Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
2 Which configuration parameters can a host receive From a DHCP server? (Choose
three.)
MAC address
outside global address
√ DNS server address
DHCP helper address
√ default gateway address
√ IP address/subnet mask
3 When using distance-vector routing protocols in a frame relay environment with multiple
DLCIs on a single physical router interface, split-horizon issues must be resolved.
According to Cisco best practices, what should be configured to manage these issues?
a single network address
multiple LMIs
√ subinterfaces
multiple IP addresses on the same subnet
5 What are the two basic functions that a router uses to relay packets?
filtering and switching
path determination and filtering
√ path determination and switching
traffic analysis and filtering
7 Which protocol of the TCP/IP model internet layer provides connectionless, best-effort-
delivery of datagrams?
ARP
ICMP
√ IP
RARP
TCP
DNS
8 A static route needs to be configured to network 192.17.10.0/24. This route should have an
administrative distance of 180. Which command will configure this route if the IP address
of the next hop interface is 10.15.0.1?
Router(config)# ip route 192.17.10.1 255.255.255.0 10.15.0.0 180
√ Router(config)# ip route 192.17.10.0 255.255.255.0 10.15.0.1 180
Router(config)# ip route 10.15.0.1 192.17.10.0 255.255.255.0 180
Router (config)# ip static-route 192.17.10.0 255.255.255.255 10.15.0.1 180
Router (config)# ip default-route 192.17.10.0 255.255.255.255 10.15.0.1 180
9 Which statements reflect the process of common LAN protocols accessing the media?
(Choose three.)
Ethernet is a non-deterministic protocol that allows the first node that accesses the medium to
transmit its data.
√ Token Ring is a deterministic protocol that allows only one node within the ring a turn to
transmit data before passing control to the next node.
Token Ring is a non-deterministic protocol that uses a first-come, first-serve approach for
nodes to seize the token and transmit data.
√ FDDI networks use a deterministic approach to assure that each node has fair access to the
medium.
Ethernet and Token Ring networks avoid collisions by allowing only one node to transmit at a
time.
√ Ethernet is a deterministic protocol that uses CSMA/CD to assure that each node takes turns to
access the medium.
13 Which utility shows the route a packet takes to reach its destination?
netstat
ping
Telnet
√ traceroute
14 A partial configuration of a Catalyst 1900 switch is shown in the graphic. Why do the
following commands fail to delete VLAN1 and VLAN2? (Choose two.)
no vlan 1
no vlan 2
VLAN 1 is not configured on the switch.
√ VLAN 1 is the default VLAN and cannot be removed.
The network administrator is using the wrong command.
√ The switch is configured in VTP client mode.
Ports are still assigned to VLAN 1 and VLAN 2 and the VLANs cannot be deleted until those
assignments are removed.
15 Which layer of the OSI model can provide connection-oriented and reliable data
transfer between two hosts?
application
presentation
session
√ transport
18 In an IPv4 environment, what information is used by the router to forward data packets
From one interface of a router to another?
√ destination network address
source network address
source MAC address
well known port destination address
19 Which statement best describes the difference between exterior routing protocols and
interior routing protocols?
Exterior routing protocols are used for communications within a single autonomous system,
and interior routing protocols are used for communications between autonomous systems.
Interior routing protocols are used between neighbor routers, and exterior routing protocols
are used between peer routers.
Interior routing protocols are used by mid size companies, and exterior routing protocols are
used by large organizations.
√ Interior routing protocols are used for communications within a single autonomous system, and
exterior routing protocols are used for communications between autonomous systems.
20 What is the term for the cabling that connects the customer premises equipment to the
CO switch?
demarc
local loop
final mile
√ DTE
trunk line
21 Which command will display statistics for all interfaces configured on a router?
list interfaces
√ show interfaces
show processes
show statistics
22 An administrator has an older 1900 switch located on the edge of the network. What can
the network administrator do to ensure that it does not become the root bridge of the
spanning-tree network?
decrease the BPDU hello timer update on the 1900
assign the highest IP address to the switch that should be the root
assign the lowest IP address to new root bridge
√ assign the lowest priority to the switch that should be the root
assign the highest priority to the new root bridge
decrease the BID on the 1900 switch
23 The administrator of the network shown in the graphic would like to use VLSM to
subnet the company’s Class C address. Which subnet masks should be used on the LANs
and serial links to waste the fewest host addresses? (Choose three.)
255.255.255.0
√ 255.255.255.192
255.255.255.224
√ 255.255.255.240
255.255.255.248
√ 255.255.255.252
28 Refer to exhibit. Given the topology shown in the exhibit, what three commands are
needed to configure EIGRP on the Paris router? (Choose three.)
√ Paris(config)# router eigrp 100
Paris(config)# router eigrp
Paris(config-router)# network 192.168.6.0
Paris(config-router)# network 192.168.7.0
Paris(config-router)# network 192.168.8.0
Paris(config-router)# network 192.168.9.0
30 Which statement describes the store and forward transmission mode of an Ethernet
switch?
It is also referred to as a hybrid mode or as error sensing mode.
It requires the switch to read the first 64 bytes of an Ethernet frame and then begins to
forward the data.
It decreases the latency of the transmission but has very little error detection.
√ It increases latency with large frames, but error detection is high.
32 What are the advantages of OSPF in comparison with RIP v2? (Choose two.)
OSPF provides support for Classless Interdomain Routing but RIP v2 does not.
√ OSPF may result in faster convergence, due to triggered updates.
OSPF’s built-in features make it easy to design, implement, and troubleshoot.
√ OSPF routers build a complete view of the network, reducing the potential for routing loops.
