Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
excess emissions are required under to change over the next three years. and Toxics (OPPT), Environmental
subpart Eb. These notifications, reports, Secondly, the growth rate for the Protection Agency, 1200 Pennsylvania
and records are essential in determining industry is very low, negative or non- Ave., NW., Washington, DC 20460–
compliance and are required, in general, existent, so there is no significant 0001.
of all sources subject to the standard. change in the overall burden. Since • Hand Delivery: OPPT Document
Notifications are used to inform the there are no changes in the regulatory Control Office (DCO), EPA East Bldg.,
Agency or delegated authority when a requirements and there is no significant Rm. 6428, 1201 Constitution Ave., NW.,
source becomes subject to the standard. industry growth, the labor hours and Washington, DC. Attention: Docket ID
The reviewing authority may then cost figures in the previous ICR are used Number EPA–HQ–OPPT–2007–1193.
inspect the source to check if the in this ICR and there is no change in The DCO is open from 8 a.m. to 4 p.m.,
pollution control devices are properly burden to industry. Monday through Friday, excluding legal
installed and operated, and the standard holidays. The telephone number for the
Dated: February 20, 2008.
is being met. Performance test reports DCO is (202) 564–8930. Such deliveries
are needed as these are the Agency’s Sara Hisel-McCoy, are only accepted during the DCO’s
records of a source’s initial capability to Director, Collection Strategies Division. normal hours of operation, and special
comply with the emission standards, [FR Doc. E8–4149 Filed 3–3–08; 8:45 am] arrangements should be made for
and serve as a record of the operating BILLING CODE 6560–50–P deliveries of boxed information.
conditions under which compliance Instructions: Direct your comments to
was achieved. The information docket ID number EPA–HQ–OPPT–
generated by monitoring, recordkeeping ENVIRONMENTAL PROTECTION 2008–0127. EPA’s policy is that all
and reporting requirements described in AGENCY comments received will be included in
this ICR is used by the Agency to ensure [EPA–HQ–OPPT–2008–0127; FRL–8353–6] the docket without change and may be
that facilities affected by the standard made available on-line at http://
continue to operate the control Certain New Chemicals; Receipt and www.regulations.gov, including any
equipment and achieve continuous Status Information personal information provided, unless
compliance with the regulation. the comment includes information
Burden Statement: The annual public AGENCY: Environmental Protection claimed to be Confidential Business
reporting and recordkeeping burden for Agency (EPA). Information (CBI) or other information
this collection of information is ACTION: Notice. whose disclosure is restricted by statute.
estimated to average 198 hours per Do not submit information that you
SUMMARY: Section 5 of the Toxic
response. Burden means the total time, consider to be CBI or otherwise
Substances Control Act (TSCA) requires
effort, or financial resources expended protected through regulations.gov or e-
any person who intends to manufacture
by persons to generate, maintain, retain, mail. The regulations.gov website is an
(defined by statute to include import) a ‘‘anonymous access’’ system, which
or disclose or provide information to or new chemical (i.e., a chemical not on
for a Federal agency. This includes the means EPA will not know your identity
the TSCA Inventory) to notify EPA and or contact information unless you
time needed to review instructions; comply with the statutory provisions
develop, acquire, install, and utilize provide it in the body of your comment.
pertaining to the manufacture of new If you send an e-mail comment directly
technology and systems for the purposes chemicals. Under sections 5(d)(2) and
of collecting, validating, and verifying to EPA without going through
5(d)(3) of TSCA, EPA is required to regulations.gov, your e-mail address
information, processing and publish a notice of receipt of a
maintaining information, and disclosing will be automatically captured and
premanufacture notice (PMN) or an included as part of the comment that is
and providing information; adjust the application for a test marketing
existing ways to comply with any placed in the docket and made available
exemption (TME), and to publish on the Internet. If you submit an
previously applicable instructions and periodic status reports on the chemicals
requirements which have subsequently electronic comment, EPA recommends
under review and the receipt of notices that you include your name and other
changed; train personnel to be able to of commencement to manufacture those
respond to a collection of information; contact information in the body of your
chemicals. This status report, which comment and with any disk or CD-ROM
search data sources; complete and covers the period from January 1, 2008
review the collection of information; you submit. If EPA cannot read your
through January 31, 2008, consists of the comment due to technical difficulties
and transmit or otherwise disclose the PMNs and TMEs, both pending or
information. and cannot contact you for clarification,
expired, and the notices of EPA may not be able to consider your
Respondents/Affected Entities:
commencement to manufacture a new comment. Electronic files should avoid
Municipal waste combustors.
