Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
050-200704GR
(MFR'S VERSION A)
SERVICE MANUAL
COLOR TELEVISION
13A26
The above model is classified as a green product (*1), as indicated by the underlined serial number.
This Service Manual describes replacement parts for the green product. When repairing this green
product, use the part(s) described in this manual and lead-free solder (*2).
For (*1) and (*2), see the next page.
DOCUMENT CREATED IN JAPAN, April, 2007 GREEN
(*1)
The EC is actively promoting the WEEE & RoHS Directives that define standards for recycling
and reuse of Waste Electrical and Electronic Equipment and for the Restriction of the use of
certain Hazardous Substances. From July 1, 2006, the RoHS Directive will prohibit any
marketing of new products containing the restricted substances.
Increasing attention is given to issues related to the global environmental. Toshiba Corporation
recognizes environmental protection as a key management tasks, and is doing its utmost to
enhance and improve the quality and scope of its environmental activities. In line with this,
Toshiba proactively promotes Green Procurement, and seeks to purchase and use products,
parts and materials that have low environmental impacts.
Green procurement of parts is not only confined to manufacture. The same green parts used in
manufacture must also be used as replacement parts.
(*2)
LEAD-FREE SOLDER
This product is manufactured using lead-free solder as a part of a movement within the consumer
products industry at large to be environmentally responsible. Lead-free solder must be used in
the servicing and repair of this product.
WARNING
This product is manufactured using lead free solder.
A1-1
6. AVOID AN X-RAY
Safety is secured against an X-ray by considering about the cathode-ray tube and the high
voltage peripheral circuit, etc.
Therefore, when repairing the high voltage peripheral circuit, use the designated parts and
make sure not modify the circuit.
Repairing except indicates causes rising of high
voltage, and it emits an X-ray from the cathoderay tube.
[Note 1]
In the condition that an explosion-proof cathoderay tube is set in this equipment, safety is
secured against implosion. However, when
removing it or serving from backward, it is
dangerous to give a shock. Take enough care to
deal with it.
IMPORTANT
When you exchange IC and Transistor with a heat sink, apply silicon grease on the contact section of
the heat sink. Befor applying new silicon grease, remove all the old silicon grease. (Old grease may
cause damages to the IC and Transistor.)
A1-2
TABLE OF CONTENTS
GREEN PRODUCT PROCUREMENT ..........................................................................................
LEAD-FREE SOLDER ..................................................................................................................
SERVICING NOTICES ON CHECKING ......................................................................................
HOW TO ORDER PARTS ............................................................................................................
IMPORTANT .................................................................................................................................
TABLE OF CONTENTS ...............................................................................................................
GENERAL SPECIFICATIONS .....................................................................................................
DISASSEMBLY INSTRUCTIONS
1. REMOVAL OF ANODE CAP ................................................................................................
2. REMOVAL AND INSTALLATION OF FLAT PACKAGE IC .................................................
SERVICE MODE LIST .................................................................................................................
CONFIRMATION OF HOURS USED ..........................................................................................
WHEN REPLACING EEPROM (MEMORY) IC ...........................................................................
ELECTRICAL ADJUSTMENTS ...................................................................................................
BLOCK DIAGRAMS .....................................................................................................................
PRINTED CIRCUIT BOARDS
TV MT/CRT ...............................................................................................................................
TV MT ........................................................................................................................................
SCHEMATIC DIAGRAMS
MICON/CHROMA/TUNER ........................................................................................................
TV POWER ...............................................................................................................................
DEFLECTION/CRT ...................................................................................................................
SOUND/AV ................................................................................................................................
WAVEFORMS ...............................................................................................................................
MECHANICAL EXPLODED VIEWS ............................................................................................
MECHANICAL REPLACEMENT PARTS LIST ...........................................................................
ELECTRICAL REPLACEMENT PARTS LIST ............................................................................
A2-1
A1-1
A1-1
A1-2
A1-2
A1-2
A2-1
A3-1~A3-5
B1-1
B2-1, B2-2
C-1
C-3
C-3
D-1~D-4
E-1, E-2
F-1, F-2
F-3, F-4
G-1, G-2
G-3, G-4
G-5, G-6
G-7, G-8
H-1, H-2
I-1, I-2
J1-1
J2-1~J2-3
GENERAL SPECIFICATIONS
G-1
TV
System
CRT
13 inch / 335.4mmV
Normal
90
+0.45G/0.18G
NTSC
1Speaker
Bottom
3 Inch
8
1.0
---
Color System
Speaker
G-2
Tuning
System
Position
Size
Impedance
Sound Output
MAX
10%(Typical)
NTSC3.58+4.43 /PAL60Hz
Broadcasting System
Tuner and
System
Receive CH
Destination
Tuning System
Input Impedance
Intermediate
Frequency
G-3
Power
Protector
Regulation
G-5
Temperature
G-6
Operating Humidity
ohm
W
W
No
US System M
1Tuner
USA(W/ CATV)
F-Synth
VHF/UHF 75 ohm
2 - 69, 4A, A-5 - A-1,
A - I, J - W, W+1 - W+84
45.75MHz
41.25MHz
4.50MHz
No
No
Yes
120V AC 60Hz
CH Coverage
Picture(FP)
Sound(FS)
FP-FS
Preset CH
Stereo/Dual TV Sound
Tuner Sound Muting
Power Source
AC
DC
Power Consumption
G-4
degree
at AC
54 W at AC 120 V 60 Hz
3 W at AC 120 V 60 Hz
-kWh/Year
Yes
UL(UL1492)
--DHHS
+5oC ~ +40oC
-20oC ~ +60oC
Less than 80% RH
A3-1
GENERAL SPECIFICATIONS
G-7
On Screen
Display
Menu
Yes
Character
Yes
Yes
Yes
Yes
Yes
Yes
Menu Type
Picture
Contrast
Brightness
Color
Tint
Sharpness
Audio
No
No
No
No
No
No
Bass
Treble
Balance
BBE On/Off
Stable Sound On/Off
CH Set Up
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
TV/CABLE(CATV)
Auto CH Memory
Add/ Delete
Language
V-chip
Lock
On Timer
CH Label
Favorite CH
Color Stream DVD/DTV
Control Level
Volume
Brightness
Contrast
Color
Tint
Sharpness
Tuning
Bass
Treble
Balance
Back Light
Stereo,Audio Output,SAP
Video
Color Stream
Channel(TV/Cable)
CH Label
Game Timer
Sleep Timer
Sound Mute
V-chip Rating
G-8
OSD Language
G-9
Clock and
Timer
Sleep Timer
Max Time
Step
Program(On Timer )
On Timer
Wake Up Timer
Timer Back-up (at Power Off Mode)
No
No
No
Yes
Yes
Yes
Yes
Yes
Yes
Yes
No
No
No
No
No
No
Yes
No
Yes
No
Yes
Yes
Yes
Yes
English
French
Spanish
120 Min
10 Min
Yes
more than
A3-2
--
Min
No
Sec
GENERAL SPECIFICATIONS
G-10
Remote
Control
Unit
Glow in Dark Remocon
Format
Custom Code
Power Source
Voltage(D.C)
UM size x pcs
Total Keys
Keys
Power
1
2
3
4
5
6
7
8
9
0
100
CH Up
CH Down
Volume Up
Volume Down
TV/Caption/Text
CH1/CH2
TV/Video(TV/AV)
CH RTN/CH ENT(Quick View)
Sleep
RE Call(Call)
Reset
Menu
Enter
Mute
Exit
MTS(Audio Select)
Set +
Set Multi Brand Keys
CH Up(VCR)
CH Down(VCR)
Pause/Still
TV/VCR(VCR)
Code
FF
Rew
Rec
Play
Stop
TV
VCR
Cable
A3-3
RC-EH
Yes
Toshiba
40-BF h
3V
UM-4 x 2 pcs
27
Keys
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
No
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
No
No
Yes
Yes
No
No
No
No
No
No
No
No
No
No
No
No
No
GENERAL SPECIFICATIONS
G-11
Features
Auto Degauss
Auto Shut Off
Canal+
CATV
Anti-theft
Rental
Memory(Last CH)
Memory(Last Volume)
V-Chip
Yes
Yes
No
Yes
No
No
Yes
Yes
Yes
USA,ORION Type
Type
BBE
Auto Search
CH Allocation
SAP
Channel Lock
Just Clock Function
Game Position
CH Label
VM Circuit
Full OSD
Premiere
Comb Filter
No
No
No
No
No
No
No
No
No
No
No
No
Lines
G-12
Accessories
Auto CH Memory
Hotel Lock
Closed Caption
FBT Leak Test Protect
CH Lock
Video Lock
Game Timer (Max Time:120 Min)
Stable Sound
Energy Star
Power On Memory
Favorite CH
Owner's Manual
Language
w/Guarantee Card
Remote Control Unit
Rod Antenna
Poles
Terminal
Loop Antenna
Terminal
U/V Mixer
DC Car Cord (Center+)
Guarantee Card
Warning Sheet
Circuit Diagram
Antenna Change Plug
Service Facility List
Important Safeguard
Dew/AHC Caution Sheet
AC Plug Adapter
Quick Set-up Sheet
Battery
UM size x pcs
OEM Brand
AC Cord
AV Cord (2Pin-1Pin)
Registration Card (NDL Card)
ESP Card
300 ohm to 75 ohm Antenna Adapter
Yes
No
Yes
Yes
Yes
Yes
Yes
No
No
Yes
No
English/Spanish
No
Yes
No
No
No
No
Yes
No
No
No
No
No
No
No
No
Yes
UM-4 x 2 pcs
No
No
No
No
No
No
A3-4
GENERAL SPECIFICATIONS
G-13
Interface
G-14
G-15
Set Size
Weight
G-16
Carton
Switch
Front
Power
System Select
Main Power SW
Sub Power
Channel Up/Reset
Channel Down/Enter
Volume Up/Set Up
Volume Down/Set Down
MENU=Volume Up+Volume Down
Rear
AC/DC
TV/CATV Selector
Degauss
Main Power SW
Indicator
Power
Stand-by
On Timer
Terminals Front
Video Input
Audio Input
Other Terminal
Rear
Video Input(Rear1)
Video Input(Rear2)
Audio Input(Rear1)
Audio Input(Rear2)
Video Output
Audio Output
Euro Scart
Color Stream
Diversity
Ext Speaker
DC Jack 12V(Center +)
VHF/UHF Antenna Input
AC Outlet
Approx.
