Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
www.efichip.com
Tacho Universal
Alfa Romeo
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Alfa Romeo
page 2
Tacho Universal
www.efichip.com
Model 166
Model 166/56
Model Spider & GTV
Model 156 after 12/2001
Tacho Universal
Alfa Romeo
page 3
Tacho Universal
www.efichip.com
Select the menu ALFA 145 - old. The Tacho Universal displays the old
value
Enter the new value. Verify the new value with OK.
Connect pin 57 (red cable) of the processor back to the circuit board.
Tacho Universal
Alfa Romeo
page 4
Tacho Universal
www.efichip.com
The blue cable comes from the 4 cables that belong together, the green from
the 2 data cables that belong together. The green marked pins have to be
connected together.
Hochlten=Lift pin
Tacho Universal
Alfa Romeo
page 5
Tacho Universal
www.efichip.com
Model 156
Blau=blue Grn=green
Schwarz=black Rot=red
Tacho Universal
Alfa Romeo
page 6
Tacho Universal
www.efichip.com
Troubleshooting TIP:
Some times the 156 have problems with the electrical loading,
try these steps to program it:
1. Dont connect the plug to the Tach
2. Go to the menu 156
3. connect the plug now
4. choose immediately 156
5. after reading disconnect the plug for 30 seconds, type in the new value
6. connect the plug and choose immediately writing
you can try to connect the components of the cluster
to Ground to eliminate the electrical loading
Tacho Universal
Alfa Romeo
page 7
Tacho Universal
www.efichip.com
Tacho Universal
Alfa Romeo
page 8
Tacho Universal
www.efichip.com
Alfa Romeo
page 9
Tacho Universal
www.efichip.com
Pin 1&2 brcken=connect Pin1&2 hochlten und blau=lift pin and blue cable
Gelb=yellow Grne Wanne=green socket
Remove the complete circuit board. (somewhere on the board you can
see the manufacturer. If it is Magneti Marelli you have to send us the
instrument).
The Tacho Universal shows you the old value. If it is not correct, you may
also have to lift the pin for the yellow cable.
Tacho Universal
Alfa Romeo
page 10
Tacho Universal
www.efichip.com
Model 166
Blu=blue Verde=green
Tacho Universal
Alfa Romeo
page 11
Tacho Universal
www.efichip.com
Model 166/
Look for the silver crystal near the chip and join its contacts
Tacho Universal
Alfa Romeo
page 12
Tacho Universal
www.efichip.com
Model 147
Look for the silver crystal near the chip and join its contacts
Tacho Universal
Alfa Romeo
page 13
Tacho Universal
www.efichip.com
Put the GTV plug onto the processor. Watch the pin 1 mark!
When the Tacho Universal displays Reset press the red button on the
plug for less than 1 second.
Tacho Universal
Alfa Romeo
page 14
Tacho Universal
Tacho Universal
www.efichip.com
Alfa Romeo
page 15
Tacho Universal
www.efichip.com
Tacho Universal
Audi
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Audi
page 2
Tacho Universal
www.efichip.com
Diagnostic programming
Connect the Tacho Universal to the OBD II plug and the diagnostic port.
Tacho Universal
Audi
page 3
Tacho Universal
www.efichip.com
Model A3 / S3 UKNSI
Look for the 8 pin Chip 93C56 (not the chip 93C46!)
Tacho Universal
Audi
page 4
Tacho Universal
www.efichip.com
Note:
If the displayed value is not correct, you can continue programming, most time it
works anyway
You cannot destroy anything. If you cannot change the value this way, you have to
program by clip.
Tacho Universal
Audi
page 5
Tacho Universal
www.efichip.com
Tacho Universal
Audi
page 6
Tacho Universal
www.efichip.com
Tacho Universal
Audi
page 7
Tacho Universal
www.efichip.com
Diagnostic programming
Connect the Tacho Universal to the OBD II plug and the diagnostic port.
The Tacho Universal shows you with one of these programs the old value.
Tacho Universal
Audi
page 8
Tacho Universal
www.efichip.com
Model A4 / S4 UK NSI
Use this board and clip:
Note:
There are different instrument versions. To find the right one, you have to try which
one gives you the right value when reading. Reading will not corrupt the database.
But only program with the version that gives you the correct value!
Look for the 8 pin Chip 93C56 (not the chip 93C46!)
Tacho Universal
Audi
page 9
Tacho Universal
Tacho Universal
www.efichip.com
Audi
page 10
Tacho Universal
www.efichip.com
Note:
If the displayed value is not correct, you can continue programming, most time it
works anyway
You cannot destroy anything. If you cannot change the value this way, you have to
program by clip.
Tacho Universal
Audi
page 11
Tacho Universal
www.efichip.com
Tacho Universal
Audi
page 12
Tacho Universal
www.efichip.com
Also connect the black and the red cables like shown in the picture.
IMPORTANT: You must not move the black and the red contact when
beginning to read until you are ready with programming. A good contact is
absolutely necessary.
Note:
If the handheld shows you out of range the contact was bad or the database may
be corrupted. For security reasons you cannot program the instrument at this
moment.
Normally it will be possible to program again after driving about 100 km.
Tacho Universal
Audi
page 13
Tacho Universal
www.efichip.com
Connect the Tacho Universal with both plugs to the diagnostic port.
Note:
If you cannot read the old value or or nothing changes when programming, let the
engine run. Maybe you have to try several times, also try different values, it will work.
Tacho Universal
Audi
page 14
Tacho Universal
www.efichip.com
Diagnostic programming
The diagnostic port near your left knee when you sit on the drivers seat.
Connect the Tacho Universal to the OBD II plug and the diagnostic port
Tacho Universal
Audi
page 15
Tacho Universal
www.efichip.com
Model A6 / S6 UK NSI
Use this board and clip:
Look for the 8 pin Chip 93C56 (not the chip 93C46!).
Tacho Universal
Audi
page 16
Tacho Universal
www.efichip.com
Note:
If the displayed value is not correct, you can continue programming, most time it
works anyway
You cannot destroy anything. If you cannot change the value this way, you have to
program by clip.
Tacho Universal
Audi
page 17
Tacho Universal
www.efichip.com
Tacho Universal
Audi
page 18
Tacho Universal
www.efichip.com
Also connect the black and the red cables like shown in the picture.
IMPORTANT: You must not move the black and the red contact when
beginning to read until you are ready with programming. A good contact is
absolutely necessary.
Note:
If the handheld shows you out of range the contact was bad or the database may
be corrupted. For security reasons you cannot program the instrument at this
moment.
Normally it will be possible to program again after driving about 100 km.
Tacho Universal
Audi
page 19
Tacho Universal
www.efichip.com
Remove the bridge at the silver chrystal, assemble the cluster and
clock it with the VAG-blue plug 40km (connect 100-300Hz on the
blue cable of the VAG-blue plug)
Dont clock faster than 260 km/h.
Power off, Power on and write down the second Km value.
Open the cluster, join the silver chrystal contacts, use Port 93CX6
Audi->A6(A3,A2)->A6 2002 VDO->VDO2002 R+W read and store.
Universal
not show
you the old value.
The Tachodoes
Choose Audi->A6(A3,A2)->A6 2002 VDO->VDO2002 R+W and
choose the 2 datasets and type in the values.
If the 2 datasets are correct the Tacho Universal will ask for the new
value.
Write the now produced third dataset with the new value back on
the eeprom with VDO2002 R+W->Complete write (join the silver
chrystal contacts again).
Ready
Tacho Universal
Audi
page 20
Tacho Universal
www.efichip.com
Model A8 / S8 up to ~ 1/1999
Diagnostic programming
There is an old and a new version. The old version was built before 10/1996. If the program
shows you with the old version a wrong value, try the new version.( ???? is ok for the
value then).
Turn ignition on.
Connect the Tacho Universal to the OBD II plug and the diagnostic port.
The Tacho Universal shows you the old value. (for A8 new the value ????? is ok)
Note:
If the new value is not displayed after programming, try this:
Pull out the fuse for the odometer for a few seconds. (fuse Nr. 8 or 9 in the black line)
Tacho Universal
Audi
page 21
Tacho Universal
www.efichip.com
Tacho Universal
Audi
page 22
Tacho Universal
www.efichip.com
Diagnostic programming
The diagnostic port near your left knee when you sit on the drivers seat.
Connect the Tacho Universal to the OBD II plug and the diagnostic port.
For some models you have to enter the old value on demand.
Note:
If you cannot change the value, the cluster is model 2000.
Tacho Universal
Audi
page 23
Tacho Universal
www.efichip.com
Also connect the black and the red cables like shown in the picture.
IMPORTANT: You must not move the black and the red contact when
beginning to read until you are ready with programming. A good contact is
absolutely necessary.