OSPF sends periodic link state advertisements to keep the link active.
OSPF routers have lower memory and processor requirements.
33 Which command will verify that a router is configured with RIPv2 and that the hold-
down timer and administrative distance are set to the default values?
show ip route
show interface brief
√ show ip protocols
show interface
35 Which statements are true regarding OSPF DR and BDR elections? (Choose three.)
√ The command ip ospf prioritypriority number is used to set the priority value that determines
the DR.
The default priority value for a router connected to a multiaccess network is 0.
The router with the highest MAC address is elected as the DR when the default priority
values are used.
The loopback interface must be configured on the DR.
√ The BDR is selected From remaining routers and uses the same criteria applied in the DR
election.
√ There are no DRs or BDRs on point-to-point links.
41 Which of the following does CHAP authentication use to increase security on a PPP
link? (Choose three.)
periodic verification of identity while the link is established
√ secure recording of playback attacks
transmission of the CHAP password in plain text
√ the use of a unique and random challenge value
the use of a two-way handshake of CHAP exchanges
√ identity verification at the startup of a link
42 Which three statements describe the operation of routing with EIGRP? (Choose three.)
√ As new neighbors are discovered, entries are placed in a neighbor table.
If the feasible successor has a higher advertised cost than the current successor route, then it
becomes the primary route.
√ If hello packets are not received within the hold time, DUAL must recalculate the topology.
√ The reported distance is the distance to a destination as advertised by a neighbor.
EIGRP maintains full knowledge of the network topology in the topology table and
exchanges full routing information with neighboring routers in every update.
EIGRP builds one routing table that contains routes for all configured routed protocols.
43 What command is used to verify that a Frame Relay link is up and operational?
Router# show line
Router# show version
√ Router# show interface
Router# show frame-relay
Router# show frame-relay status
44 Which ISDN channels are used for voice, video, and data?
A channels
√ B channels
E channels
D channels
Q channels
E channels
45 A packet destined for 10.188.12.12 is received by a router with the configuration shown
in the graphic. The routing table displays the following lines:
10.0.0.0/24 is subnetted, 3 subnets
R 10.5.5.0 [120/1] via 10.20.20.2, 00:00:18, Serial0/0
C 10.20.20.0 is directly connected, Serial0/0
C 10.10.10.0 is directly connected, FastEthernet0/0
What will happen?
The packet will be forwarded to the next hop.
The router will forward the packet out all ports.
√ The packet will be dropped.
The router will forward the packet out all ports except the receiving port.
46 How many host addresses may be assigned on each subnetwork when using the
130.68.0.0 network address with a subnet mask of 255.255.248.0?
30
256
√ 2046
2048
4094
4096
47 Which automatic process is started first whenever power is applied to a Cisco router?
empties contents of NVRAM
looks for the configuration file
√ performs a POST
starts the operating system
48 Which utility can be used to verify connectivity through all seven layers of the OSI
model?
netstat
ping
√ Telnet
traceroute
49 Which layer of the OSI model establishes, manages, and terminates sessions between
applications?
Layer 7
Layer 6
√ Layer 5
Layer 4
Layer 3
Layer 2
50 When a user generates information to be sent on a network, in what order does data
encapsulation occur?
data, frame, segment, packet, bits
data, packet, frame, segment, bits
data, packet, segment, frame, bits
√ data, segment, packet, frame, bits
51 Which of the following are true regarding bridges and switches? (Choose two.)
√ Bridges are faster than switches because they have fewer ports.
√ A switch is a multiport bridge.
Bridges and switches learn MAC addresses by examining the source MAC address of each
frame received.
A bridge will forward a broadcast but a switch will not.
Bridges and switches increase the size of a collision domain.
52 A network administrator wants to reconfigure a router. Which of the following will clear
the running-configuration in preparation for the reconfiguration?
erase running-config and then reload
erase running-config
reload
no running-config and then reload
√ erase startup-config and then reload
delete running-config
54 Which fields are common to the TCP and the UDP segments? (Choose two.)
√ source address
sequence number
acknowledgement number
options
checksum
√ destination port
55 Which OSI model layer is responsible for regulating the flow of information
From source to destination, reliably and accurately?
application
presentation
session
√ transport
network
56 What are the primary functions of a Layer 2 Ethernet switch? (Choose three.)
filters traffic between LAN segments
√ achieves greater bandwidth per user
prevents hosts From sending broadcasts
√ increases the number of broadcast domains through VLANs
√ decreases the number of collision domains through VLANs
57 What operations can be executed From the Router> prompt? (Choose two.)
√ enter privileged mode with the enable command
modify passwords
modify the router name with the hostname command
√ view basic router status
view passwords
view the running-configuration with the show running-config command
58 Host A in the graphic has received its DHCP configuration From R1. Host A is unable to
reach the Internet. What could cause this problem?
The DNS server is not on the same LAN as Host A.
The ip helper-address command must be configured on the Ethernet interface.
√ Host A did not receive the correct gateway address.
The DHCP service has not been enabled on interface e0.
The router IP address has been excluded From the DHCP pool.
The subnet mask in the network command is incorrect.
59 The network in the graphic is using EIGRP with the metrics shown. Router A has a
route to network 210.67.130.0 through Router C, with a feasible distance of three. What
will happen if the direct link between A and C becomes unavailable? (Choose two.)
DUAL will immediately promote the feasible successor route through Router B to successor
route status.
√ The route to Network C on Router A will be placed in Active status.
The route to Network C on Router A will be placed in Passive status.
√ Router A will send query packets to all neighbor routers.
Router A will mark the link as down until regularly scheduled update packets are received.