W x D x H (mm)
Net (Approx.)
Gross (Approx.)
Master Carton
Content
Material
Dimensions
W x D x H(mm)
Description of Origin
Gift Box
Material
Dimensions
W x D x H(mm)
Description of Origin
Cabinet Material
G-18
Environment
No
No
No
Yes
Yes
Yes
Yes
Yes
No
No
No
No
Yes
No
No
RCA
RCA x 1
Ear Phone
No
No
No
No
No
No
No
No
No
No
No
F Type
No
x 320.5
( 20.9 lbs)
( 24.4lbs)
No
---Sets
-/--- x -- x -No
Double/Brown
440 x 408 x 380
Yes
362 x 360
9.5 kg
11.0kg
Drop Test
G-17
Yes
Height (cm)
Container Stuffing
Cabinet
Cabinet Front
Cabinet Rear
PCB
Non-Halogen Demand
Eyelet Demand
Environmental standard requirement
Pb-free
A3-5
62
Sets/40' container
866
PS 94V0 DECABROM
PS 94V0 DECABROM
No
Yes
Green procurement of TOSHIBA
Phase3(Phase3A)
DISASSEMBLY INSTRUCTIONS
3. After one side is removed, pull in the opposite direction to
remove the other.
NOTE
REMOVAL
Location of Anode Cap
Fig. 1-3
GND on the CRT
NOTE
Confirm that there is no dirt, dust, etc. at the spot where
the cap was located.
2. Arrange the wire of the Anode Cap and make sure the
wire is not twisted.
3. Turn over the Rubber Cap. (Refer to Fig. 1-4.)
CRT
Screwdriver
Support
Alligator Clip
Fig. 1-4
Fig. 1-1
4. Insert one end of the Anode Support into the anode button,
then the other as shown in Fig. 1-5.
CRT
Support
CRT
Support
Fig. 1-2
B1-1
Fig. 1-5
DISASSEMBLY INSTRUCTIONS
3. When IC starts moving back and forth easily after
desoldering completely, pickup the corner of the IC using a
tweezers and remove the IC by moving with the IC
desoldering machine. (Refer to Fig. 2-3.)
NOTE
1. Put the Masking Tape (cotton tape) around the Flat
Package IC to protect other parts from any damage.
(Refer to Fig. 2-1.)
NOTE
Masking is carried out on all the parts located within 10
mm distance from IC leads.
Masking Tape
(Cotton Tape)
Blower type IC
desoldering
machine
IC
Tweezers
Fig. 2-1
IC
Fig. 2-3
NOTE
NOTE
Do not move the Braided Shield Wire in the vertical
direction towards the IC pattern.
Blower type IC
desoldering machine
Soldering Iron
IC
IC pattern
Fig. 2-2
B2-1
Fig. 2-4
DISASSEMBLY INSTRUCTIONS
INSTALLATION
1. Take care of the polarity of new IC and then install the new
IC fitting on the printed circuit pattern. Then solder each
lead on the diagonal positions of IC temporarily.
(Refer to Fig. 2-5.)
IC
Soldering Iron
Fig. 2-8
5. Finally, confirm the soldering status on four sides of the IC
using a magnifying glass.
Confirm that no abnormality is found on the soldering
position and installation position of the parts around the IC.
If some abnormality is found, correct by resoldering.
Solder temporarily
Solder temporarily
Fig. 2-5
2. Supply the solder from the upper position of IC leads
sliding to the lower position of the IC leads.
(Refer to Fig. 2-6.)
Solder
IC
NOTE
When the IC leads are bent during soldering and/or
repairing, do not repair the bending of leads. If the
bending of leads are repaired, the pattern may be
damaged. So, always be sure to replace the IC in this
case.
Soldering Iron
Supply soldering
from upper position
to lower position
Fig. 2-6
3. Absorb the solder left on the lead using the Braided Shield
Wire. (Refer to Fig. 2-7.)
NOTE
Do not absorb the solder to excess.
Soldering Iron
IC
Fig. 2-7
B2-2
Remocon Key
Operations
6
Can be checked of the INITIAL DATA of MEMORY IC.
Refer to the "WHEN REPLACING EEPROM (MEMORY) IC".
ADDRESS
INIT
00
DATA
D0
CRT ON 0010
FIG. 1
+0
+1
+2
+3
+4
+5
+6
+7
+8
+9
+A
+B
+C
+D
+E
+F
00
D0
04
EB
4E
47
B3
24
69
39
00
00
05
90
D4
00
07
Table 1
1. Enter DATA SET mode by setting VOLUME to minimum.
2. While holding down VOLUME button on front cabinet, press key (6) on remote control for more than 2 seconds.
ADDRESS and DATA should appear as FIG 1.
3. ADDRESS is now selected and should "blink". Using the VOL. +/- button on the remote, step through the ADDRESS until
required ADDRESS to be changed is reached.
4. Press ENTER to select DATA. When DATA is selected, it will "blink".
5. Again, step through the DATA using VOL. +/- button until required DATA value has been selected.
6. Pressing ENTER will take you back to ADDRESS for further selection if necessary.
7. Repeat steps 3 to 6 until all data has been checked.
8. When satisfied correct DATA has been entered, turn POWER off (return to STANDBY MODE) to finish DATA input.
After the data input, set to the initializing of shipping.
9. Turn on the POWER.
10. Set the VOLUME to minimum.
11. While holding down VOLUME button on front cabinet, press key (1) on remote control for more than 2 seconds.
12. After the finishing of the initializing of shipping, the unit will turn off automatically.
The unit will now have the correct DATA for the new MEMORY IC.
C-1
ELECTRICAL ADJUSTMENTS
1. BEFORE MAKING ELECTRICAL
ADJUSTMENTS
2. BASIC ADJUSTMENTS
CAUTION
Use an isolation transformer when performing any service
on this chassis.