Note:
If the handheld shows you out of range the contact was bad or the database may
be corrupted. For security reasons you cannot program the instrument at this
moment.
Normally it will be possible to program again after driving about 100 km.
Tacho Universal
Audi
page 24
Tacho Universal
www.efichip.com
Tacho Universal
Audi
page 25
Tacho Universal
www.efichip.com
Tacho Universal
Audi
page 26
Tacho Universal
Tacho Universal
www.efichip.com
Audi
page 27
Tacho Universal
www.efichip.com
Pull out the fuse for the odometer for a few seconds. Fuse Nr 15.
Tacho Universal
Audi
page 28
Tacho Universal
www.efichip.com
The diagnostic port near your left knee when you sit on the drivers seat.
Connect the Tacho Universal to the OBD II plug and the diagnostic port
Tacho Universal
Audi
page 29
Tacho Universal
www.efichip.com
The diagnostic port near your left knee when you sit on the drivers seat.
Connect the Tacho Universalto the OBD II plug and the diagnostic port
Tacho Universal
Audi
page 30
Tacho Universal
www.efichip.com
The Tacho Universal shows the value that can be programed now
If this value is too high or too low, load the stored dataset and try again.
Tacho Universal
Audi
page 31
Tacho Universal
Tacho Universal
www.efichip.com
Audi
page 32
Tacho Universal
Tacho Universal
www.efichip.com
Audi
page 33
Tacho Universal
www.efichip.com
Tacho Universal
Audi
page 34
Tacho Universal
www.efichip.com
BMW Service
Tacho Universal
BMW
page 1
Tacho Universal
www.efichip.com
Diagnostic programming
Connect the Tacho Universal to the BMW diagnostic plug and the
diagnostic port.
Tacho Universal
BMW
page 2
Tacho Universal
www.efichip.com
On front of the board you can see the 8pin chip 93C46 or B58323. Remove the
paint on it to get access to pin 1+2
Put the board back in the car and connect it with the plugs.
Connect the Tacho Universal to the BMW diagnostic plug and the diagnostic port.
Disconnect the board from the car. If you connect it again, the new value will be
displayed.
Tacho Universal
BMW
page 3
Tacho Universal
www.efichip.com
Connect the plug with the blue port and put the 3 pin plug in the 4 pin
port left down on the instrument. Put this plug in as it is easy. If it is hart
to position, it is upside down!
Select the menu BMW Z3/COMPACT Diagnosis
The Tacho Universal does not show you the old value.
Enter the new value.
Verify the new value with OK.
If the Tacho Universal shows: remove plug, the programming was correct.
Otherwise control the position of the 3pin plug and try again.
Tacho Universal
BMW
page 4
Tacho Universal
www.efichip.com
Connect the cluster plug with the white and blue port and the Tacho
Universal
Tacho Universal
BMW
page 5
Tacho Universal
www.efichip.com
Connect the plug with the blue port and put the 3 pin plug in the 4 pin
port left down on the instrument. Put this plug in as it is easy. If it is hart
to position, it is upside down!
The Tacho Universal does not show you the old value.
If the Tacho Universal shows: remove plug, the programming was correct.
Otherwise control the position of the 3pin plug and try again
Tacho Universal
BMW
page 6
Tacho Universal
www.efichip.com
Tacho Universal
BMW
page 7
Tacho Universal
www.efichip.com
Modell Z3 Roadster Sw 9 up to Sw 11
Tacho Universal
BMW
page 8
Tacho Universal
www.efichip.com
Modell Z8
Tacho Universal
BMW
page 9
Tacho Universal
www.efichip.com
Tacho Universal
BMW
page 10
Tacho Universal
www.efichip.com
Tacho Universal
BMW
page 11
Tacho Universal
www.efichip.com
The Tacho Universal does not show you the old value.
If the value does not change, try again with the connector old.
Tacho Universal
BMW
page 12
Tacho Universal
www.efichip.com
The Tacho Universal does not show you the old value.
If the value does not change, try again with the connector old.- If it still
does not change, it may be a high IKE instrument. (2 Buttons, after ~
11/1997).
Tacho Universal
BMW
page 13
Tacho Universal
www.efichip.com
Connect the cluster plug with the white and blue port and the Tacho
universal. Ensure that the red point on each plug faces pin 1 on the
instruments port.
If you take a sharpe look at the display now, you can see the new value.
If it is good, press OK, if not, you can undo everything with STOP
Tacho Universal
BMW
page 14
Tacho Universal
www.efichip.com
Tacho Universal
BMW
page 15
Tacho Universal
www.efichip.com
Code-plug -brown
Tacho Universal
BMW
page 16
Tacho Universal
www.efichip.com
Turn the cross-shaped plastic pins on the back in a not disturbing position.
Look for the points on the board you can see on the picture. Remove the red
paint that covers the contacts.
The Tacho Universal shows you the old value. The Tacho Universal shows you the
old value, if it is wrong, go to Show. If the database is ok, you may continue.
If not check the cables.
Tacho Universal
BMW
page 17
Tacho Universal
Tacho Universal
www.efichip.com
BMW
page 18
Tacho Universal
www.efichip.com
Connect the Tacho Universal to the BMW diagnostic plug and the diagnostic
port.
The Tacho Universal does not show you the old value.
Tacho Universal
BMW
page 19
Tacho Universal
www.efichip.com
Connect the cluster plug with the white and blue port and the Tacho
Universal. Ensure that the red point on each plug faces pin 1 on the
instruments port.
The Tacho Universal shows you the hard- and softwareversion of the
instrument.
If you take a sharpe look at the display now, you can see the new value.
If it is good, press OK, if not, you can undo everything with STOP
Tacho Universal
BMW
page 20
Tacho Universal
www.efichip.com
Look for the points on the board you can see on the picture. Remove the
red paint that covers the contacts.
The Tacho Universal shows you the old value. The Tacho Universal shows
you the old value, if it is wrong, go to Show. If the database is ok, you
may continue. If not check the cables.
Tacho Universal
BMW
page 21
Tacho Universal
Tacho Universal
www.efichip.com
BMW
page 22
Tacho Universal
www.efichip.com
Connect the Tacho Universal to the BMW diagnostic plug and the
diagnostic port.
The Tacho Universal does not show you the old value.
If the new value is not displayed, try to program again with open doors,
open windows or any combination of it. If it still does not work, remove all
plugs from the instrument. Close and lock the car for about 2 minutes. Open
it, turn ignition on and program again. Put the instrument back in. Now it
should be ok.
If even this does not work, continue like this:
Tacho Universal
BMW
page 23
Tacho Universal
www.efichip.com
Tacho Universal
BMW
page 24
Tacho Universal
www.efichip.com
Look for the points on the board you can see on the picture. Remove the
red paint that covers the contacts.
The Tacho Universal shows you the old value. The Tacho Universal shows
you the old value, if it is wrong, go to Show. If the database is ok, you
may continue. If not check the cables.
Tacho Universal
BMW
page 25
Tacho Universal
Tacho Universal
www.efichip.com
BMW
page 26
Tacho Universal
www.efichip.com
This chip is used in all E46, E38, E39 and X5 after Model 2001. The model 2001
you recognize by the new OBD II-socket in the car interior, instead of the BMWtypical round socket in the motorroom.
This chip can be placed only upward, not downward.
So there are two possibilities to set the wanted value:
You can buy a new cluster (with a new chip inside), if you put
this cluster in a car he will get the original KM. This cluster
will be counted from 0 to the wanted value. This happens
about the plug 912
The original Chip M35080 will be replaced through a new one.
Tacho Universal
BMW
page 27
Tacho Universal
www.efichip.com
Connect the cables with the original cluster as described in the plan:
The Tacho Universal stored the original Dataset, confirm with a key.
Now you see a list of stored datasets. Load the newest one.
Tacho Universal
BMW
page 28
Tacho Universal
Grn: green
Tacho Universal
www.efichip.com
Gelb: yellow
Schwarz: black
BMW
Weiss: white
page 29
Tacho Universal
www.efichip.com
Tacho Universal
BMW
page 30
Tacho Universal
Tacho Universal
www.efichip.com
BMW
page 31
Tacho Universal
www.efichip.com
Tacho Universal
BMW
page 32
Tacho Universal
Tacho Universal
www.efichip.com
BMW
page 33
Tacho Universal
www.efichip.com
Connect the Plug with the black and the white socket at the cluster.
The Tacho Universal does not show you the old value.
