Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1. Pressurized Distribution
The pressurized systems include sprinkler, trickle, and the array of similar
systems in which water is conveyed to and distributed over the farmland
through pressurized pipe networks. There are many individual system
configurations identified by unique features (centre-pivot sprinkler systems).
automation, the control of or the capture and reuse of runoff, field soil and topographical
variations and the existence and location of flow measurement and water control structures.
Questions that are common to all irrigation systems are when to irrigate, how much to apply,
and can the efficiency be improved. A large number of considerations must be taken into
account in the selection of an irrigation system. These will vary from location to location,
crop to crop, year to year, and farmer to farmer.
Level of Mechanization
Size of Fields
Cultivation
Pest Control
Topographic Limitations.
groundwater levels
the location and relative elevation of the water source,
field boundaries,
acreage in each field,
the location of roads
power and water lines and other obstructions,
the shape and slope of the field
Methods of Irrigation
Under gravity irrigation, water is distributed by means of open canals and conducts with out
pressure. Gravity irrigation methods are less expensive, but requires more skill and experience
to achieve rescannable efficiency. This method also requires that the land to be irrigated
should have a flatter slope, other wise the cost of land leveling and preparation at times be
come very high. Gravity irrigation method. Includes furrow, boarder, basin, wild- flooding
and corrugation.
1. Furrow irrigation
In this method of surface irrigation, water is applied to the field by furrow which are small
canales having a continuous our nearly uniform slope in the direction of irrigation. Water
flowing in the furrow into the soil spreads laterally to
irrigate the area between furrows.
The rate of lateral spread of water in the soil depends on soil type.i.e. For a given time, water
will infiltrate more vertically and less laterally in relatively sandy soils than in clay soil.
Where the land grade is less than 1% in the direction of furrow, striate graded furrows may be
adapted. The grade can be as much as 2 to 3% depending on the soil type and the rainfall
intensity, which affects erosion. When field sloped is too steep to align the furrows down the
slope, control furrows which run along curved routed may be used. Spacing of furrows
depends on the crop type and the type of machinery used for cultivation and planting.
Length of furrows depends largely on permeability of the soil, the available labor and skill,
and experiences of the irrigation.
Flow rates are related to the infiltration to the rate of the soil.
Longitudinal slope of furrow depends up on the soil type, especially its errodiability and the
velocity of flow.
slope may be related to discharge as follows.
slope % 0.25 0.5 0.75 1.0 1.5 2.0
Qmax (m3/hr) 9.0 4.5 3.0 2.2 1.5 1.1
3. Basin irrigation
Large stream of water is applied to almost level and smaller unit of fields which are
surrounded by levees or bunds. The applied water is retained in the basin until it filtrates.
Soil type, stream size and irrigation depth are the important factors indeterming the basin
area.
Method of irrigation
Furrow method
Basin method
Orchard trees
4. Wild flooding
Water is applied all over the field especially, before plowing for soil that can't be plowed
when dry.
Under closed conduit- there are two types of irrigation
1. Sprinkler
2. Drip irrigation
1. Sprinkler irrigation:
It is mostly used for young growth, to humid the atmosphere, for soil compaction( specially
for sandy loam soils before planting, for land having up and down slope and used to wash out
plant leaves especially in dusty area.
Sprinkler irrigation offers a means of irrigating areas which are so irregular that they prevent
use of any surface irrigation methods. By using a low supply rate, deep percolation or surface
runoff and erosion can be minimized. Offsetting these advantages is the relatively high cost of
the sprinkling equipment and the permanent installations necessary to supply water to the
sprinkler lines.
Very low delivery rates may also result in fairly high evaporation from the spray and the
wetted vegetation. It is impossible to get completely uniform distribution of water around a
sprinkler head and spacing of the heads must be planned to overlap spray areas so that
distribution is essentially uniform
Advantages
o
2. Drip irrigation
This is used especially where there is shortage of water and salt problem. The drip method of
irrigation, also called trickle irrigation. The method is one of the most recent developments in
irrigation. It involves slow and frequent application of water to the plant root zone and
enables the application of water and fertilizer at optimum rates to the root system.
It minimizes the loss of water by deep percolation below the root zone or by evaporation from
the soil surface. Drip irrigation is not only economical in water use but also gives higher
yields with poor quality water.
Advantages