Before removing the anode cap, discharge electricity
because it contains high voltage.
When removing a PCB or related component, after
unfastening or changing a wire, be sure to put the wire
back in its original position.
When you exchange IC and Transistor for a heat sink,
apply the silicon grease on the contract
section of the heat sink, Before applying new silicon
grease, remove all the old silicon grease. (Old grease
may cause damages to the IC and Transistor.)
2-2: FOCUS
1. Receive the monoscope pattern.
2. Turn the Focus Volume fully counterclockwise once.
3. Adjust the Focus Volume until picture is distinct.
2-3: WHITE BALANCE
NOTE: Adjust after performing CUT OFF adjustment.
1. Place the set with Aging Test for more than 10 minutes.
2. Receive the white 100% signal from the Pattern
Generator.
3. Using the adjustment control, set the brightness and
contrast to normal position.
4. Activate the adjustment mode display of Fig. 1-1 and
press the channel button (10) on the remote control to
select "R.BIAS".
5. Using the VOL. UP/DOWN button on the remote control,
adjust the R.BIAS.
6. Press the CH. UP/DOWN button on the remote control to
select the "R.DRIVE", "B.DRIVE", "G.BIAS" or "B.BIAS".
7. Using the VOL. UP/DOWN button on the remote control,
adjust the R.DRIVE, B.DRIVE, G.BIAS or B.BIAS.
8. Perform the above adjustments 6 and 7 until the white
color is achieved.
1. Synchro Scope
2. Digital Voltmeter
On-Screen Display Adjustment
1. In the condition of NO indication on the screen.
Press the VOL. DOWN button on the set and the
Channel button (9) on the remote control for more than
1 second to appear the adjustment mode on the
screen as shown in Fig. 1-1.
TV
00 OSD
23
Fig. 1-1
FUNCTION
OSD H
CUT OFF
H.VCO
H.PHASE
V.SIZE
V.SHIFT
R.DRIVE
B.DRIVE
R.BIAS
G.BIAS
B.BIAS
BRIGHT CENT
BRIGHT MAX
BRIGHT MIN
NO.
16
17
18
19
20
21
22
23
24
27
28
29
FUNCTION
CONTRAST CENT
CONTRAST MAX
CONTRAST MIN
COLOR CENT
COLOR MAX
COLOR MIN
TINT
SHARPNESS
FM LEVEL
SEPARATION
TEST MONO
TEST STEREO
Fig. 1-2
D-1
ELECTRICAL ADJUSTMENTS
2-8: OSD HORIZONTAL
1. Activate the adjustment mode display of Fig. 1-1.
2. Press the VOL. UP/DOWN button on the remote
control until the difference of A and B becomes
minimum. (Refer to Fig. 2-3)
"A"
TV
Fig. 2-1
00 OSD
23
Fig. 2-3
Fig. 2-2
NO.
04
14
15
16
18
20
D-2
NO.
21
23
24
27
28
29
ELECTRICAL ADJUSTMENTS
3-3: STATIC CONVERGENCE
NOTE
Adjust after performing adjustments in section 3-2.
NOTE
RGB
R
G
B
R
G
B
UPWARD/DOWNWARD SLANT RIGHT/LEFT SLANT
3-2: PURITY
Fig. 3-2-a
NOTE
Adjust after performing adjustments in section 3-1.
1. Receive the green raster pattern from color bar generator.
2. Adjust the pair of purity magnets to center the color on the
screen.
Adjust the pair of purity magnets so the color at the ends
are equally wide.
3. Move the deflection yoke backward (to neck side)
slowly, and stop it at the position when the whole screen is
green.
4. Confirm red and blue color.
5. Adjust the slant of the deflection yoke while watching the
screen, then tighten the fixing screw.
WEDGE
WEDGE
WEDGE
WEDGE POSITION
DEFLECTION YOKE
DEFLECTION YOKE SCREW
MAGNET SCREW
Fig. 3-2-b
PURITY MAGNETS
6 POLE MAGNETS
4 POLE MAGNETS
Fig. 3-1
D-3
ELECTRICAL ADJUSTMENTS
4. ELECTRICAL ADJUSTMENT PARTS LOCATION GUIDE (WIRING CONNECTION)
CRT PCB
CP806
03
R8
C
P8
03
B
R8
TP022
07
FB401
TU001
CP803A
TP023
J8
0
1
40
CP
CP802B
CP801
CD801
CR
T
DY
GND CRT
L503
DEGAUSS COIL
CP502
CP802A
S501B
AC IN
CD501
S501A
CD101A
CD101B
TV MT PCB
D-4
SPEAKER
BLOCK DIAGRAM
J702
CH. DOWN
J703
1
IC1001 AN7511
20
CH. UP
21
26
27
RGB Proc.2
OSD SW
CONTRAST BRIGHTNESS
73
67
POWER
69
70
SW
76
78
D106
I/O
IIC
TIM
INT
PWM
AD
RGB Proc.1
RGB MATRIX
COLOR CONT
MCU
CLK
Chroma
Proc.
ACC/C-BPF
APC/KILLER
TINT/DEMO
51
ROM
RAM
46
Hor.COUNT DOWN
45
AFC-1/H COINCIDENT
AFC-2 H PHASE
11
62
56 58
57
RY501
6
POWER CTL
Q507
FEED BACK
SW
Heater
V-OUT IC
IC401 STV9302B
CRT
V801
PUMP UP
SDA SCL
AMP
+
MEMORY IC
IC199
BR24L02F-WE2
VCC
6
2
DY
Q501
SWITCHING
TH501
L503
DEGAUSS COIL
RELAY
FEED BACK
Q502
13
H. OUTPUT
X601
3.579545MHz
IC501
PS2561AL1-1-V(W)
Q402
16
37 38
10
D501~D504
RECTIFIER
BLUE OUT
Q401
VCXO
12
16
Q803
H. DRIVE
13
GREEN OUT
Hor.Proc.
17
T501
Q802
52
Q607
Ver.Proc.
Ver SYNC SEP
Ver.COUNT DOWN
V RAMP
66
Q506
RELAY DRIVE
RED OUT
50
H.CTL
OSD
TU001
34
SPEAKER
SP1001
Q801
68
OS101
6
SOUND AMP
IC
2
8
4
ATT
VOL. UP
MICON/CHROMA IC
IC101 OEC7091C
VOL. DOWN
Q105
FB401
9
1
F501
10
HV
AC IN
E-1
E-2
CP601
D408
C406
CAUTION
D404
ATTENTION
R403
C435
R429_2
W010
W008
8V
R410
W009
C448_1
12V
T401
D509
HS501
R508
R522
Q501
W819
C514_1
C526_1
R501
D502
D501
IC501
C502
R5
17_
1
R8
03
_1
5_
R8
0
R8
07
_1
9_
C505
FH501
S501B
01
J8
CP801
W812
R1007
R121
D106_1
OS101
W029
CD501
00
R5
AS MARKED
.