Grn: green
Tacho Universal
Gelb: yellow
Schwarz: black
BMW
Weiss: white
page 34
Tacho Universal
www.efichip.com
m
LKM 3 series
LKM 5 series
EWS
Tacho Universal
BMW
page 35
Tacho Universal
www.efichip.com
Remove first the EWS (ignition lock) (driver floor space behind the cover), then
the LKM (front seat passenger side on the A-column) and then the cluster.
First erase the EWS, then the keys, program the LKM and then the instrument.
Put the modules back in the car: First the EWS, then the LKM and the cluster.
REMEMBER to check for the RED pin of the EWS.
Tacho Universal
BMW
page 36
Tacho Universal
www.efichip.com
Tacho Universal
BMW
page 37
Tacho Universal
Tacho Universal
www.efichip.com
BMW
page 38
Tacho Universal
www.efichip.com
Tacho Universal
BMW
page 39
Tacho Universal
Tacho Universal
www.efichip.com
BMW
page 40
Tacho Universal
www.efichip.com
Kurz auf Masse wenn Auslesen nicht mglich: Put it on Minus if you get no value
Hochlten & Gelb: lift pin & yellow cable - Hochlten & Blau: lift pin & blue cable
Tacho Universal
BMW
page 41
Tacho Universal
www.efichip.com
If you cant read out the value, connect a 1KOhm resistor to the brown marked
point, choose V3 and before you press OK hold the resistor on Minus(-)
Tacho Universal
BMW
page 42
Tacho Universal
www.efichip.com
If you get no value connect the blue (blau) and the yellow (gelb) cable directly to
the lifted pins of the processor (like the E46LKM)
Tacho Universal
BMW
page 43
Tacho Universal
www.efichip.com
If you get no value, connect the marked point with a 1,5KOhm resistor before the
reading shortly to the ring of the the power supply of the Tacho Universal (screw
3,5mm on the right side)
Gelb DATA: yellow DATA - Blau DATA: blue DATA
Tacho Universal
BMW
page 44
Tacho Universal
www.efichip.com
350080 Erase
1. Select the menu 3 series E46/35080 /35080->0
2. Please wait until OK is on the Tacho Universal
Tacho Universal
BMW
page 45
Tacho Universal
www.efichip.com
Tacho Universal
BMW
page 46
Tacho Universal
Tacho Universal
www.efichip.com
BMW
page 47
Tacho Universal
Tacho Universal
www.efichip.com
BMW
page 48
Tacho Universal
www.efichip.com
BMW Service
rcksetzen
For all BMW`s with the BMW Diagnosticport (not OBD-II)
Tacho Universal
BMW
page 49
Tacho Universal
www.efichip.com
Turn ignition off press left button and hold - ignition on position 1
Hold the left button till 5 seconds after Test 1 then Oilservice or
Inspection is displayed.
Press again the left button to reset the service, if you press not long
enough, the brake fluid interval will be displayed, you can press left to
reset it.
Tacho Universal
BMW
page 50
Tacho Universal
www.efichip.com
Connect the cable 912 with the cluster ports as described in the picture
Tacho Universal
BMW
page 51
Tacho Universal
Tacho Universal
www.efichip.com
BMW
page 52
Tacho Universal
www.efichip.com
Modell Z4
Tacho Universal
BMW
page 53
Tacho Universal
www.efichip.com
Cadillac
Modell Seville STS
Tacho Universal
Cadillac
page1
Tacho Universal
www.efichip.com
Tacho Universal
Chrysler
page 1
Tacho Universal
www.efichip.com
Chrysler-Diagnostic-plug:
Tacho Universal
Chrysler
page 2
Tacho Universal
www.efichip.com
The diagnostic port is near your left knee when you sit on the drivers
seat.
The Tacho Universal shows you the old value. A deviation of 1000 km is
normal.
Note:
If the new value is not displayed, you have to disconnect the battery for about 2
minutes.Important: Radiocode! (last page in the manual)
Tacho Universal
Chrysler
page 3
Tacho Universal
www.efichip.com
Tacho Universal
Chrysler
page 4
Tacho Universal
Tacho Universal
www.efichip.com
Chrysler
page 5
Tacho Universal
www.efichip.com
Chrysler-Diagnostic-plug:
Diagnostic-plug
The diagnostic port is near your left knee when you sit on the drivers
seat.
The Tacho Universal shows you the old value. A deviation of 1000 km is
normal.
Note: If the new value is not displayed, you have to disconnect the battery for
about 2 minutes. Important: Radiocode (last page in the manual)
Tacho Universal
Chrysler
page 6
Tacho Universal
www.efichip.com
Chrysler-Diagnostic-plug:
Diagnostic-plug
1. The diagnostic port is near your left knee when you sit on the drivers
seat.
2. Turn ignition on.
3. Connect the Tacho Universal to Chrysler diagnostic plug and the
diagnostic port. Use the connector CCD
4. Select the menu Chrysler-Chrysler Diagnose.
5. The Tacho Universal shows you the old value. A deviation of 1000 km is
normal.
6. Enter the new value
7. Verify the new value with OK.
Note:
If the new value is not displayed, you have to disconnect the battery for about 2
minutes.Important: Radiocode (last page in the manual)
Tacho Universal
Chrysler
page 7
Tacho Universa
www.efichip.com
Diagnostic-plug
The diagnostic port is near your left knee when you sit on the drivers
seat.
The Tacho Universal shows you the old value. A deviation of 1000 km is
normal.
Note:
If the new value is not displayed, you have to disconnect the battery for about 2
minutes.Important: Radiocode (last page in the manual)
Tacho Universal
Chrysler
page 8
Tacho Universal
www.efichip.com
Diagnostic-plug
The diagnostic port is near your left knee when you sit on the drivers
seat.
The Tacho Universal shows you the old value. A deviation of 1000 km is
normal.
Note:
If the new value is not displayed, you have to disconnect the battery for about 2
minutes.Important: Radiocode (last page in the manual)
Tacho Universal
Chrysler
page 9
Tacho Universal
www.efichip.com
Put the clip on the Chip 93C56 (rot auf Pin 1).
The Tacho Universal shows you the old value. If the value is not correct, try
Port 1 and Port 0.
Tacho Universal
Chrysler
page 10
Tacho Universal
www.efichip.com
Put the clip on the Chip 93C56 (rot auf Pin 1).
The Tacho Universal shows you the old value. If the value is not correct, try
Port 1 and Port 0.
Tacho Universal
Chrysler
page 11
Tacho Universal
www.efichip.com
Model PT Cruiser
Remove the motors with the needles from behind with the soldering iron.
Chrysler
page 12
Tacho Universal
www.efichip.com
Remove the motors with the needles from behind with the soldering iron.
Tacho Universal
Chrysler
page 13
Tacho Universal
www.efichip.com
Chrysler
page 14
Tacho Universal
www.efichip.com
Tacho Universal
Chrysler
page 15
Tacho Universal
www.efichip.com
page 16
Tacho Universal
www.efichip.com
Diagnostic-plug
1. The diagnostic port is near your left knee when you sit on the drivers
seat.
2. Turn ignition on.
3. Connect the Tacho Universal to Chrysler diagnostic plug
diagnostic port. Use the connector SRI.
and the
Note:
You dont need to program the memory, if the Tacho Universal reads 000000 as
old value!
Tacho Universal
Chrysler
page 17
Tacho Universal
www.efichip.com
Model Neon
Tacho Universal
Chrysler
page 18
Tacho Universal
www.efichip.com
Tacho Universal
Chrysler
page 19
Tacho Universal
www.efichip.com
Tacho Universal
Chrysler
page 20
Tacho Universal
Verbinden=connect
Tacho Universal
www.efichip.com
Widerstand=resistor
Chrysler
page 21
Tacho Universal
www.efichip.com
Tacho Universal
Chrysler
page 22
Tacho Universal
Verbinden=connect
Tacho Universal
www.efichip.com
Widerstand=resistor
Chrysler
page 23
Tacho Universal
www.efichip.com
Model Xsara
Model Xantia
Model Evasion
Model Dispatch
Model Synergy
Model Saxo
Model Jumpy
Model Xsara2003
Model C5 Tacho
Model C5 BSI
Model Jumper
<
Update Juli 03
Model C 3
<
Update Juli 03
Model C3 BSI
<
Update Juli 03
Tacho Universal
Citroen
page 1
Tacho Universal
www.efichip.com
Model Xsara
Use this board and plug:
Remove the motors carefully from the circuit board. Do not pull off the
needles!!!
Tacho Universal
Citroen
page 2
Tacho Universal
www.efichip.com
Model Xantia
Use this board and plug:
Tacho Universal
Citroen
page 3
Tacho Universal
www.efichip.com
Model Evasion
Use the Renault Megane / Peugeot 206 Plug:
1.
2.
3.
4.
5.
6.
Remove the cluster and open it. Look for the processor.
