Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Total Marks: 50
b] swan nut
c] castle nut
d] clevis pin
3. Which are of the following springs resist a tensile load applied by means of a suitable end form hook or wop?
a] leaf spring
c] coil spring
d] wire spring
4. The self holding tapers have a smaller taper angle that is limited to maximum of
a) 3
b)4
c)2
d)5
b) 6/8"
c) 5/8"
d) 4/8"
b) Jarno 1 to 20
c) Jarno 0 to 18
d) Jarno 0 to 20
7. In which follwoing start threads allows to keep the depth of the thread to be less and provides for rapid
axial movement of the screws.
a) Single start
b) Multi start.
C) Double Stan
9. A tap broken above the surface of the work piece, this brocken tap can be removed by using_
a) use of punch
d) Free fit
b) Numbers
d) Bond
12. The hallow saddle key and circular taper key are used for
a) Only light duty transmission
13.The operation of enlarging the end of a drilled hole for accomadating the socket head screw. Name the
operation
a) counter boring
b) Counter sinking
c) Spot facing
d) Boring
14. The bottom surface joining two sides of adjacent thread is known as_
a) Crest
b) Root
c) Pitch
d) Flank
17. Machined "T" bolts are to be protected against corrosion. The most suitable surface treatment for this is_
a) Enamelling
b) Painting
c) Blackening
d) Polishing
18. Which type lap abrasives are used for lapping tungston carbide?
a) Silicon carbide
b) aluminium oxide
c) Boron carbide
d) Diamond.
19. The self-locking nut have a nylon or fiber ring insert the internal die of the ring insert is
a] Strollers than they are die of the bolt Thread
20. Belt get slip in open belt drive, due to insufficient arc of contact of pulley. How do you reduce this type slip?
a) Put jockey pulley on slack side near smaller pulley b) Put jockey pulley on tension side near to smaller pulley
c) Put jockey pulley on slack side near to bigger pulley d) Put jockey pulley on tension side near to bigger pulley
21. The main advantage of using hexagonal socket head cap screw is to
a) Operate frequently and easily
22. which severe is used to connect the collar and shaft in a passion
a) Hexagonal socket et screw
22. Measuring gauges require wear resistance. Which heat treatment process is required to get such property?
a) Normalizing
b) Case hardening
c) Annealing
d) Temparing
23. The flank angle and the form of fine screw thread can be checked by using
a) plug gauge
b) thread micrometer
c) optical projector
d) snap gauge
24. Match the uses against with slip gauges accessories labelled in the figure. Uses
a) To measure the bore diameter of a bush
b) To measure the external dimensions of a rectangular
block
c) To scribe arc and circles while marking / layout work d) To check the height of a work setup
Slip gauge accessories
25. In which following metal, has it's most one important uses for electro plating metallic surfaces? a) Chromium
b) Nickel
c) Stainless steel
d) Aluminium