S501A
Q803
C810_1
R814_1
CP802B
24
L501
F501
03
TP
0
D504
W002
8
CP
1
C8
TP023
R816
R538
R806
CCF073B
W031
C123_1
W030
W003
R802
C1008
W813
FH502
CP806
W053
J703
R509
T502
D604
R1001
W033
Q105
C808_1
R813_1
CP503
L801_1
IC1001
R809
D511
W830
TP022
C809_1
R815
R811
CP502
TH501_1
R512
R804
Q802
C1005
R502
R513
Q801
D603
R113
R112
R616
R109
W054
R110
CD101B
CD101A
W032
R617
W055
W056
W057
R620
R611
W034
W810
R605
C1003
C503
R518_1
W024
W037
W036
W035
W007
W038
R507
D517
D522
W803
W080
D515
R519
C623
W025
W023
C620_1
C621 W019
C630
W064
CP802A
C633
W072
R704_1
W811
F-1
D505
W832
C628
R615
C118
Q507
W026
S802Y
R607
W073
R614
R613
W808
C519
D514
R130
R119
W049
W027
W020
W063
C624
R621
R52
5
W021
C622
R606
B504
R537_1
W028
W040
W065
W016
R603
R505
D503
RY501
D528
C518
TP401
W817
Q606
C610_1
C508
W017
R515
W042
W068
D611
W066
W018
D403
W006
R6
29
W050
W051
R601
W816
W067
W809
W052
W070
D510
C447
CMF081B
C605
D602
W069
R416
W045
W046
W039
W041
C602
C521_1
C414
R405
R413_1
W047
W048
R415
R002
W044
W043
R604
R423
D606
X601
B501
C517_1
C507
R523
Q601
C103
W071
C418
Q502
R510
D508
47
R4
D513
C417
L001
C106
C509
D516
R418
R424
Q503
C601
W827
C511
C515
R527
R001
W833
C410_1
R504
R422
D521
R503
C516
R539
R506
D506
01
D512
4
IC
R542
D518
R514
C606
R602
R608
HS402
S802X
W013
C422
R445
W058
W005
R449
Q603
W059
R427
R401
R448
W834
C617
W060
D406
C446
R417
W061
W001
Q401
D409
R409_1
40
HS
R421
L401
R402
D001
Q402
W011
Q602
FB401
C4
43
R446
C427
COL
D412
C007_1
C401
C4
37
C440
W015
W062
+B
25V
CP
401
C434
R408
HEATER
180V
D411
D405
C403
ABL
D410
AFC
CP803A
GND
TU001
W004
J1001
J702
SW101
SW102
SW103
SW104
SW105
F-2
F-3
C001
R004 R003
C004_1
R419
C501
C510
R129
C615
R105_1
41
C609
C616
R627
R610
CMF081B
C627
C626
R618
C112
R143_1
R115
R126
C614
C101
IC199
C604
C603
C104
C629
R107
R1003
R1008
C1001
R1004
R101
R104
1
R102
C107
C108_1
R108
C105
R106_1
R124
C1004
R1005
R609
C102
64
IC
10
R531
R532
R134_1
R125
R127
R116_1
Q506
R103
R516_1
C513_1
CCF073B
R702
R701
R128
C612
R703
Q607
25
Q505
R420
F-4
61
60
4.9
59
0.3
58
56
68
LPF
6bB AMP
4.9
27
1
25
100 1/4W
AUDIO_IN
B C612
VIDEO_IN
1 B
NC
AUDIO_IN
AUDIO_OUT
4.9
P.CON+5V
5.5
7.2
C617
7.2
10V 100 YK
GND
R629
22 3W
5.5
5V REG
Q603
KTC3203_Y
19
20
21
22
23
24
18
5.6
0 2.9 2.8
5.0 0 NC 2.0
NC
4.9
NC
C001
NC
0.01 F
4.94
L001
TUNER+5V
3.3uH 0305
3
10V 100 YK
C606
R602
22P CH 100BT3R537
3.579545MHz
S802X
5V REG
Q602
KTC3203_Y
R604
C615
C609
TU_VIDEO
NC
NC
NC
NC
NC
D602
C616 MTZJ9.1B
1
TU_AUDIO
C610_1
D611
16V 47 YK
MTZJ12B
NC
R004
10
AT+5V
KEY1
POWER_ON
KEY2
REMOCON
4.93
11
13
TU_AUDIO
2.9
17
20
C007_1
0.022 F
R002
15K 1/2W
IIC_OFF
SDA
SDA
SCL
SCL
GND
R001
P.CON+B
15K 1/2W
TU_VIDEO
MTZJ33B
TU001
115-V-KA35ARH
C004_1
NC
0.022 B
32
16
SW105
EVQ21505R
POWER
NC
15
1/2W
NC
IIC_OFF
D001
R603
120
NC
AFT
14
560
SW104
EVQ21505R
VOL DOWN
SW103
EVQ21505R
VOL UP
SW102
EVQ21505R
SW101
EVQ21505R
CH DOWN
CH UP
OS101
KSM-713SY
4.8
1
Vout
4.9
B+ 2
2.7K
4.9
R101
R126
CP601 A2001WR2-6P
12
21
560
5V REG
5.5 Q601
KTC3203_Y
8.8
TEST POINT
SDA
100
3.3
R128
GND 3
C123_1
10
SCL
100
R003
4.95
R143_1
50V 10 YK
1/4W
SLR-342VCT32
270
R121
POWER ON/ON TIMER
D106_1
C605
C603
C604
0.022 F
1M
ON_TIMER
2.9
0.01 B
R601
5.1
17
3.4
AUDIO_MUTE
VIDEO_IN
100 1/4W
16
0
X601
C602
C601
15
3.4
FROM/TO SOUND/AV
220 1/2W
P.CON+5V
2.2
14
5.0
13
4.9
0.1
12
3.4
W833
C108_1
11
0.8
50V 1 KA
10
2.0
W816
9
1.2
R104
C103
0.01 B
R102 C104
W809
C102
8
0
0.001 B
7
4.9
R103
C107
470P B 1K 0.01 B
1K
C106
220P B 50V 1 KA
5
3
4
0 NC 5.0
5.0 0
C105
MTZJ8.2B
C614
2.0
80
AT+5V
2.3
VCXO
NC
1SS133
TUNER+5V
26
XO
MICON/CHROMA IC
IC101
OEC7091C
SWITCHING
Q105
KRA102MAT
ATT
VCO
6.3V 470 YK
4.9
D604
R605
2.0
NC
2.3
NC
5.7
78
0
47K
79
R129
4.7K
R134_1
4.8
34
32
MCU
CLK
D603
18
CLK CONT
CPU core
Chroma Proc.
ACC/C-BPF
APC/KILLER
TINT/DEMO
Vldeo Proc.
C-TRAP/YDELAY
SHARPNESS
BLACK STRETCH
Y MUTE
77
NC
39
36
AD
0.01 B
30
PWM
NC
3.1
NC
8.8
31
CCD
INT
AT+5V
C620_1
19
ON_TIMER
POWER_FAIL
4.6
29
DEGAUSS_H
C621
16V 47 YK
28
4.9
1K
RGB Proc.1
RGB MATRIX
COLOR CONT
TIM
74
R127
C622
33
71
IIC
2.9
75
IIC_OFF
RGB Proc.2
OSD SW
CONTRAST
BRIGHTNESS
Power Manage.
MCU RESET
P-ON CONT
76
47K
X-RAY
GND
35
70
AUDIO_MUTE
73
4.9
UNREG+12V
V_FEEDBACK
50V 1 KA
AUDIO_OUT
4.0
72
R606
0 22K 1/4W
I/O
NC
4.9
NC
FROM/TO TV POWER
UNREG+12V
POWER_FAIL
2.6
3.3
R125
OSD
V_OUT
38
DECODER
4.5
4.9
REMOCON
X-RAY
Hor.Proc.
SYNC SEPA/Hor.VCO
Hor.COUNT DOWN
AFC-1/H COINCIDENT
AFC-2 H PHASE
SDA/SCL
ROM
RAM
100 1/4W
37
67
IIC BUS
4.9
POWER_ON
22K
TF
0.01 B
65
R115
H_SYNC
8V REG
Q606
KTC3203_Y
R607
4.6
4.9
KEY2
B.OUT
50V 2.2 KA
Ver.Proc.
4.9
2.2K 1/4W
R116_1 2.2K
C624
B
0.01
C626
C627 12K
R610
C628
10K 1/4W
50V 1 KA
G.OUT
C623
69
R113
X-RAY
R.OUT
MCU GND
66
2.2K 1/4W
KEY1
H_OUT
8.8
2.4
AFT
P.CON+5V
W808
H_SYNC
4.9
22K 1/4W
R112
H_CTL
R620
R611
R609
120K
R627
R616
100
ABCL
NC
0 4.6 NC2.3 3.2 3.2
3.5 8.0
0
8.0 4.6
4.9
0
3.4 3.7
0 NC
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
4.9
57
1K 1/4W
R615
0
C629
V_FEEDBACK
8.5
11.3
R119
62
10V 470 YK
40
63
P.CON+B
GND
7.9
64
CLAMP
680 1/4W
10K
R608
2
C630
0.01
5
FROM/TO DEFLECTION/CRT
V_OUT
D606
10K 1/4W
100
R107
SCL
R130
4.7K
R106_1
SDA
10K
4.7K
R105_1
R124
R108
C112
AT+5V
100P CH
10K 1/4W
R.OUT
R109
10K 1/4W
0.01 B
G.OUT
R110
100 1/4W
C101
R613
S802Y
H.CTL
Q607
KTC3875S-GR-RTK/P
5.6
H_CTL
DEGAUSS_H
6.3V 470 YK
22K
100 1/4W
C118
H_OUT
R618
4.9
220 1/4W
1K 1/2W
C633
4.9
R614
4.9
P.CON+5V
50V 10 YK
R621
11E1-EIC ABCL
R617
47K 1/4W
PROTECT
SDA
VSS
SCL
E2
MODE
4.9
(TV MT PCB)
E1
VCC
MEMORY IC
IC199
BR24L02F-WE2
1
E0
PCB070
CMF081
G-1
ARE
G-2
TO SOUND/AV
10.3
GND
10K
R517_1
SOUND+B
10K
R531
W832
D505
21DQ09N
1W
C519
C518
500V 470P B
D517
1SS133
1
SOUND_GND
FROM/TO DEFLECTION/CRT
RY501
R500
R510
200V 220 YK
15
16
17
1SS133
X-RAY
22K 1/2W
4.8
UNREG+12V
AT+5V
GND
D515
1SS133
18 NC
D522
1SS133
D514
1SS133
R515
B
FEED BACK
SWITCHING
Q507
KTC3198
R519
2
R507
27 1/4W
R518_1
1.2K 1/4W
680 1/4W
MTZJ5.6B
9.5
D528
0.1
6.0
5.6K +-1%
R512
5.5
0.001
C513_1
R513
1
2
10.5
FEED BACK
IC501
PS2561AL1-1-V(W)
11.5
D511
1/4W
9.5
120K 1/2W
W810
C511
50V 1 KA
C510
0.1
DEGAUSS_H
NC
2.2K
250V 0.0047 KX
MTZJ12B
R537_1
4.9
11.3
W830
C501
1SS133
C508
21DQ09N
0.0082
HS501
763WSAA029
1.2K 1/4W
D513
W5RH3.5X5X1.0
C515
14
B504
132.3
D521
16V 1000 YK
C516
R505
R516_1
13
100 1/4W
50V 1 YK
R504
1N4937
R502
1SS133
220
12
1/4W
D512
R509
1/4W
D508
1/4W
R539
10
D516
10.0
1K 1/4W
0.1
1SS133
1/4W
1K
4.8
D518
R506
POWER CTL
Q502
KTC3198
R503
0.047 M
11
POWER_FAIL
100
220 1/2W
0.68
1W
3
R542
C509
W827
S
0.1
10.3
R508
D506
G
4.8
6.6
P.FAIL
Q505
KTA1504S-GR-RTK/P
MTZJ18B
W819
10.3
POWER AMP
Q501
2SK3563(ORION_Q)
B501
C514_1
W5RH3.5X5X1.0
S501A
S501B
2KV 820P RR
BLADE
WIDE
NC
C507
1.2M 1/2W
R522
D509
NC
144.0
2W
FROM/TO MICON/CHROMA/TUNER
T502
81291084
144.0
WHITE
R527
5.6K 1/4W
GND
1.7
4A 125V
R523
47K 1/4W
R525
COIL,LINE FILTER
L501
ELF15N010AP
FH502
EYF-52BCY
1.5
MTZJ18B
C526_1
C503
0.22 1W
1.2M 1/2W
R514
5W C
500V 0.001 B
D502
D503
1N4005-EIC
1N4005-EIC
3.3
1N4005-EIC
C502
500V 0.001 B
D504
1N4005-EIC
D501
FH501
EYF-52BCY
R538
4A125V
F501
4A125V
1.5M 1/2W
C505
CP503
003P-2100
B59203-S1060-B14
C521_1
R501
2KV 820P RR
TH501_1
P.CON+B
135.0
C517_1
AC120V_60Hz
CD501
P201-2469-2
BLACK
W834
10K
+B
UNREG+12V
PROTECT DRIVE
Q503
2SA1624
135.0
0
RU2AM-EIC
100V 10 MHE
CP502
A1561WV2-2P
D510
3 ALKS321
2.7M 1/2W
+-10%
DEGAUSS COIL
L503
DYD1-3020-80
16V 1000 YK
RELAY DRIVE
Q506
KTC3875S-GR-RTK/P
R532
PCB070
CMF081
FUSE.
4A 125V
G-3
ARE
G-4
E
GND
GND
GND
CLAMP
CLAMP
CLAMP
CLAMP
CLAMP
G.OUT
G.OUT
G.OUT
G.OUT
G.OUT
R.OUT
R.OUT
R.OUT
R.OUT
R.OUT
B.OUT
B.OUT
B.OUT
B.OUT
D403
1/4W
V801
A34AGT13X98(DL)
13
330 1/2W
R410
1/4W
R814_1
BLUE OUT
Q803
2SC1473A
3.2
95.4
2.7
R
G
B
2.7
TO DY
6
14
5 CP401
A1561WV2-A5P
4
3
NC
R429_2
15
TP022
16
TP024
TP023
2
1
4.7
3W
R401
2.7K 1/4W
15K 1W
R806
R807_1
2.7K 1/4W
R804
R803_1
R409_1
15K 1W
D411
AU02A-EIC
FROM/TO MICON//CHROMA/TUNER
98.4
2.7
5 7 1
50V 10 YK
C427
R413_1
R416
1 1/2W
1.8K 1/2W
100V 22 YK
C434
10K +-1%
R408
D412
MTZJ5.1B
C447
50V 1 YK
R422
HS401
763WSAA029
9
10
8
6
11
R415
2.2 1/2W
C418
470
2.7K
50V 22 YK
C417
R417
22K 1/4W
10K 1/4W
470 1/4W
25V 470 YK
R420
R418
R419
R424
2.2K 1/2W
C422
100V 0.15
MKT
11E1-EIC
100.6
C808_1
12
GREEN OUT
Q802
2SC1473A
3.2
2.7K
R423
100
RED OUT
Q801
2SC1473A
3.2
CP801
131001101K1
3.5
R816
7
25.0
270 1/4W
NC
180V
C810_1
180V
470P CH
1/4W
R811
180V
2.7K
NC
R815
GND
270 1/4W
6
12.0
GND
R805_1
5
0
NC
470P CH
C414
4
2.0
HEATER
270 1/4W
3
25.0
B2013H02-4P
HEATER
L801_1
2
3.5
NC
180V
AMP
CP803B
35V 100
YK
C809_1
THERMAL
PROTECTION
PUMP
UP
B.OUT
CP803A B2013H02-4P
HEATER
HEATER
1
GND
GND
2
1/4W
STV9302B
R813_1
IC401
R809
V-OUT IC
GND
CP802B
B2013H02-5P
2.7K
CP802A
B2013H02-5P
470P CH
2.7K 1/4W
15K 1W
R802
FROM MICON/CHROMA/TUNER
100uH 0606
X-RAY
27K M+-1%
C401
250V 1 MHE
L401
4.7mH
1/2W
R402
68
FOCUS
CP806
P.CON+B
4.3
5 NC
6.4
D410
99.6
PCB110
CCF073
R449
560 1/2W
R448
560 1/2W
D408
11E1-EIC
R421
220K 1/4W
100V 0.1
MHE
180K 1/4W
C435
C448_1
250V 22
YK
C403
35V 470 YK
R445
AU02A-EIC
D405
AU02A-EIC
MTZJ6.2B
D404
11E1-EIC
D409
11E1-EIC
101.6
GND 0
8
E8
GND
500V 220P B
UNREG+12V
G-5
96.4
J801
ISMP01S
E12
NC 4
25.0 E25
3
C406
D406
ABL
GND 0
11
SCREEN
SCREEN
R403
2W
FOCUS
10K 1/4W
R447
B+
AFC
HEA
7.0
10 TER
150
48.0
VIDEO
132.5
132.5
W817
+B
HV
HS402
763WSA0043
TP401
COL
2KV 0.001 B
C443
R427
H.OUTPUT
Q401
2SC5885
C819_1
GND
130.0
130.0
100 1/4W
C410_1
R405
1K 1/4W
FROM/TO TV POWER
470 1/2W
R446
0.3
4
FB401 FNI14B002_M
11
0.001 CH
H_OUT
H_SYNC
6
10
C446
ABCL
50V 22 YK
V_OUT
C440
H.DRIVE
Q402
2SC1627_Y
27.0
GND
V_FEEDBACK
3
NC 2
1
C437
T401
STP-03Q24
P.CON+B
CAUTION
ARE
PCB070
CMF081
G-6
ACCESSORY
UM-4
BT001
MNAAA(R03)
UM-4
BT002
7
TM101
RC-EH050(CT-859)
MNAAA(R03)
R703
W811
19
AUDIO 2
AUDIO_IN
TO MICON/CHROMA/TUNER
2
10 1/4W
47K