Estimated Number of Respondents: chemical that the Agency has received the use of special characters, any form
12. under TSCA section 5 during this time of encryption, and be free of any defects
Frequency of Response: Initially, period. or viruses. For additional information
quarterly, annually and semiannually. DATES: Comments identified by the about EPA’s public docket, visit the EPA
Estimated Total Annual Hour Burden: specific PMN number or TME number, Docket Center homepage at http://
20,421. must be received on or before April 3, www.epa.gov/epahome/dockets.htm.
Estimated Total Annual Cost: 2008. Docket: All documents in the docket
$1,635,293 which includes $60,000 ADDRESSES: Submit your comments, are listed in the docket index available
annualized capital costs and $99,000 in identified by docket identification (ID) in regulations.gov. To access the
O&M costs. number EPA–HQ–OPPT–2008–0127, by electronic docket, go to http://
Changes in the Estimates: There is no one of the following methods: www.regulations.gov, select ‘‘Advanced
sroberts on PROD1PC70 with NOTICES
change in the labor hours or cost in this • Federal eRulemaking Portal: http:// Search,’’ then ‘‘Docket Search.’’ Insert
ICR compared to the previous ICR. This www.regulations.gov. Follow the on-line the docket ID number where indicated
is due to two considerations. First, the instructions for submitting comments. and select the ‘‘Submit’’ button. Follow
regulations have not changed over the • Mail: Document Control Office the instructions on the regulations.gov
past three years and are not anticipated (7407M), Office of Pollution Prevention website to view the docket index or
VerDate Aug<31>2005 17:57 Mar 03, 2008 Jkt 214001 PO 00000 Frm 00022 Fmt 4703 Sfmt 4703 E:\FR\FM\04MRN1.SGM 04MRN1
Federal Register / Vol. 73, No. 43 / Tuesday, March 4, 2008 / Notices 11633
access available documents. Although to a particular entity, consult the person viii. Make sure to submit your
listed in the index, some information is listed under FOR FURTHER INFORMATION comments by the comment period
not publicly available, e.g., CBI or other CONTACT. deadline identified.
information whose disclosure is
B. What Should I Consider as I Prepare II. Why is EPA Taking this Action?
restricted by statute. Certain other
material, such as copyrighted material, My Comments for EPA?
Section 5 of TSCA requires any
will be publicly available only in hard 1. Submitting CBI. Do not submit this
information to EPA through person who intends to manufacture
copy. Publicly available docket
regulations.gov or e-mail. Clearly mark (defined by statute to include import) a
materials are available electronically at
http://www.regulations.gov, or, if only the part or all of the information that new chemical (i.e., a chemical not on
available in hard copy, at the OPPT you claim to be CBI. For CBI the TSCA Inventory to notify EPA and
Docket. The OPPT Docket is located in information in a disk or CD-ROM that comply with the statutory provisions
the EPA Docket Center (EPA/DC) at Rm. you mail to EPA, mark the outside of the pertaining to the manufacture of new
3334, EPA West Bldg., 1301 disk or CD-ROM that you mail to EPA, chemicals. Under sections 5(d)(2) and
Constitution Ave., NW., Washington, mark the outside of the disk or CD-ROM 5(d)(3) of TSCA, EPA is required to
DC. The EPA/DC Public Reading Room as CBI and then identify electronically publish a notice of receipt of a PMN or
hours of operation are 8:30 a.m. to 4:30 within the disk or CD-ROM the specific an application for a TME and to publish
p.m., Monday through Friday, excluding information that is claimed as CBI. In periodic status reports on the chemicals
Federal holidays. The telephone number addition to one complete version of the under review and the receipt of notices
of the EPA/DC Public Reading Room is comment that includes information of commencement to manufacture those
(202) 566–1744, and the telephone claimed as CBI, a copy of the comment chemicals. This status report, which
number for the OPPT Docket is (202) that does not contain the information covers the period from January 1, 2008
566–0280. Docket visitors are required claimed as CBI must be submitted for through January 31, 2008, consists of the
to show photographic identification, inclusion in the public docket. PMNs and TMEs, both pending or
pass through a metal detector, and sign Information so marked will not be expired, and the notices of
the EPA visitor log. All visitor bags are disclosed except in accordance with commencement to manufacture a new
processed through an X-ray machine procedures set forth in 40 CFR part 2. chemical that the Agency has received
and subject to search. Visitors will be 2. Tips for preparing your comments. under TSCA section 5 during this time
provided an EPA/DC badge that must be When submitting comments, remember period.
visible at all times in the building and to:
returned upon departure. i. Identify the document by docket ID III. Receipt and Status Report for PMNs
FOR FURTHER INFORMATION CONTACT: number and other identifying
Colby Lintner, Regulatory Coordinator, information (subject heading, Federal This status report identifies the PMNs
Environmental Assistance Division, Register date and page number). and TMEs, both pending or expired, and
Office of Pollution Prevention and ii. Follow directions. The Agency may the notices of commencement to
Toxics (7408M), Environmental ask you to respond to specific questions manufacture a new chemical that the
Protection Agency, 1200 Pennsylvania or organize comments by referencing a Agency has received under TSCA
Ave., NW., Washington, DC 20460– Code of Federal Regulations (CFR) part section 5 during this time period. If you
0001; telephone number: (202) 554– or section number. are interested in information that is not
1404; e-mail address: TSCA- iii. Explain why you agree or disagree; included in the following tables, you
Hotline@epa.gov. suggest alternatives and substitute may contact EPA as described in Unit II.
language for your requested changes. to access additional non-CBI
SUPPLEMENTARY INFORMATION:
iv. Describe any assumptions and information that may be available.
I. General Information provide any technical information and/
In Table I of this unit, EPA provides
or data that you used.
A. Does this Action Apply to Me? v. If you estimate potential costs or the following information (to the extent
This action is directed to the public burdens, explain how you arrived at that such information is not claimed as
in general. As such, the Agency has not your estimate in sufficient detail to CBI) on the PMNs received by EPA
attempted to describe the specific allow for it to be reproduced. during this period: the EPA case number
entities that this action may apply to. vi. Provide specific examples to assigned to the PMN; the date the PMN
Although others may be affected, this illustrate your concerns and suggest was received by EPA; the projected end
action applies directly to the submitter alternatives. date for EPA’s review of the PMN; the
of the premanufacture notices addressed vii. Explain your views as clearly as submitting manufacturer; the potential
in the action. If you have any questions possible, avoiding the use of profanity uses identified by the manufacturer in
regarding the applicability of this action or personal threats. the PMN; and the chemical identity.
P–08–0158 01/02/08 03/31/08 CBI (G) Corrosion inhibitor (G) Fatty acid amine derivative
P–08–0159 01/02/08 03/31/08 CBI (G) Corrosion inhibitor (G) Fatty acid amine derivative
sroberts on PROD1PC70 with NOTICES
VerDate Aug<31>2005 17:57 Mar 03, 2008 Jkt 214001 PO 00000 Frm 00023 Fmt 4703 Sfmt 4703 E:\FR\FM\04MRN1.SGM 04MRN1
11634 Federal Register / Vol. 73, No. 43 / Tuesday, March 4, 2008 / Notices
P–08–0165 01/09/08 04/07/08 CBI (S) Deodorizer for consumer products (G) Extract of tea
P–08–0166 01/11/08 04/09/08 PPG Industries, Inc. (G) Component of coating with open (G) Trimethoxysilane
use
P–08–0167 01/11/08 04/09/08 Mitsubishi Chemical (S) Molding material for agriculture; (G) Alkanedioic acid, polymer with
Performance Poly- molding material for food package; 1,4-butanediol
mers, Inc. material for fiber, monofilament;
molding material for construction;
material for sheet, film
P–08–0168 01/11/08 04/09/08 CBI (G) Specialty additive (G) Potassium humate, polymer with
acrylic monomers
P–08–0169 01/14/08 04/12/08 CBI (G) Crosslinking agent for coatings (G) Aromatic polyisocyanate, glycol
ethers-blocked