Connect the cables as shown in the picture.
Select the menu Citroen Evasion
The Tacho Universal shows you the old value.
Enter the new value.
Verify the new value with OK.
Tacho Universal
Citroen
page 4
Tacho Universal
www.efichip.com
Model Dispatch
Use the Renault Megane / Peugeot 206 Plug:
Remove the cluster and open it. Look for the processor.
Connect the cables as shown in the picture.
Select the menu Citroen Dispatch
The Tacho Universal shows you the old value.
Enter the new value.
Verify the new value with OK.
Tacho Universal
Citroen
page 5
Tacho Universal
www.efichip.com
Model Synergy
Use the Renault Megane / Peugeot 206 Plug:
Remove the cluster and open it. Look for the processor.
Connect the cables as shown in the picture.
Select the menu Citroen Synergy
The Tacho Universal shows you the old value.
Enter the new value.
Verify the new value with OK.
Tacho Universal
Citroen
page 6
Tacho Universal
www.efichip.com
Model Saxo
Connect the P106 Plug with the black socket at the instrument.
Tacho Universal
Citroen
page 7
Tacho Universal
www.efichip.com
Model Jumpy
908 Plug:
Remove the cluster and open it. Look for the processor.
Tacho Universal
Citroen
page 8
Tacho Universal
www.efichip.com
Tacho Universal
Citroen
page 9
Tacho Universal
www.efichip.com
Model C5 Cluster
Dont disconnect the batterie before you get the BSI out!
Ignition lock will be activated!
If the car doesnt start after the programming, lock and unlock it
with the keys, turn the ignition and wait for 10 minutes!.
Remove the cluster and open it. Look for the processor
Tacho Universal
Citroen
page 10
Tacho Universal
Tacho Universal
www.efichip.com
Citroen
page 11
Tacho Universal
www.efichip.com
Model C5 BSI
Dont disconnect the batterie before you get the BSI out!
Ignition lock will be activated!
If the car doesnt start after the programming, lock and unlock it
with the keys, turn the ignition and wait for 10 minutes!.
Open the module and look for the points in the picture.
First put back the BSI in the car and then the cluster.
Tacho Universal
Citroen
page 12
Tacho Universal
Tacho Universal
www.efichip.com
Citroen
page 13
Tacho Universal
www.efichip.com
Model Xsara2003
Tacho Universal
Citroen
page 14
Tacho Universal
Tacho Universal
www.efichip.com
Citroen
page 15
Tacho Universal
www.efichip.com
Remove the BSI-Module. You find it near your left knee when you sit on
the drivers seat
First put back the BSI in the car and then the cluster.
Citroen
page 16
Tacho Universal
www.efichip.com
Model C 3
Note: cluster and BSI have to be programmed with the same value
First put back the BSI in the car and then the cluster
Tacho Universal
Citroen
page 17
Tacho Universal
www.efichip.com
Model C3 BSI
Note: cluster and BSI have to be programmed with the same value!
Remove the BSI-Module. You find it near your left knee when you sit on
the drivers seat
First put back the BSI in the car and then the cluster.
Tacho Universal
Citroen
page 18
Tacho Universal
www.efichip.com
Model Jumper
Tacho Universal
Citroen
page 19
Tacho Universal
www.efichip.com
Model V40
Tacho Universal
Volvo
page 1
Tacho Universal
www.efichip.com
Model V40
There are 2 different versions, you have to remove the display at one
version, the other version is possible without removing the display.
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Volvo
page 2
Tacho Universal
www.efichip.com
remove the display with a soldering iron and remove the screws
Tacho Universal
Volvo
page 3
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Volvo
page 4
Tacho Universal
www.efichip.com
Tacho Universal
Volvo
Kabel=cable
hochlten=lift pin
page 5
Tacho Universal
www.efichip.com
Tacho Universal
Volvo
page 6
Tacho Universal
www.efichip.com
Volvo
page 7
Tacho Universal
www.efichip.com
Tacho Universal
Volvo-S60S70S80/ 912
Volvo
page 8
Tacho Universal
www.efichip.com
Volvo
page 9
Tacho Universal
www.efichip.com
Tacho Universal
Volvo-S60S70S80/ 912
Volvo
page 10
Tacho Universal
Tacho Universal
www.efichip.com
Volvo
page 11
Tacho Universal
www.efichip.com
Model Yaris
Model Avensis
Model Camry
Model Corolla
Model Rav4
Model Picnic
Model Landcruiser
Model Avensis Verso
Model Corolla 2002
Model Cellica
Model Hiace
Model Prado
Model Landcruiser HJ 100
Model Prius
Model CorollaVerso
Update Juli 03
Update Juli 03
Tacho Universal
Toyota
page 1
Tacho Universal
www.efichip.com
Model Yaris
Remove the cluster and open the black module on the back.
Look for the 8 pin chip 93C46.
Look for the silver crystal near the chip and join its contacts.
Connect the clip to Port 0.
Tacho Universal
Toyota
page 2
Tacho Universal
www.efichip.com
Model Avensis
Remove the cluster and open the black module on the back.
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Toyota
page 3
Tacho Universal
www.efichip.com
Update Juli 03
Renault
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 2
Tacho Universal
www.efichip.com
The instrument looks like this (the control lamps are combined in the center
into a block):
Tacho Universal
Renault
page 3
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 4
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 5
Tacho Universal
www.efichip.com
Version 1
Tacho Universal
Renault
page 6
Tacho Universal
www.efichip.com
Version 2
Tacho Universal
Renault
page 7
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 8
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 9
Tacho Universal
www.efichip.com
1. Remove the BCU and open it. It is in the front seat passenger floor space
under the floor mat.
2. Connect the cables as shown in the picture.
3. Connect the 908-plug with the Tacho Universal.
4. Select the menu Renault-Espace 2000-Body Controller
5. The Tacho Universal shows you the old value.
6. Enter the new value. Verify the new value with OK.
7. Now put back in the BCU first, then the instrument.
Tacho Universal
Renault
page 10
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 11
Tacho Universal
www.efichip.com
1. Remove the cluster and open it. You have to pull off the needles and
unclip the motors carefully.
2. Look for the processor as shown in the picture.
3. Connect the cables as shown in the picture.
4. Connect the plug with the Tacho Universal.
5. Select the menu Renault-Clio II- Jaeger 908
6. The Tacho Universal shows you the old value.
7. Enter the new value.
8. Verify the new value with OK.
Tacho Universal
Renault
page 12
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 13
Tacho Universal
www.efichip.com
Tacho Universal
Renault
for cable1
page 14
Tacho Universal
www.efichip.com
page 15
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 16
Tacho Universal
www.efichip.com
The instrument looks like this (the control lamps are combined in the center
into a block):
Tacho Universal
Renault
page 17
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 18
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 19
Tacho Universal
www.efichip.com
Version 1
Tacho Universal
Renault
page 20
Tacho Universal
www.efichip.com
Version 2
Tacho Universal
Renault
page 21
Tacho Universal
www.efichip.com
Model Safrane
Tacho Universal
Renault
page 22
Tacho Universal
www.efichip.com
Model Twingo
Alfa 145/146/Twingo-plug:
1.
2.
3.
4.
5.
6.
Tacho Universal
Renault
page 23
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 24
Tacho Universal
www.efichip.com
Remove the cluster and open it. You have to pull off the needles and unclip
the motors carefully.
Tacho Universal
Renault
page 25
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 26
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 27
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 28
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 29
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 30
Tacho Universal
www.efichip.com
page 31
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 32
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 33
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 34
Tacho Universal
www.efichip.com
Tacho Universal
verbinden: connect
Renault
page 35
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 36
Tacho Universal
www.efichip.com
Tacho Universal
verbinden: connect
Renault
page 37
Tacho Universal
www.efichip.com
Model Trafic
Tacho Universal
Renault
page 38
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 39
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 40
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 41
Tacho Universal
www.efichip.com
verbinden: connect
Renault
page 42
Tacho Universal
www.efichip.com
Renault
page 43
Tacho Universal
www.efichip.com
Model 928
Tacho Universal
Porsche
page 1
Tacho Universal
www.efichip.com
Model 928
Tacho Universal
Porsche
page 2
Tacho Universal
www.efichip.com
Diagnostic programming
The diagnostic port is near your left knee when you sit on the drivers
seat.
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
The Tacho Universal does not show you the old value.
Tacho Universal
Porsche
page 3
Tacho Universal
www.efichip.com
Tacho Universal
Porsche
page 4
Tacho Universal
Tacho Universal
www.efichip.com
Porsche
page 5
Tacho Universal
www.efichip.com
Diagnostic programming
The diagnostic port is near your left knee when you sit on the drivers
seat
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
The Tacho Universal does not show you the old value.
Tacho Universal
Porsche
page 6
Tacho Universal
www.efichip.com
Tacho Universal
Porsche
page 7
Tacho Universal
Tacho Universal
www.efichip.com
Porsche
page 8
Tacho Universal
www.efichip.com
Model Cayenne
Tacho Universal
Adjust KM.
Porsche
page 9
Tacho Universal
www.efichip.com
Model 206
Model 306
Tacho Universal
Peugeot
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 2
Tacho Universal
www.efichip.com
<
Update Juli 03
Model Expert
Model 307
Model 106
Model 206 2001
Model 206 2003
Model Boxer
Model 206
Tacho Universal
Peugeot
page 3
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 4
Tacho Universal
www.efichip.com
Model 306
The Tacho Universal does not show you the old value.
Tacho Universal
Peugeot
page 5
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 6
Tacho Universal
www.efichip.com
1.
2.
3.
4.
5.
6.
7.
Hochlten: Lift pin Blau: blue Rot: red Grn: green Gelb: yellow
DATA: separate DATA cable Pin1 red (+12V) Pin 19 black (ground -)
Tacho Universal
Peugeot
page 7
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 8
Tacho Universal
www.efichip.com
Now remove the BSI-module. It is under the steering wheel near your left
foot when you sit inside.
Open the BSI Module. For some versions you have to break the box to open
it.
Look for the 8 pin Chip 96C66.
Remove this chip from the board.
Connect the clip to Port 0.
Put the clip on the chip 93C66 (RED on Pin 1).
Select the menu Peugeot-406-VDO-BSI V1.
The Tacho Universal does not show you the old value.
Now look at the data-base.
You have to find out what version you have:
Note:
BSI-Version 2 has 2 times the same combination in the data-base.
Tacho Universal
Peugeot
page 9
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 10
Tacho Universal
www.efichip.com
The BSI-versions V2 and V3 you recognise by the same two values in the
data-base. After reading and saving the BSI-Data, look at the data-base.
The Tacho Universal should show a data-base similar to the example database. Go to the position 042 (V3 position 04D), write down the data up to
position 045 (V3 up to position 051). Go to the position 0ED (V3 position
10A). Compare these 4 values with the noticed values. In the example
they are the same, so it is a version 2 BSI. If the values are not the dame,
it is a version 1 BSI. If you have identified the version, program 0 as new
value (Adjust KM).
Remove the eeproms from the BSI and from the cluster for programming
If you connect the pins 6 and 8 in the clip you can read the eeproms
much easier (Port 1)
Tacho Universal
Peugeot
page 11
Tacho Universal
www.efichip.com
Model 806
1.
2.
3.
4.
5.
6.
Tacho Universal
Peugeot
page 12
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 13
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 14
Tacho Universal
www.efichip.com
Now remove the BSI-module. It is under the steering wheel near your left
foot when you sit inside.
Now put back in the BSI-module and after that the instrument.
Tacho Universal
Peugeot
page 15
Tacho Universal
www.efichip.com
Verbinden = CONNECT
Tacho Universal
Peugeot
page 16
Tacho Universal
www.efichip.com
Model Expert
908 plug:
Important: Lift the processor pins, which are connected with a cable
Tacho Universal
Peugeot
page 17
Tacho Universal
www.efichip.com
Model 307
Remove the BSI-module. It is under the steering wheel near your left foot
when you sit inside.
Tacho Universal
Peugeot
page 18
Tacho Universal
www.efichip.com
Important!
The old 912 plug must be supplemented with the new cable3 from Pin21. The 307
will be programmed only by the BSI. The old value will be shown.
Tacho Universal
Peugeot
page 19
Tacho Universal
www.efichip.com
Model 106
Connect the P106 plug with the black port at the cluster.
Tacho Universal
Peugeot
page 20
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 21
Tacho Universal
www.efichip.com
Update Juli 03
Renault
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 2
Tacho Universal
www.efichip.com
The instrument looks like this (the control lamps are combined in the center
into a block):
Tacho Universal
Renault
page 3
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 4
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 5
Tacho Universal
www.efichip.com
Version 1
Tacho Universal
Renault
page 6
Tacho Universal
www.efichip.com
Version 2
Tacho Universal
Renault
page 7
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 8
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 9
Tacho Universal
www.efichip.com
1. Remove the BCU and open it. It is in the front seat passenger floor space
under the floor mat.
2. Connect the cables as shown in the picture.
3. Connect the 908-plug with the Tacho Universal.
4. Select the menu Renault-Espace 2000-Body Controller
5. The Tacho Universal shows you the old value.
6. Enter the new value. Verify the new value with OK.
7. Now put back in the BCU first, then the instrument.
Tacho Universal
Renault
page 10
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 11
Tacho Universal
www.efichip.com
1. Remove the cluster and open it. You have to pull off the needles and
unclip the motors carefully.
2. Look for the processor as shown in the picture.
3. Connect the cables as shown in the picture.
4. Connect the plug with the Tacho Universal.
5. Select the menu Renault-Clio II- Jaeger 908
6. The Tacho Universal shows you the old value.
7. Enter the new value.
8. Verify the new value with OK.
Tacho Universal
Renault
page 12
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 13
Tacho Universal
www.efichip.com
Tacho Universal
Renault
for cable1
page 14
Tacho Universal
www.efichip.com
page 15
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 16
Tacho Universal
www.efichip.com
The instrument looks like this (the control lamps are combined in the center
into a block):
Tacho Universal
Renault
page 17
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 18
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 19
Tacho Universal
www.efichip.com
Version 1
Tacho Universal
Renault
page 20
Tacho Universal
www.efichip.com
Version 2
Tacho Universal
Renault
page 21
Tacho Universal
www.efichip.com
Model Safrane
Tacho Universal
Renault
page 22
Tacho Universal
www.efichip.com
Model Twingo
Alfa 145/146/Twingo-plug:
1.
2.
3.
4.
5.
6.
Tacho Universal
Renault
page 23
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 24
Tacho Universal
www.efichip.com
Remove the cluster and open it. You have to pull off the needles and unclip
the motors carefully.
Tacho Universal
Renault
page 25
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 26
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 27
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 28
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 29
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 30
Tacho Universal
www.efichip.com
page 31
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 32
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 33
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 34
Tacho Universal
www.efichip.com
Tacho Universal
verbinden: connect
Renault
page 35
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 36
Tacho Universal
www.efichip.com
Tacho Universal
verbinden: connect
Renault
page 37
Tacho Universal
www.efichip.com
Model Trafic
Tacho Universal
Renault
page 38
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 39
Tacho Universal
Tacho Universal
www.efichip.com
Renault
page 40
Tacho Universal
www.efichip.com
Tacho Universal
Renault
page 41
Tacho Universal
www.efichip.com
verbinden: connect
Renault
page 42
Tacho Universal
www.efichip.com
Renault
page 43
Tacho Universal
www.efichip.com
Model 928
Tacho Universal
Porsche
page 1
Tacho Universal
www.efichip.com
Model 928
Tacho Universal
Porsche
page 2
Tacho Universal
www.efichip.com
Diagnostic programming
The diagnostic port is near your left knee when you sit on the drivers
seat.
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
The Tacho Universal does not show you the old value.
Tacho Universal
Porsche
page 3
Tacho Universal
www.efichip.com
Tacho Universal
Porsche
page 4
Tacho Universal
Tacho Universal
www.efichip.com
Porsche
page 5
Tacho Universal
www.efichip.com
Diagnostic programming
The diagnostic port is near your left knee when you sit on the drivers
seat
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
The Tacho Universal does not show you the old value.
Tacho Universal
Porsche
page 6
Tacho Universal
www.efichip.com
Tacho Universal
Porsche
page 7
Tacho Universal
Tacho Universal
www.efichip.com
Porsche
page 8
Tacho Universal
www.efichip.com
Model Cayenne
Tacho Universal
Adjust KM.
Porsche
page 9
Tacho Universal
www.efichip.com
Model 206
Model 306
Tacho Universal
Peugeot
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 2
Tacho Universal
www.efichip.com
<
Update Juli 03
Model Expert
Model 307
Model 106
Model 206 2001
Model 206 2003
Model Boxer
Model 206
Tacho Universal
Peugeot
page 3
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 4
Tacho Universal
www.efichip.com
Model 306
The Tacho Universal does not show you the old value.
Tacho Universal
Peugeot
page 5
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 6
Tacho Universal
www.efichip.com
1.
2.
3.
4.
5.
6.
7.