R702
R704_1
68
R701
20
VIDEO 2
VIDEO_IN
820
GND
EAR PHONE_JACK
J1001
MSJ-035-12A_PC
2
R1007
3
1
C1008
16V 47 YK
W812
68 1/2W
18
FROM TV POWER
CD101A
CH012006
SOUND_GND
SOUND+B
SPEAKER
1
CD101B
CH012007
8.2
3.5
SP1001
S08F77
8 OHM
3.4
SOUND AMP IC
IC1001
AN7511
GND
FROM MICON/CHROMA/TUNER
3
5.1
2
0
1
0.3
W813
4
R1001
AUDIO_MUTE
3.9
47K 1/4W
R1003
P.CON+5V
68K
C1001
17
C1005
50V 10 YK
C1004
0.0015
68K
GND
R1008
C1003
50V 1 KA
270K
R1005
100K
R1004
W803
AUDIO_OUT
0.1
ARE
PCB070
CMF081
G-7
G-8
WAVEFORMS
MICON/CHROMA/TUNER
1 0.5V 2ms/div
6 1V 20s/div
11 200V 20s/div
20V 20s/div
7 1V 20s/div
12 10V 5ms/div
DEFLECTION/CRT
200mV 20s/div
8 0.5V 5ms/div
0.5V 5ms/div
5 1V 20s/div
20V 20s/div
10 2V 20s/div
13 10V 5ms/div
14 50V 20s/div
15 50V 20s/div
NOTE: The following waveforms were measured at the point of the corresponding
balloon number in the schematic diagram.
H-1
WAVEFORMS
16 50V 20s/div
SOUND/AV
17 0.5V 1ms/div
18 1V 1ms/div
19 200mV 500s/div
20 500mV 20s/div
NOTE: The following waveforms were measured at the point of the corresponding
balloon number in the schematic diagram.
H-2
107
202
202
202
201
105
102
104
119
202
201
105
108
201
PCB110
(CRT PCB ASS'Y)
103
119
205
105
201
106
205
203
105
106
106
101D
PCB070
(TV MT PCB ASS'Y)
101B
204
101C
206
109
101A
101
I-1
113
113
112
111
110
115
114
114
110
114
114
I-2
110
TSB P/N
Reference No.
Description
101
101A
101B
101C
101D
72781144
72799312
72799477
72799476
72799757
7A701A312A
701WPJC918
713WPAA203
713WPAA202
735WPBB315
102
103
104
105
106
107
108
109
75007550
72794734
72799717
72796255
72798769
75007551
72795687
72799738
702WPAA852
899HV3T000
726000A091
800WR0A011
800WQ0A024
722549A709
741WUA0021
735WPAA837
CABINET BACK
HOLDER ANODE WIRE
SHEET CRT SERVICEMAN
SHEET CRT SUPPORT (D)
FELT SHEET
SHEET RATING
SPRING EARTH
SPEAKER HOLDER
110
111
112
113
114
115
116
117
118
119
72783505
72799981
72782852
72798721
72782855
75007552
72783478
75004935
75007553
72799965
723000D248
791WHAA122
791WHAA137
792WHAA052
792WHAA179
793WCDD496
JB5ND200
J3X30302B
J3X00321A
769WSAA011
SHEET BARCODE
FILM BAG
LIGHTRON SHEET
PACKAGE TOP
PACKAGE BOTTOM
GIFT BOX
POLYBAG INSTRUCTION(RED CAUTION)
GUARANTEE CARD
INSTRUCTION BOOK(E/S)
WASHER CRT T=1
201
202
203
204
205
206
72781281
72781279
72798786
72798790
72781255
72798791
8121J50B5U
8117540A6U
810763080U
811063080U
8109I3080U
8110630A0U
J1-1
TSB P/N
Reference No.
Description
RESISTORS
R401
R408
R409
R429
R447
R500
R501
R514
R517
R518
R525
R538
R542
R629
R803
R805
R807
72794595
72796016
72781720
72781702
72781689
72794631
72795522
72794633
72781671
72795514
72781692
72795500
72781685
72781701
72781674
72781674
72781674
R4X5T6273F
R4X5T6103F
R4K1T4273F
R3K58B4R7J
R3K58A151J
R0G3K2275K
R5X2CD3R3J
R63881R22J
R3K581010J
R4X5T6562F
R3K58A1R5J
R002T2155J
R3K581R68J
R3K58B220J
R3K581153J
R3K581153J
R3K581153J
R,METAL
R,METAL
R,METAL
R,METAL OXIDE
R,METAL OXIDE
RC
R,CEMENT
R,FUSE
R,METAL OXIDE
R,METAL
R,METAL OXIDE
RC
R,METAL OXIDE
R,METAL OXIDE
R,METAL OXIDE
R,METAL OXIDE
R,METAL OXIDE
! C418
! C434
C437
! C443
! C447
C448
! C502
! C503
! C505
! C508
! C514
! C515
! C517
! C518
! C519
! C521
! C526
C819
72795628
72794396
72795104
72783441
72794416
72796351
72795629
72795629
72795567
72795579
72795580
72794425
72795580
72796329
72794425
72794411
72797379
72795578
E02LT3471M
E02LU8220M
P4J7F3474J
P4G8FJ912H
E02LU5010M
E02LTD220M
C0JTB0513K
C0JTB0513K
P2122B104M
CD39E0MQ3M
C0PLRR7W2K
E02LT2102M
C0PLRR7W2K
C0JTB05Q2K
E02LT2102M
E62NFC221M
E02LFC221M
C0JBB0713K
CE
CE
CMPP
CMPP
CE
CE
CC
CC
CMP
CC
CC
CE
CC
CC
CE
CE
CE
CC
D001
D106
D403
D404
D405
D406
D408
D409
D410
D411
D412
D501
D502
D503
D504
D505
D506
D508
D509
D510
D511
D512
D513
D514
D515
D516
D517
D518
D521
D522
D528
D602
D603
D604
D606
D611
72794465
72795529
72794488
72794490
72794472
72794488
72794488
72794488
72794472
72794472
72794469
72795626
72795626
72795626
72795626
72794480
72795541
72794491
72795541
72795545
72794491
72794491
72794480
72794491
72794491
72794483
72794491
72794491
72794487
72794491
72794489
72794481
72794491
72794486
72794488
72794487
D97U03301B
0021721150
D2WT011E10
D97U06R21B
D2WTAU02A0
D2WT011E10
D2WT011E10
D2WT011E10
D2WTAU02A0
D2WTAU02A0
D97U05R11B
D2WXN40050
D2WXN40050
D2WXN40050
D2WXN40050
D28T21DQN9
D97U01801B
D1VT001330
D97U01801B
D2WXRU2AM0
D1VT001330
D1VT001330
D28T21DQN9
D1VT001330
D1VT001330
D2WXN49370
D1VT001330
D1VT001330
D97U01201B
D1VT001330
D97U05R61B
D97U09R11B
D1VT001330
D97U08R21B
D2WT011E10
D97U01201B
DIODE,ZENER
LED
DIODE SILICON
DIODE,ZENER
DIODE SILICON
DIODE SILICON
DIODE SILICON
DIODE SILICON
DIODE SILICON
DIODE SILICON
DIODE,ZENER
DIODE SILICON
DIODE SILICON
DIODE SILICON
DIODE SILICON
DIODE SCHOTTKY
DIODE,ZENER
DIODE,SILICON
DIODE,ZENER
DIODE SILICON
DIODE,SILICON
DIODE,SILICON
DIODE SCHOTTKY
DIODE,SILICON
DIODE,SILICON
DIODE SILICON
DIODE,SILICON
DIODE,SILICON
DIODE,ZENER
DIODE,SILICON
DIODE,ZENER
DIODE,ZENER
DIODE,SILICON
DIODE,ZENER
DIODE SILICON
DIODE,ZENER
IC101
IC199
! IC401
! IC501
! IC1001
72795532
75007546
72783444
72794512
72795537
I56F07091C
S3X001VE03
I0WTD9302B
000220002W
I01DP75110
IC
MEMORY DATA
IC
PHOTO COUPLER
IC
Q105
72795555
TPATB03003
COMPOUND TRANSISTOR
!
