragm (below) Angle Pattern
Most sizes of valves are also available in Angle Pattern. vs. Flat Diaphragm (above) (106 series full port angle pattern
(106 series 10’’ PG model shown below) shown below)
PILOTS & CONTROLS
We offer a wide range of Pilot system options to suit the most
complex applications. We specialize in the following areas: water
loss management, pressure reducing control, relief, sustaining
and surge control, pump, level or flow control and electronic
control.
OPERATION
SINGER Control Valves are hydraulically operated by introducting
or releasing water from the control chamber above the diaphragm.
The main valve is combined with specific purpose pilots and
accessories to provide control for a wide range of functions.
We can customize to any required solution - please contact us to This brochure outlines only some of the many application
discuss your unique application requirements. solutions available. For further information please contact
us.
F5 - Non-Modulating Float
Pilot opens main valve fully to fill tank when level falls a preset (adjustable amount). Closes
tightly on high water level.
PR - Pressure Reducing
Automatically reduces higher upstream pressure to a lower downstream pressure (adjustable)
regardless of fluctuations in inlet pressure or flow. (If downstream pressure is 30% or less of
upstream please contact us).
RF - Rate of Flow
Limits the flow to preset (adjustable) maximum. Paddle style orifice generates low signal.
FLOW HC - Hydraulic Check
CONTROL Permits one-way flow only and offers adjustable opening and closing speeds. When pressure
is reversed there is brief reverse flow and the valve closes tightly. (Usually installed with
forward flow over the seat for smoother closing).
SC - Solenoid Control
Solenoid control valves respond to an electrical signal to provide two-position (on/off) operation.
The SC valve is available either with the main valve closed when the solenoid is de-energized
(NC-Normally Closed) or with the main valve open when the solenoid is de-energized (NO-
Normally Open).
ELECTRIC 2SC-MV
CONTROL Combines the electronic control of flow, pressure or level of a 2SC-PCO model with metering.
Uses advanced PLC controllers with both control and metering algorithms. Capable of local
display and re-transmission to remote stations.
Dependable maintenance-free
seat
(Stainless Steel
Improve anti-vibration fasteners)
flow, wear resistance
(fusion epoxy lined
and coated)
Easy re-orientation of
pilot system
(Extra threaded taps
on main valve)
Craan, Craanford,
GLOBE PATTERN ORIENTATION ANGLE PATTERN ORIENTATION STANDARD OPPOSITE
www.measurIT.com
Solenoid voltage: ________________________________ □ reclaimed water Pilot spring range: ____________________
email: info@measurIT.com
Pilot range(s): __________________________________ □ external spring lift Required operating range: ______________
Energize to: □ open □ close main valve □ grooved ends Pilot utilized: _________________________
Number of limit switches: _________________________ □ internal drop check
Actuation positions: ______________________________ □ anti-cavitation trim □ model J0097A strainer
Contacts: □ SPDT or □ DPDT □ x107 position indicator □ model J0098A strainer
□ Standard power-failure mode is fail at last position or □ x129 limit switch indicator □ arion model J1521G strainer
□ Fail open on power failure or □ x136 analog position transmitter □ arion model J1521M strainer
□ Fail closed on power failure □ no yellow metal upgrade
Source of set point signal (4-20mA): _______________ □ delrin stem sleeve OTHER INFORMATION:
Source of set process variable signal: ______________ □ oxy nitride stem ____________________________________
□ Optional explosion proof housing OTHER: