Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
FDX4D(M)(S)1
INS_FDX4D_REV
08/23/10
PAGE 1
FDX4D(M)(S)(-M)
BLACK
BLACK WITH WHITE STRIPE/RED
Power Supply:
Surface Mount: 815 VDC @ 3W
Rack Mount: From Rack
REAR PANEL
INS_FDX4D_REV
08/23/10
PAGE 2
FDX4D(M)(S)(-M)
INS_FDX4D_REV
08/23/10
PAGE 3
FDX4D(M)(S)(-M)
INS_FDX4D_REV
08/23/10
PAGE 4
FDX4D(M)(S)(-M)
RS232
RS422
Bi-phase or
Manchester
FDX4D
Data Transmit
DIN()
DOUT()
Data Receive
Data Receive
DOUT()
DIN()
Data Transmit
Signal Ground
GND
GND
Signal Ground
DIN(+)
DOUT(+)
Data In (+)
Data Out ()
DIN()
DOUT()
Data In ()
Data In (+)
DOUT(+)
DIN(+)
Data In ()
DOUT()
DIN()
Data Out ()
DIN(+)
DOUT(+)
Data In (+)
Data Out ()
DIN()
DOUT()
Data In ()
Data (A)
DIN(+)
DIN(+)
Data (A)
Data (B)
DIN()
DIN()
Data (B)
2-Wire
RS485,
Sensornet
4-Wire
RS485
Customer
Equipment
FDX4D
DIN(+)
DOUT(+)
Data In (A)
DIN()
DOUT()
Data In (B)
Data In (A)
DOUT(+)
DIN(+)
Data In (B)
DOUT()
DIN()
DATA ACTIVITY (1 4)
POWER
GREEN
Unit In Sync
Activity
Unit Powered Up
RED
No Activity
OFF
No Optical Link
INS_FDX4D_REV
08/23/10
PAGE 5
Figure A
Dimensions are for a standard ComNet two slot module
2. Tighten the two thumb screws on the card until the front panel of
the card is seated against the front of the rack.
WARNING: Unit is to be used with a Listed Class 2 or LPS power supply rated
9-12 VDC @ 1A.
IMPORTANT SAFEGUARDS:
A) Elevated Operating Ambient - If installed in a closed or multi-unit rack
assembly, the operating ambient temperature of the rack environment may
be greater than room ambient. Therefore, consideration should be given to
installing the equipment in an environment compatible with the maximum
ambient temperature (Tma) specified by the manufacturer.
B) Reduced Air Flow - Installation of the equipment in a rack should be such
that the amount of air flow required for safe operation of the equipment is
not compromised.
INS_FDX4D_REV
08/23/10
PAGE 6