Hochlten: Lift pin Blau: blue Rot: red Grn: green Gelb: yellow
DATA: separate DATA cable Pin1 red (+12V) Pin 19 black (ground -)
Tacho Universal
Peugeot
page 7
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 8
Tacho Universal
www.efichip.com
Now remove the BSI-module. It is under the steering wheel near your left
foot when you sit inside.
Open the BSI Module. For some versions you have to break the box to open
it.
Look for the 8 pin Chip 96C66.
Remove this chip from the board.
Connect the clip to Port 0.
Put the clip on the chip 93C66 (RED on Pin 1).
Select the menu Peugeot-406-VDO-BSI V1.
The Tacho Universal does not show you the old value.
Now look at the data-base.
You have to find out what version you have:
Note:
BSI-Version 2 has 2 times the same combination in the data-base.
Tacho Universal
Peugeot
page 9
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 10
Tacho Universal
www.efichip.com
The BSI-versions V2 and V3 you recognise by the same two values in the
data-base. After reading and saving the BSI-Data, look at the data-base.
The Tacho Universal should show a data-base similar to the example database. Go to the position 042 (V3 position 04D), write down the data up to
position 045 (V3 up to position 051). Go to the position 0ED (V3 position
10A). Compare these 4 values with the noticed values. In the example
they are the same, so it is a version 2 BSI. If the values are not the dame,
it is a version 1 BSI. If you have identified the version, program 0 as new
value (Adjust KM).
Remove the eeproms from the BSI and from the cluster for programming
If you connect the pins 6 and 8 in the clip you can read the eeproms
much easier (Port 1)
Tacho Universal
Peugeot
page 11
Tacho Universal
www.efichip.com
Model 806
1.
2.
3.
4.
5.
6.
Tacho Universal
Peugeot
page 12
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 13
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 14
Tacho Universal
www.efichip.com
Now remove the BSI-module. It is under the steering wheel near your left
foot when you sit inside.
Now put back in the BSI-module and after that the instrument.
Tacho Universal
Peugeot
page 15
Tacho Universal
www.efichip.com
Verbinden = CONNECT
Tacho Universal
Peugeot
page 16
Tacho Universal
www.efichip.com
Model Expert
908 plug:
Important: Lift the processor pins, which are connected with a cable
Tacho Universal
Peugeot
page 17
Tacho Universal
www.efichip.com
Model 307
Remove the BSI-module. It is under the steering wheel near your left foot
when you sit inside.
Tacho Universal
Peugeot
page 18
Tacho Universal
www.efichip.com
Important!
The old 912 plug must be supplemented with the new cable3 from Pin21. The 307
will be programmed only by the BSI. The old value will be shown.
Tacho Universal
Peugeot
page 19
Tacho Universal
www.efichip.com
Model 106
Connect the P106 plug with the black port at the cluster.
Tacho Universal
Peugeot
page 20
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 21
Tacho Universal
www.efichip.com
Now remove the BSI-module. It is under the steering wheel near your left
foot when you sit inside.
Now put back in the BSI-module and after that the instrument.
Tacho Universal
Peugeot
page 22
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 23
Tacho Universal
www.efichip.com
Now remove the BSI-module. It is under the steering wheel near your left
foot when you sit inside.
Now put back in the BSI-module and after that the instrument.
Tacho Universal
Peugeot
page 24
Tacho Universal
www.efichip.com
Model Boxer
Tacho Universal
Peugeot
page 25
Tacho Universal
www.efichip.com
Tacho Universal
Peugeot
page 26
Tacho Universal
www.efichip.com
Model Concept
Tacho Universal
Peugeot
page 27
Tacho Universal
www.efichip.com
Model Omega
Update Juli 03
Model Combo
Update Juli 03
Tacho Universal
OPEL
page 1
Tacho Universal
www.efichip.com
Diagnostic programming
Tacho Universal
OPEL
page 2
Tacho Universal
www.efichip.com
Tacho Universal
OPEL
page 3
Tacho Universal
Tacho Universal
www.efichip.com
OPEL
page 4
Tacho Universal
www.efichip.com
Diagnostic programming
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
The Tacho Universal does not show you the old value.
Tacho Universal
OPEL
page 5
Tacho Universal
www.efichip.com
Tacho Universal
OPEL
page 6
Tacho Universal
www.efichip.com
Diagnostic programming
Tacho Universal
OPEL
page 7
Tacho Universal
www.efichip.com
Diagnostic programming
Tacho Universal
OPEL
page 8
Tacho Universal
www.efichip.com
Tacho Universal
OPEL
page 9
Tacho Universal
www.efichip.com
Diagnostic programming
Tacho Universal
OPEL
page 10
Tacho Universal
www.efichip.com
Tacho Universal
OPEL
page 11
Tacho Universal
Tacho Universal
www.efichip.com
OPEL
page 12
Tacho Universal
www.efichip.com
Diagnostic programming
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
The Tacho Universal does not show you the old value.
Tacho Universal
OPEL
page 13
Tacho Universal
www.efichip.com
Model Corsa
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
The Tacho Universal does not show you the old value.
When the Tacho Universal shows Press press the reset button of the
day-km and hold it until the Tacho Universal goes back into the main
menue.
After this open the motorroom and remove the fuse nr.3 for about 30
seconds.
Tacho Universal
OPEL
page 14
Tacho Universal
www.efichip.com
OPEL
page 15
Tacho Universal
www.efichip.com
Diagnostic programming
Tacho Universal
OPEL
page 16
Tacho Universal
www.efichip.com
Model Monterey
Tacho Universal
OPEL
page 17
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
OPEL
page 18
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
OPEL
page 19
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
OPEL
page 20
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
OPEL
page 21
Tacho Universal
www.efichip.com
Model Omega
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
OPEL
page 22
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
OPEL
page 23
Tacho Universal
www.efichip.com
Model Vivaro
Tacho Universal
OPEL
page 24
Tacho Universal
www.efichip.com
Tacho Universal
OPEL
page 25
Tacho Universal
Tacho Universal
www.efichip.com
OPEL
page 26
Tacho Universal
www.efichip.com
Model Combo
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
Tacho Universal
OPEL
page 27
Tacho Universal
www.efichip.com
Model Almera
Model Almera2000
Model Almera2001
Model Maxima
Model Maxima2001
Model Micra
Model Primera before 1999
Model Primera ab 1999
Model Primera 2000
Model Primera 2001
Model Patrol
Model Pathfinder
Model Nawaro
Model Pickup
Model Pickup Bj 2000
Model Terrano
Model X-Trail
Model Skyline
Model Infinity
Model Terrano 2002
Model Tino
Primera 2002
Model Pickup Bj 2002/2003
Tacho Universal
Nissan
page 1
Tacho Universal
www.efichip.com
Model Almera
Tacho Universal
Nissan
page 2
Tacho Universal
www.efichip.com
Model Maxima
Tacho Universal
Nissan
page 3
Tacho Universal
www.efichip.com
Model Micra
Tacho Universal
Nissan
page 4
Tacho Universal
www.efichip.com
Tacho Universal
Nissan
page 5
Tacho Universal
www.efichip.com
Tacho Universal
Nissan
page 6
Tacho Universal
www.efichip.com
Model Patrol
Tacho Universal
Nissan
page 7
Tacho Universal
www.efichip.com
Model Pathfinder
Tacho Universal
Nissan
page 8
Tacho Universal
www.efichip.com
Model Nawaro
Tacho Universal
Nissan
page 9
Tacho Universal
www.efichip.com
Model Pickup
Tacho Universal
Nissan
page 10
Tacho Universal
www.efichip.com
Model Terrano
plug:908
Tacho Universal
Nissan
page 11
Tacho Universal
www.efichip.com
Model X-Trail
Tacho Universal
Nissan
page 12
Tacho Universal
www.efichip.com
Model Almera2000
Tacho Universal
Nissan
page 13
Tacho Universal
www.efichip.com
Model Almera2001
Tacho Universal
Nissan
page 14
Tacho Universal
www.efichip.com
Model Maxima2001
Tacho Universal
Nissan
page 15
Tacho Universal
www.efichip.com
Tacho Universal
Nissan
page 16
Tacho Universal
www.efichip.com
Model Skyline
Tacho Universal
Nissan
page 17
Tacho Universal
www.efichip.com
Model Infinity
Nissan
page 18
Tacho Universal
www.efichip.com
Tacho Universal
Nissan
page 19
Tacho Universal
www.efichip.com
Nissan
page 20
Tacho Universal
www.efichip.com
Tacho Universal
Nissan
page 21
Tacho Universal
www.efichip.com
Model Tino
Tacho Universal
Nissan
page 22
Tacho Universal
www.efichip.com
Primera 2002
Tacho Universal
Nissan
page 23
Tacho Universal
Tacho Universal
www.efichip.com
Nissan
page 24
Tacho Universal
www.efichip.com
Tacho Universal
Nissan
page 25
Tacho Universal
www.efichip.com
Nissan
page 26
Tacho Universal
www.efichip.com
Model Spacegear
Model Spacewagon
Model Spacestar
Model Charisma
Model Colt
Model Lancer
Model Pajero before Model 2000
Model Pajero Model 2000
Model Shogun before Model 2000
Model Shogun Model 2000
Model Pinin
Model Pinin Soldering work
Model Spacegear with Yazaki
Model Spacerunner
Tacho Universal
Mitsubishi
page 1
Tacho Universal
www.efichip.com
Model Spacegear
Tacho Universal
Mitsubishi
page 2
Tacho Universal
www.efichip.com
Model Spacewagon
Tacho Universal
Mitsubishi
page 3
Tacho Universal
www.efichip.com
Model Spacestar
Put the clip on the Chip 93C46 or S130 (RED on Pin 1).
