Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Page 1 of 4
Online Course
Blast Design and Assessment for Surface Mines and Quarries
Part 1: Introduction
Change Course
Help
Level
Map
Introduction ... | Interaction ... | Rock Properties ... | Glossary ... | Review #1 ...
Rock Properties
Session Headings: Introduction
Introduction
(See Summary for main points)
Blasting results are greatly influenced by properties of the intact rock and the rock mass.
Fragmentation, displacement and blasting damage can, in some instances, be more influenced
by the rock than by the blast design.
Intact Rock Properties
The primary intact rock properties commonly applied in blast design are:
Definitions
(See Summary for main points)
Young's Modulus is the ratio of axial stress to axial strain in uniaxial compression
(typically expressed in GPa).
Poisson's Ratio is the ratio of lateral to axial strain magnitudes (dimensionless).
Compressive strength is the ratio of peak load to the cross-sectional area of a test sample
in uniaxial compression (typically expressed in MPa).
Tensile strength is the peak load per cross section area at the point of rupture in tension
(typically expressed in kPa).
The density of a rock is the specific weight (typically expressed in g/cc).
The P-wave velocity of a rock is a measure of the compressive wave transmission
velocity (typically expressed in m/s).
http://premium.infomine.com/edumine/xutility/html/documentDisplayEN.htm
8/14/2009
document display
Page 2 of 4
blastability
fragmentation
blast damage
Blastability Indices
Rock and rock mass properties can be used in the development of blastability indices. A
popular method was developed by Lilly (1986) for use in the northwest iron ore range in
Australia. This Blastability Index uses the following variables in the calculation of blasting
energy requirements:
where:
= induced strain in the rock
http://premium.infomine.com/edumine/xutility/html/documentDisplayEN.htm
8/14/2009
document display
Page 3 of 4
where:
PPVmax = maximum particle velocity before tensile failure (mm/s)
t = uniaxial tensile strength of rock (Pa) - 1/10 to 1/15 the UCS
Vp = P-wave velocity of rock (mm/s)
E = Young's Modulus of the rock (Pa)
Many other damage predictions methods have been published that use essentially the same
information to assess damage potential from blasting.
Summary
(See Summary for main points)
It is important to remember that blasting is rarely undertaken in a homogeneous, isotropic
rock mass. In terms of achieving successful blasting, the properties of the intact rock and the
rock mass may be as important as the selection of an explosive and blasting pattern.
Examples of the influence of geology on blasting results is shown in the following figures:
http://premium.infomine.com/edumine/xutility/html/documentDisplayEN.htm
8/14/2009
document display
Page 4 of 4
Blast Design and Assessment for Surface Mines and Quarries - April 14 2002
http://premium.infomine.com/edumine/xutility/html/documentDisplayEN.htm
8/14/2009