P–08–0170 01/14/08 04/12/08 CBI (G) Crosslinking agent for coatings (G) Aromatic polyisocyanate, glycol
ether and aliphatic alcohol-blocked
P–08–0171 01/14/08 04/12/08 CBI (G) Crosslinking agent for coatings (G) Aromatic polyisocyanate, aliphatic
diol, glycol ether-blocked
P–08–0172 01/14/08 04/12/08 CBI (G) Crosslinking agent for coatings (G) Aromatic polyisocyanate, aliphatic
diol, glycol ether-blocked
P–08–0173 01/14/08 04/12/08 CBI (G) Crosslinking agent for coatings (G) Aromatic polyisocyanate, glycol
ethers-blocked
P–08–0174 01/14/08 04/12/08 CBI (G) Crosslinking agent for coatings (G) Aromatic polyisocyanate, aliphatic
polyol, glycol ethers-blocked
P–08–0175 01/14/08 04/12/08 CBI (G) Open non-dispersive (elastomer) (G) Polyurethane elastomer
P–08–0176 01/15/08 04/13/08 Ineos Olefine and (S) Catalyst for polyolefins polym- (S) Magnesium, bu alc. chloro tita-
Polymers USA LLC erization nium complexes
P–08–0177 01/14/08 04/12/08 CBI (G) (1) Property modifier in electronic (S) Multi-walled carbon nanotubes
applications, contained use; (2)
Property modifier in polymer com-
posites, contained use
P–08–0178 01/14/08 04/12/08 CBI (G) Chemical intermediate that is (G) Substituted benzoyl chloride
chemically transformed in use
P–08–0179 01/14/08 04/12/08 CBI (G) Nucleator for polymers (G) 1,2,3-propanetricarboxamide de-
rivative
P–08–0180 01/14/08 04/12/08 CBI (G) Precursor to another chemical (G) Salt of condensation product of
substance, destructive use cyclic diketone
P–08–0181 01/14/08 04/12/08 CBI (G) Precursor to another chemical (G) Substituted benzoic acid
substance, destructive use
P–08–0182 01/15/08 04/13/08 CBI (G) Reactant (G) Acid modified alumina
P–08–0183 01/16/08 04/14/08 CIBA Corporation (S) High mw pigment dispersant in (G) Polyethylene gylcol/polyacrylate/
paints and coatings vinylpyridine block polymer
P–08–0184 01/16/08 04/14/08 CIBA Corporation (S) High MW pigment dispersant in (G) Polyacrylate/vinylpyridine block
paints and coatings copolymer
P–08–0185 01/08/08 04/06/08 Advanced Polymer, (S) Adhesion promoter for poly- (S) 1-butene, polymer with ethene
Inc. propylene and 1-propene, maleated
P–08–0186 01/18/08 04/16/08 Colonial Chemical, (S) Surfactant for carpet cleaning; (S) D-glucopyranose, oligomeric,
Inc. surfactant for antifog coating; wet- decyl octyl glycosides, 3-
ting agent for fiber treatment (dodecyldimethylammonio)-2-
hydroxypropyl ethers, chlorides
P–08–0187 01/18/08 04/16/08 Colonial Chemical, (S) Surfactant for carpet cleaning; (S) D-glucopyranose, oligomeric,
Inc. surfactant for antifog coating; wet- C10–16-alkyl glycosides, 3-
ting agent for fiber treatment (dodecyldimethylammonio)-2-
hydroxypropyl ethers, chlorides
P–08–0188 01/18/08 04/16/08 Colonial Chemical, (S) Surfactant for carpet cleaning; (S) D-glucopyranose, oligomeric,
Inc. surfactant for antifog coating; wet- decyl octyl glycosides, 3-
ting agent for fiber treatment (dimethyloctadecylammonio)-2-
hydroxypropyl ethers, chlorides
P–08–0189 01/18/08 04/16/08 Colonial Chemical, (S) Surfactant for carpet cleaning; (S) D-glucopyranose, oligomeric,
Inc. surfactant for antifog coating; wet- C10–16-alkyl glycosides, 3-
ting agent for fiber treatment (dimethyloctadecylammonio)-2-
hydroxypropyl ethers, chlorides
P–08–0190 01/18/08 04/16/08 Colonial Chemical, (S) Surfactant for carpet cleaning; (S) D-glucopyranose, oligomeric,
Inc. surfactant for antifog coating; wet- C10–16-alkyl decyl octyl glycosides,
ting agent for fiber treatment 2-hydroxy-3-
(trimethylammonio)propyl ethers,
sroberts on PROD1PC70 with NOTICES
chlorides
P–08–0191 01/18/08 04/16/08 Cytec Industries Inc. (G) Antiscalant (G) Modified polyamine
P–08–0192 01/18/08 04/16/08 Cytec Industries Inc. (G) Antiscalant (G) Modified polyamine