Tacho Universal
Mitsubishi
page 4
Tacho Universal
www.efichip.com
Model Charisma
Put the clip on the Chip 93C46 or OKI.... (RED on Pin 1).
Tacho Universal
Mitsubishi
page 5
Tacho Universal
www.efichip.com
Model Colt
Tacho Universal
Mitsubishi
page 6
Tacho Universal
www.efichip.com
Model Lancer
Put the clip on the Chip 93C46 or AD0970 (RED on Pin 1).
Tacho Universal
Mitsubishi
page 7
Tacho Universal
www.efichip.com
Tacho Universal
Mitsubishi
page 8
Tacho Universal
www.efichip.com
Tacho Universal
Mitsubishi
page 9
Tacho Universal
www.efichip.com
Tacho Universal
Mitsubishi
page 10
Tacho Universal
www.efichip.com
Tacho Universal
Mitsubishi
page 11
Tacho Universal
www.efichip.com
Model Pinin
Tacho Universal
Mitsubishi
page 12
Tacho Universal
www.efichip.com
Tacho Universal
Mitsubishi
page 13
Tacho Universal
www.efichip.com
Model Spacerunner
Tacho Universal
Mitsubishi
page 14
Tacho Universal
www.efichip.com
Tacho Universal
Mitsubishi
page 15
Tacho Universal
www.efichip.com
Pinin
Tacho Universal
Mitsubishi
page 16
Tacho Universal
www.efichip.com
Tacho Universal
Mini Cooper
page 1
Tacho Universal
Tacho Universal
www.efichip.com
Mini Cooper
page 2
Tacho Universal
www.efichip.com
Mini Cooper
page 3
Tacho Universal
Tacho Universal
www.efichip.com
Mini Cooper
page 4
Tacho Universal
www.efichip.com
Change the silver crystal to a 4Mhz Type
BCU
Remove the BCU. Right floor space (A column)
Have a look in the picture
Remove 2x Torx screws (lower shield)
remove the sideshield carefully
B
C
U
Tacho Universal
Mini Cooper
page 5
Tacho Universal
www.efichip.com
Cluster
Remove 4x Torx screws
Remove the shield over the driving wheel carefully and pull it
forward
Tacho Universal
Mini Cooper
page 6
Tacho Universal
www.efichip.com
Cluster
Tacho Universal
Mini Cooper
page 7
Tacho Universal
www.efichop.com
Model MGF
Tacho Universal
Adjust KM.
MG
page 1
Tacho Universal
www.efichop.com
Tacho Universal
Mercedes
Page 1
Tacho Universal
www.efichop.com
Tacho Universal
Mercedes
Page 2
Tacho Universal
www.efichop.com
Tacho Universal
Mercedes
Page 3
Tacho Universal
www.efichop.com
Hint:
W209 - Removing the cluster:
Use the Mercedes-hooks, turn them up, then you can get
the cluster out easily.
Tacho Universal
Mercedes
Page 4
Tacho Universal
www.efichop.com
Note:
If the new value returns after a second to the old value, it is a model
2000 or a new cluster.
Tacho Universal
Mercedes
Page 5
Tacho Universal
www.efichop.com
Tacho Universal
Mercedes
Page 6
Tacho Universal
www.efichop.com
Tacho Universal
Mercedes
Page 7
Tacho Universal
www.efichop.com
Motometer-Plug:
1. Remove the cluster.
2. Leave all plugs on the cluster.
3. On the rear side there is a small hole into that the 4-contactprogramming plug fits exactly.
4. Connect the Plug with the Cluster and the Tacho Universal.
5. Turn ignition on.
6. Select the menu Mercedes-C-Class-Motometer 9/95
7. The Tacho Universal does not show you the old value
8. Enter the new value.
9. Verify the new value with OK.
Tacho Universal
Mercedes
Page 8
Tacho Universal
www.efichop.com
Motometer-Plug
The Tacho Universal does not show you the old value
Tacho Universal
Mercedes
Page 9
Tacho Universal
www.efichop.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
1. The diagnostic port is in the motorroom ander a round cover.
2. Turn ignition on.
3. Connect the Tacho Universal with the Mercedes-Diagnostic-plug and with
the Diagnostic-socket.
4. Select the menu Mercedes-C-Class-Bj 9/95-4/98
5. The Tacho Universal shows you the old value
6. Enter the new value.
7. Verify the new value with OK.
Tacho Universal
Mercedes
Page 10
Tacho Universal
www.efichop.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 11
Tacho Universal
www.efichop.com
Tacho Universal
Mercedes
Page 12
Tacho Universal
www.efichop.com
C-Class 2000 Mod. 2000 CPU.
Select the menu MERCEDES C-Class C-Class 2000 Mod. 2000 CPU.
6.
Note:
How to erase error:
1. Turn engine on.
2. Press R button on the instrument, hold it. Turn the steering wheel
full left for 5 seconds, then full right 5 seconds.
Tacho Universal
Mercedes
Page 13
Tacho Universal
www.efichop.com
Turn out the cluster and disassemble it, until you see the 8 pin Chip
93C86.
Tacho Universal
Mercedes
Page 14
Tacho Universal
www.efichop.com
Open the black ignition-lock-module and look for the the 64-pin
Processor from Motorola.
Type in the old original value of the car. If the program starts you see in
the try the readen KM and the amount of tries in the display.
If the Tacho makes a new try - tip with a wet finger for ~ 1 second (not
longer) on the both cables marked with the blue hand. You have to make
3 to 5 tipps per second.
If the Tacho shows you the right value, you have programed the module.
Now put back in first the ignition lock and then the instrument.
Note:
How to erase error:
1. Turn engine on.
2. Press R button on the instrument, hold it. Turn the steering wheel
full left for 5 seconds, then full right 5 seconds.
Hint for the picture:
Baustein auslten: remove this component from the board
Tacho Universal
Mercedes
Page 15
Tacho Universal
www.efichop.com
Baustein
auslten
1,7 MOhm
Tacho Universal
Mercedes
Page 16
Tacho Universal
www.efichop.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 17
Tacho Universal
www.efichop.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 18
Tacho Universal
www.efichop.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
1. The diagnostic port is in the motorroom ander a round cover.
2. Turn ignition on.
3. Connect the Tacho Universal with the Mercedes-Diagnostic-plug and with
the Diagnostic-socket.
4. Select the menu Mercedes-E-Class-Diagnosis 7/995. The Tacho Universal does not show you the old value
6. Enter the new value.
7. Verify the new value with OK.
Tacho Universal
Mercedes
Page 19
Tacho Universal
www.efichop.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 20
Tacho Universal
www.efichop.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 21
Tacho Universal
www.efichop.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 22
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 23
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
1. The diagnostic port is in the motorroom in the fuse-box
2. Turn ignition on.
3. Connect the Tacho Universal with the Mercedes-Diagnostic-plug and with
the Diagnostic-socket.
4. Select the menu Mercedes-CE-S- 4/985. The Tacho Universal shows you the old value
6. Enter the new value.
7. Verify the new value with OK.
Tacho Universal
Mercedes
Page 24
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 25
Tacho Universal
www.efichip.com
Programming by diagnostic
Tacho Universal
Mercedes
Page 26
Tacho Universal
www.efichip.com
Programming by diagnostic
1. The diagnostic port is near your left knee when you sit on the drivers
seat.
2. Turn ignition on.
3. Connect the Tacho Universal with Mercedes OBD II - Plug and with the
Diagnostic-socket.