!
!
!
!
!
!
!
!
!
!
!
CAPACITORS
DIODES
ICS
TRANSISTORS
J2-1
TSB P/N
Reference No.
Description
TRANSISTORS
!
!
!
!
!
Q401
Q402
Q501
Q502
Q503
Q505
Q506
Q507
Q601
Q602
Q603
Q606
Q607
! Q801
! Q802
! Q803
72795478
72795480
72795539
72794577
72794569
75007547
75007548
72794577
72795476
72795476
72795476
72795476
75007548
72798340
72798340
72798340
TC1G058850
TC5T01627Y
T25F035630
TCATC31980
TA3T016240
T6AJ1504S0
T8AJ3875S0
TCATC31980
TCAT032034
TCAT032034
TCAT032034
TCAT032034
T8AJ3875S0
TCKT1473A0
TCKT1473A0
TCKT1473A0
L001
L401
! L501
! L503
L801
T401
! T502
72796518
72795560
72798941
72798932
72795941
72796466
72796474
02167F3R3J
021L75472J
0293000130
028B140033
021673101K
045011001L
0481291084
COIL
COIL
COIL,LINE FILTER
COIL,DEGAUSS
COIL
TRANS,HORIZONTAL DRIVE
TRANSFORMER,SWITCHING
J702
J703
! J801
! J1001
72795495
72795494
72783271
72796730
060Q401112
060Q401111
066F120020
060J121014
RCA JACK
RCA JACK
SOCKET,CATHODE RAY TUBE
JACK,RCA,3.5
SW101
SW102
SW103
SW104
SW105
72794688
72794688
72794688
72794688
72794688
0504101T34
0504101T34
0504101T34
0504101T34
0504101T34
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
PCB070
PCB110
75007549
72783447
A3X003V070L
A3X001V110L
TV MT PCB ASS'Y
CRT PCB ASS'Y
B501
B504
BT001
BT002
CD501
CP401
CP502
CP503
CP601
CP801
CD101A
CD101B
CP802A
CP802B
CP803A
CP803B
EL001
EL002
F501
FB401
FH501
FH502
OS101
RY501
S101
S102
SP1001
TH501
TM101
TU001
V801
X601
72794357
72794357
72783174
72783174
75005151
72796822
72796821
72796825
72799047
72799048
72783129
72783128
72796751
72796751
72796750
72796750
72797070
72797069
72795538
72796666
72794496
72794496
72783448
72796047
72798395
72798400
75005271
72794693
72795473
72783421
72796972
72783450
024HT03553
024HT03553
141U004016
141U004016
120Q414913
069S450089
069S420110
069W01001A
069S260639
069W010340
06CH012006
06CH012007
067U005049
067U005049
067U004029
067U004029
124120301A
124116281A
081PC04005
043214050F
06710T0009
06710T0009
077Q000025
0560V20115
WBL6026038
WCL6834038
070Y132031
D8EE0B1400
076N0EH050
0163300022
098Q1404D1
100BT3R537
CORE,BEADS
CORE,BEADS
BATTERY,MANGAN
BATTERY,MANGAN
CORD AC BUSH
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CORD CONNECTOR
CORD CONNECTOR
WIRE HOLDER
WIRE HOLDER
WIRE HOLDER
WIRE HOLDER
EYE LET
EYE LET
FUSE
TRANSFORMER,FLYBACK
HOLDER,FUSE
HOLDER,FUSE
REMOTE RECEIVER
RELAY
FLAT CABLE AWM2468
FLAT CABLE AWM2468
SPEAKER
DEGAUSS ELEMENT
TRANSMITTER
RF UNIT
CRT W/DY
CRYSTAL
!
!
!
!
!
!
!
!
!
TRANSISTOR SILICON
TRANSISTOR SILICON
FET
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR SILICON
TRANSISTOR SILICON
TRANSISTOR,SILICON
TRANSISTOR, SILICON
TRANSISTOR, SILICON
TRANSISTOR, SILICON
TRANSISTOR, SILICON
TRANSISTOR SILICON
TRANSISTOR SILICON
TRANSISTOR SILICON
TRANSISTOR SILICON
COILS &TRANSFORMERS
JACKS
SWITCHES
P.C.BOARD ASSEMBLIES
MISCELLANEOUS
J2-2
2SC5885
2SC1627_Y(TPE2)
2SK3563(ORION_Q)
KTC3198-AT(Y,GR)
2SA1624-AA
KTA1504S-GR-RTK/P
KTC3875S-GR-RTK/P
KTC3198-AT(Y,GR)
KTC3203_Y-AT
KTC3203_Y-AT
KTC3203_Y-AT
KTC3203_Y-AT
KTC3875S-GR-RTK/P
2SC1473A-TA-(RQ)
2SC1473A-TA-(RQ)
2SC1473A-TA-(RQ)
3.3 UH
4.7 MH
ELF15N010AP
DYD1-3020-80
100 UH
STP-03Q24
81291084
AV1-09AD-3
AV1-09AD-4
ISMP01S
MSJ-035-12A_PC
EVQ21505R
EVQ21505R
EVQ21505R
EVQ21505R
EVQ21505R
CMF081B
CCF073B
W5RH3.5X5X1.0
W5RH3.5X5X1.0
MNAAA(R03)
MNAAA(R03)
P201-2469-2
A1561WV2-A5P
A1561WV2-2P
003P-2100
A2001WR2-6P
131001101K1
CH012006
CH012007
B2013H02-5P
B2013H02-5P
B2013H02-4P
B2013H02-4P
XRY20X30BD
XRY16X28BD
51MS040L
FNI14B002_M
EYF-52BCY
EYF-52BCY
KSM-713SY
ALKS321
AWG26 4C BLACK 260MM
AWG26 5C GRAY 340MM
S08F77
B59203-S1060-B14
RC-EH050(CT-859)
115-V-KA35ARH
A34AGT13X98(DL)
HC-49U
J2-3
TOSHIBA CORPORATION
1-1, SHIBAURA 1-CHOME, MINATO-KU, TOKYO 105-8001, JAPAN
SERVICE MANUAL
COLOR TELEVISION
13A26
-SUMMARYThis supplement serves as an update to the original 13A26 Service Manual, file number 050-200603.
Please refer to this Supplement in conjunction with the original Service Manual when servicing this
model.
SERVICE INSTRUCTION
FILE NO. 053-200603GRA
DATE:Jun.,2006
RANK:
A
Product: COLOR TELEVISION
Model: 13A26/13A26C
NOBUO TSUKAMOTO
MANAGER
TEC-HQ 2TEC SEC4
PART NO.
DESCRIPTION
MFR'S VERSION B
TSB P/N
R402
!
R406
PART NO.
R638U2680J
R3K181010J
R,METAL
OHM 1W
DESCRIPTION
R,FUSE
68
72781668
OHM 1/2W
TSB P/N
CAUSE
DELETE
C401
E5EZTD010M
L401
021L75472J
CE
UF 250V
COIL
4.7 MH
72795858
72795560
PCB070
72783445
72783445
PCB110
72783447
72783447
13A26C
MFR'S VERSION A
REF NO.
