Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Industrial Automation
Training Academy
Input
Output
Timers
Counters
Memory Bits
Format
0.0, 0.1
100.0, 100.01
TIMX#Y
CNTX#Y
W0.0~W512.0 H0 ~ H1535
1.0, 1.1
TIM1~TIM4095 CNT1~CNT4095
Y is Preset Value
H0.0 ~ H1535.15
0.1
OFF
OFF
OFF
Pressed (ON)
Released (OFF)
0.2
OFF
OFF
OFF
OFF
OFF
10.0
OFF
ON
ON
OFF
OFF
10.1
OFF
OFF
OFF
ON
ON
WWW.NFIAUTOMATION.ORG
2
OFF
OFF
ON (Pulse)
OFF
OFF
6. Similarly Interlock 3 Outputs 10.0, 10.1 & 10.2 using 0.0, 0.1 & 0.2. Using 0.4 as NC Push
button to turn off the Outputs 10.0 ~ 10.2 at any event.
Section 3- Use of Rising/Falling Edge & Memory Bits (W0.0)
1. Device a Circuit such that when 0.0 is pressed, 10.0 gets latched. When 0.1 is pressed, nothing
should happen, but when 0.1 is released 10.0 should unlatched.
WWW.NFIAUTOMATION.ORG
Section 7- Use of Data Register (D0) & related commands- MOV, RST, ADD, SUB, MUL, DIV &
INC/DEC
1. Switch ON a Lamp (10.0) after 5 sec. Make a provision using MOV command to change the delay
time to 10 second by pressing 0.1 & then back to 5 sec by pressing 0.2. You have 1 maintained
button (0.0) and 2 push buttons only. Maintained button to switch on/off the lamp. Other two push
button for changing the time from 5 to 10 sec and vice-versa
2. Device a circuit to Change the time of above timer using Increment & (0.3- PB) Decrement (0.4PB) commands.
3. Device a circuit to blink the output 10.0 using following delay time sequence using MOV command
a. Default Delay Time = ON time 1 Second & OFF Time 1 second
b. Case A, When 0.1 is pressed = ON time 2 seconds & OFF time 1 second
c. Case B, When 0.2 is pressed = ON time 1.5 seconds & OFF Time 2 seconds
4. I have a constant K10 in D0
a. Multiply it with 100
b. Add 56 to it
c. Subtract 14 from it
d. Finally store it in D10
5. Device a similar circuit as above but to change the time use Increment (0.1) & Decrement (0.2)
functions such that minimum blinking time should be 0.5 seconds (ON/OFF) & maximum should
be 3 seconds (ON/OFF). The step of Increment & Decrement should be 0.1 second
WWW.NFIAUTOMATION.ORG