P–08–0193 01/18/08 04/16/08 Cytec Industries Inc. (G) Antiscalant (G) Modified polyamine
VerDate Aug<31>2005 17:57 Mar 03, 2008 Jkt 214001 PO 00000 Frm 00024 Fmt 4703 Sfmt 4703 E:\FR\FM\04MRN1.SGM 04MRN1
Federal Register / Vol. 73, No. 43 / Tuesday, March 4, 2008 / Notices 11635
P–08–0194 01/22/08 04/20/08 Cytec Industries Inc. (G) Ink additive (G) Fatty acids, dimers, polymers with
alkenoic acid, polyoxyalkylene and
alkyl substituted triol
P–08–0195 01/22/08 04/20/08 Cytec Industries Inc. (G) Coatings resin (G) Acrylated aliphatic polyurethane
P–08–0196 01/22/08 04/20/08 CBI (S) Polyester raw material used in the (G) Polyester
manufacture of industrial coatings
for automotive or metal finishing
P–08–0197 01/22/08 04/20/08 CBI (S) Polyester raw material used in the (G) Epoxy modified polyester
manufacture of industrial coatings
for automotive or metal finishing
P–08–0198 01/23/08 04/21/08 Incorez Corporation (S) Curing agent for epoxy based (G) Aromatic polyepoxide-polyamine
coatings copolymer
P–08–0199 01/23/08 04/21/08 CBI (S) Additive/filler for polymer compos- (G) Carbon
ites; support media for industrial
catalysts
P–08–0200 01/24/08 04/22/08 CBI (G) (Product 1) Additive for open, (G) Partially fluorinated amphiphilic
non-dispersive use; (Product 2) condensation polymer
Coating for open, non-dispersive
use
P–08–0201 01/24/08 04/22/08 Supresta U.S. LLC (S) Flame retardant for engineering (G) Aryl phosphoric acid ester
resins
P–08–0202 01/25/08 04/23/08 3M (G) Prepolymer (G) Polyetheramine diisocyanate
prepolymer
P–08–0203 01/25/08 04/23/08 CBI (G) Moisture curing polyurethane ad- (G) Isocyanate terminated urethane
hesive polymer
P–08–0204 01/23/08 04/21/08 CBI (G) Dispersant for inorganic materials (G) Methacrylate copolymer
P–08–0205 01/30/08 04/28/08 CBI (G) Auxiliary / finishing agent for (G) Acrylic acid polymer with alkyl ac-
leather products rylate, alkenyl benzene and acryl
amide, ammonium salt
P–08–0206 01/30/08 04/28/08 CBI (G) Interior and exterior coatings (G) Styrene/acrylate copolymer
(carboxylated)
P–08–0207 01/30/08 04/28/08 CBI (G) Raw material for oil field applica- (G) Substituted styrene copolymer
tions
P–8–0208 01/30/08 04/28/08 CBI (G) Component of paints (G) Acrylic styrene polymer
P–08–0209 01/31/08 04/29/08 CIBA Corporation (S) Antioxidant for polymers (G) Poly(oxy-1,2-ethanediyl), .alpha.-
bis alkyl substituted hydroxyphenyl
ester-.omega.-bis alkyl substituted
hydroxyphenyl ester
In Table II of this unit, EPA provides that such information is not claimed as
the following information (to the extent CBI) on the TMEs received:
T–08–0002 01/18/08 03/02/08 Cytec Industries Inc. (G) Antiscalant (G) Modified polyamine
T–08–0003 01/18/08 03/02/08 Cytec Industries Inc. (G) Antiscalant (G) Modified polyamine
T–08–0004 01/18/08 03/02/08 Cytec Industries Inc. (G) Antiscalant (G) Modified polyamine
T–08–0005 01/22/08 03/06/08 Cytec Industries Inc. (G) Ink additive (G) Fatty acids, dimers, polymers
with alkenoic acid, polyoxyalkylene
and alkyl substituted triol
T–08–0006 01/22/08 03/06/08 Cytec Industries Inc. (G) Coatings resin (G) Acrylated aliphatic polyurethane
In Table III of this unit, EPA provides CBI) on the Notices of Commencement
the following information (to the extent to manufacture received:
that such information is not claimed as
sroberts on PROD1PC70 with NOTICES
VerDate Aug<31>2005 17:57 Mar 03, 2008 Jkt 214001 PO 00000 Frm 00025 Fmt 4703 Sfmt 4703 E:\FR\FM\04MRN1.SGM 04MRN1
11636 Federal Register / Vol. 73, No. 43 / Tuesday, March 4, 2008 / Notices
VerDate Aug<31>2005 17:57 Mar 03, 2008 Jkt 214001 PO 00000 Frm 00026 Fmt 4703 Sfmt 4703 E:\FR\FM\04MRN1.SGM 04MRN1