PART NO.
DESCRIPTION
MFR'S VERSION B
TSB P/N
R402
!
R406
PART NO.
R638U2680J
R3K181010J
R,METAL
OHM 1W
DESCRIPTION
R,FUSE
68
72781668
OHM 1/2W
TSB P/N
72781748 PCB VERSION UP.
DELETE
C401
E5EZTD010M
L401
021L75472J
CE
UF 250V
COIL
4.7 MH
72795858
72795560
PCB070
72783446
72783446
PCB110
72783447
72783447
CAUSE
CP601
D408
C406
C435
CP803A
R542
D509
HS501
R522
R508
W819
C526
03
05
R8
R8
L501
07
R8
C505
RISK OF FIRE
- REPLACE AS MARKED.
R5
17_
C502
TP
02
4
D504
D501
R538
F501
W003
FH502
C819_1
C810
R814_1
R5
R806
00
R1001
D603
R809
CD501
C808
R813_1
Q801_1
Q803_1
R816
S501A
R811
S501B
FH501
TP023
Q105
W033
J8
W030
CP801_1
W807
SW104
R121
SW103
D106_1
OS101
W029
SW102
W812
01
R113
R112
W031
W032
CP802B
W053
SW101
Q501
B
03
P8
C
CCF073B
D604
W034
W002
R513
D517
W803
W019
C620_1
C1005
C123_1
W054
R110
R109
CD101B
CD101A
J702
R617
R616
W808
W055
W056
W057
R611
R620
CP802A
C633
CP806
R804
C809
R815
W037
W036
W035
L801
R802
W038
W080
C630
CP503
W836
Q802_1 TP022
W021
D502
IC501
R518_1
D515
R605
C628
R501
R509
W007
D505
R515
D514
W832
S802Y
R607
R615
J703
D522
TH501_1
R512
D525
W024
W023
R502
D507
IC1001
R613
C118
C623
W025
C503
CP502
R507
W020
W063
W064
C624_1
R621
W073
R614
Q507
R519
C621
C622
R606
B504
W018
D403
R537
W026
C610_1
W065
W016
R603
R505
C519
R130
W066
C518
TP401
W817
D503
RY501
D528
W017
W027
R119
D611
W040
W068
W816
W067
29
Q606
W049
R601
CMF081B
W069
C447
C605
D602
C517_1
W006
R52
W050
W071
W028
W809
C602
W070
R416
W042
C103
C515
Q502
R510
R514
C508
R523
W051
X601
R604
R423
D606
W052
C106
C521_1
W047
W045
W046
W039
W041
C601
D521
D513
C514_1
B501
D510
L001
R6
W827
R418
C507
Q603
R503
R4
C418
Q503
Q601
R602
W833
W834 R527
C509
D508
D516
47
T502
R413_1
R405
W048
R422
C606_1
W059
W058
R608
R415
R002
W044
W043
W060
D506
S802X
C410_1
R504
R417
D512
D406
W837
C516
IC
R506
R520
C511
C417
R407
R445
C617
HS402
C446
R427 W005
R409
D409
Q401
C427
COL
01
S4
C414
W061
W001
40
W011
R421
L401
R402
TU001
43
Q402
R449
R424
R001
FB401
C4
R448
C422
AFC
37
R446
W013
+B
25V
C4
C440_1
D001
W015
GND
12V
T401
C401
C007_1
D412
R408
Q602
401
8V
CP
C434
W062
180V
C448_1
R410
W008
D405
W010
D411
C403
ABL
D410
W009
HEATER
R429
W004
CAUTION
D404
R403
SW105
W072
R704_1
W811
ADD: R402
C401
L401
13A26/13A26C
HEATER
GND
NC
NC
180V
180V
NC
180V
R423
12
D403
R410
9
10
8
6
11
1/2W
C427
100.6
98.4
BLUE OUT
Q803
2SC1473A
3.2
95.4
2.7
R
G
B
5 7 1
50V 10 YK
R413_1
R416
R422
HS401
763WSAA029
1.8K
GREEN OUT
Q802
2SC1473A
3.2
2.7
2.7
V801
A34AGT13X98(DL)
13
R415
2.2 1/2W
2.7K
C418
470
50V 22 YK
C417
R419
10K 1/4W
R417
22K 1/4W
25V 470 YK
R420
R418
C422
470 1/4W
330 1/2W
11E1-EIC
2.2K 1/2W
R424
1/4W
1 1/2W
100
RED OUT
Q801
2SC1473A
3.2
CP801
131001101K1
3.5
R816
25.0
GND
270 1/4W
6
12.0
B2013H02-4P
HEATER
C810_1
5
0
B.OUT
CP803B
470P CH
B.OUT
35V 100
YK
C414
NC
180V
AMP
2.0
R.OUT
R815
3
25.0
B.OUT
G.OUT
270 1/4W
2
3.5
R.OUT
L801
G.OUT
CP803A B2013H02-4P
HEATER
1
HEATER
GND
2
GND
THERMAL
PROTECTION
PUMP
UP
R814_1
STV9302B
R.OUT
470P CH
IC401
G.OUT
CLAMP
270 1/4W
C809_1
V-OUT IC
CLAMP
2.7K 1/4W
B.OUT
GND
1/4W
B.OUT
R811
R.OUT
R.OUT
2.7K
G.OUT
G.OUT
GND
GND
CLAMP
C808_1
GND
CLAMP
(CRT PCB)
1/4W
CLAMP
F
CP802B
B2013H02-5P
R813_1
FROM MICON/CHROMA/TUNER
E
CP802A
B2013H02-5P
R809
2.7K
470P CH
100uH
TO DY
6
14
15
16
C434
100V 22 YK
+-1%
10K
3
R429_2
NC
TP022
TP023
1
4.7
3W
R401
R409_1
R806
2.7K 1/4W
1W
15K
R807_1
1/4W
2.7K
1W
R804
15K
R805_1
R803_1
CP401
A1561WV2-A5P
2.7K 1/4W
D411
AU02A-EIC
FROM/TO MICON//CHROMA/TUNER
TP024
15K 1W
R802
D412
MTZJ5.1B
C447
50V 1 YK
R408
X-RAY
27K M+-1%
C401
250V 1 MHE
L401
1/2W
R402
68
4.3
8
96.4
GND
E8
5 NC
500V220P B
D404
D406
99.6
J801
ISMP01S
PCB110
CCD004
D405
11E1-EIC
D409
D410
11E1-EIC
AU02A-EIC
2W
AU02A-EIC
R447
150
MTZJ6.2B
6.4
UNREG+12V
101.6
GND 0
8
E12
NC 4
25.0 E25
3
C406
ABL
AFC
HEA
10 TER
9
P.CON+B
GND 0
11
R403
10K 1/4W
SCREEN
B+
SCREEN
FOCUS
7.0
VIDEO
48.0
C819_1
132.5
W817
+B
HV
CP806
132.5
HS402
763WSA0043
TP401
COL
2KV 0.001 B
C437
0
FNI14B002_M
FOCUS
GND
H.OUTPUT
Q401
2SC5885
C443
R427
FROM/TO TV POWER
130.0
130.0
100 1/4W
R405
1K 1/4W
4
FB401
11
C410_1
0.3
H_SYNC
0.001 CH
H_OUT
C446
ABCL
10
50V 22 YK
V_OUT
C440
470 1/2W
H.DRIVE
Q402
2SC1627_Y
27.0
GND
V_FEEDBACK
R446
3
NC 2
1
T401
STP-03Q24
4.7mH
P.CON+B
R449
560 1/2W
PCB010
CMF081
R448
560 1/2W
D408
11E1-EIC
R421
220K 1/4W
1/4W
C435
250V 22 YK
C448_1
C403
35V 470 YK
R445
180K
13A26/13A26C
ARE
ADD: R402
C401
L401
H
TOSHIBA CORPORATION
1-1, SHIBAURA 1-CHOME, MINATO-KU, TOKYO 105-8001, JAPAN