4. Select the menu Mercedes-C-E-S- 4/985. The Tacho Universal shows you the old value
6. Enter the new value.
7. Verify the new value with OK.
Tacho Universal
Mercedes
Page 27
Tacho Universal
www.efichip.com
S-Class-Cluster-plug:
1. Remove the cluster.
2. Connect the S-Class-Cluster-plug with the cluster and the Tacho Universal.
3. Select the menu Mercedes-S-Class-VDO 6/96
4. The Tacho Universal does not show you the old value
5. Enter the new value.
6. Verify the new value with OK.
Tacho Universal
Mercedes
Page 28
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 29
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 30
Tacho Universal
www.efichip.com
S-Class-Cluster-plug:
Tacho Universal
Mercedes
Page 31
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 32
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 33
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 34
Tacho Universal
www.efichip.com
HINT:
Hochlten - Lift Pin
Pin am Prozessor hochlten & verbinden Lift pins at the processor and connect
Tacho Universal
Mercedes
Page 35
Tacho Universal
www.efichip.com
S-Class-Cluster-plug:
Tacho Universal
Mercedes
Page 36
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
1. Turn ignition on.
2. Connect the Tacho Universal with the Mercedes-Diagnostic-plug and with
the Diagnostic-socket.
3. Select the menu Mercedes-S-Class-Bj 6/96-4/98
4. The Tacho Universal shows you the old value
5. Enter the new value.
6. Verify the new value with OK.
Tacho Universal
Mercedes
Page 37
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
1. The diagnostic port is in the motorroom ander a round cover.
2. Turn ignition on.
3. Connect the Tacho Universal with the Mercedes-Diagnostic-plug and with
the Diagnostic-socket.
4. Select the menu Mercedes-CE-S- 4/985. The Tacho Universal shows you the old value
6. Enter the new value.
7. Verify the new value with OK
Tacho Universal
Mercedes
Page 38
Tacho Universal
www.efichip.com
1.
2.
3.
4.
5.
6.
7.
8.
9.
Tacho Universal
Mercedes
Page 39
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 40
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 41
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 42
Tacho Universal
www.efichip.com
Model M Class
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mercedes
Page 43
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 44
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 45
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 46
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 47
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 48
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
1. The diagnostic port is in the motorroom ander a round cover.
2. Turn ignition on.
3. Connect the Tacho Universal with the Mercedes-Diagnostic-plug and with
the Diagnostic-socket.
4. Select the menu Mercedes-CE-S- 4/985. The Tacho Universal shows you the old value
6. Enter the new value.
7. Verify the new value with OK.
Tacho Universal
Mercedes
Page 49
Tacho Universal
www.efichip.com
Programming by diagnostic
1. The diagnostic port is near your left knee when you sit on the drivers
seat.
2. Turn ignition on.
3. Connect the Tacho Universal to the diagnostic plug and the diagnostic port
4. Select the menu Mercedes-CE-S- 4/985. The Tacho Universal shows you the old value
6. Enter the new value.
7. Verify the new value with OK.
Tacho Universal
Mercedes
Page 50
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 51
Tacho Universal
www.efichip.com
Sprinter Kienzle-Plug:
Tacho Universal
Mercedes
Page 52
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 53
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mercedes
Page 54
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 55
Tacho Universal
www.efichip.com
Remove the cluster and open it, Look for the 8 pin chip Chip 24C04. Try to leave the small
battery connected, otherwise the date will be erased! For older versions you have to
unsolder one of the small motors to get access to the eeprom.
Tacho Universal
Mercedes
Page 56
Tacho Universal
www.efichip.com
1. Remove the cluster and open it. Be carefull when opening it!
2. Connect the cables as shown in the picture.
3. Connect the Plug with the Tacho Universal.
4. Select the menu Mercedes-Sprinter-Magneti-Marelli Prototyp (68HC) or Final Version.
5. The Tacho Universal shows you the old value. If it is not correct, try the other version.
Program only with the right version.
6. Choose in the Menu Adjust KM.
7. Enter the new value.
Tacho Universal
Mercedes
Page 57
Tacho Universal
www.efichip.com
Version 1:
Tacho Universal
Mercedes
Page 58
Tacho Universal
www.efichip.com
Version 2:
Tacho Universal
Mercedes
Page 59
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 60
Tacho Universal
www.efichip.com
:
Use the Sprinter VDO-Cluster-plug
Tacho Universal
Mercedes
Page 61
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 62
Tacho Universal
www.efichip.com
1. Remove the cluster and open it. Be carefull when opening it!
2. Connect the cables as shown in the picture.
3. Connect the Plug with the Tacho Universal.
4. Select the menu Mercedes-Sprinter-Magneti-Marelli Prototyp (68HC) or
Final Version.
5. The Tacho Universal shows you the old value. If it is not correct, try the
other version. Program only with the right version.
6. Choose in the Menu Adjust KM.
7. Enter the new value.
8. Verify the new value with OK.
Tacho Universal
Mercedes
Page 63
Tacho Universal
www.efichip.com
Version 1:
Tacho Universal
Mercedes
Page 64
Tacho Universal
www.efichip.com
Version 2:
Tacho Universal
Mercedes
Page 65
Tacho Universal
www.efichip.com
Connect the Tacho Universal with the Mercedes-Diagnostic-plug and with the
Diagnostic-socket.
The Tacho Universal does not show you the old value
Tacho Universal
Mercedes
Page 66
Tacho Universal
www.efichip.com
1. For most Mercedes the service display can be reset this way:
2. Ignition off
3. Ignition on
4. Press 2 x R or 0 on the left side of the instrument
5. Ignition off
6. press R or 0 and hold it
7. Ignition on
8. Still hold the button for about 10-15 seconds. The the service is reset
after a beep signal
Note:
You can also adjust the service display with the Tacho Universal.
Tacho Universal
Mercedes
Page 67
Tacho Universal
www.efichip.com
Important is the display Tage XXX/730 (days). Try to find a numer about 730
(use the arrow up and down keys).
If the car already has to go to service you first have to reset it as described
above. Then look for the value 730/730. With the right and left arrow keys you
can change between 15000 and 20000 km intervals.
When you have found the correct values, press OK and enter the new value.
Note:
You are directly working on the database of the car. If you are not sure you are
doing everything correct, do not program!
Tacho Universal
Mercedes
Page 68
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 69
Tacho Universal
www.efichip.com
Turn out the cluster and disassemble it, until you see the 8 pin Chip
93C86.
Tacho Universal
Mercedes
Page 70
Tacho Universal
www.efichip.com
Turn out the cluster and disassemble it, until you see the 8 pin Chip
93C66.
Tacho Universal
Mercedes
Page 71
Tacho Universal
www.efichip.com
Turn out the cluster and disassemble it, until you see the 8 pin Chip
93C56.
Tacho Universal
Mercedes
Page 72
Tacho Universal
www.efichip.com
Turn out the cluster and disassemble it, until you see the Chip 93C56.
Tacho Universal
Mercedes
Page 73
Tacho Universal
www.efichip.com
Turn out the cluster and disassemble it, until you see the chip 93C56.
Tacho Universal
Mercedes
Page 74
Tacho Universal
www.efichip.com
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 75
Tacho Universal
www.efichip.com
Programming by diagnostic
Mercedes-Diagnostic-plug:
Tacho Universal
Mercedes
Page 76
Tacho Universal
www.efichip.com
Turn out the cluster and disassemble it, until you see the 8 pin Chip
93C86.
Tacho Universal
Mercedes
Page 77
Tacho Universal
www.efichip.com
Connect the cable 912 as shown in the picture with the cluster and the
Tacho Universal .
The Tacho Universal does not show you the old value
Tacho Universal
Mercedes
Page 78
Tacho Universal
Tacho Universal
www.efichip.com
Mercedes
Page 79
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mercedes
Page 80
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mercedes
Page 81
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mercedes
Page 82
Tacho Universal
www.efichip.com
Turn out the cluster and disassemble it, until you see the 8 pin Chip
93C86.
Tacho Universal
Mercedes
Page 83
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mercedes
Page 84
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mercedes
Page 85
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mercedes
Page 86
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mercedes
Page 87
Tacho Universal
www.efichip.com
Open the black ignition-lock-module and look for the the 64-pin
Processor .
Enter the new value. Verify the new value with OK.
Type in the old original value of the car. If the program starts you see in
the try the readen KM and the amount of tries in the display.
If the Tacho
makes a new try - tip with a wet finger for ~ 1 second (not
longer) on the both cables marked with the blue hand. You have to make
3 to 5 tipps per second.
If the Tacho Universal shows you the right value, you have programed the module.
Tacho Universal
Mercedes
Page 88
Tacho Universal
www.efichip.com
Hint:
Kabel: cable
Hochlten: Lift the pin
Tacho Universal
Mercedes
Page 89
Tacho Universal
www.efichip.com
Now put back in first the ignition lock and then the instrument.
Tacho Universal
Mercedes
Page 90
Tacho Universal
www.efichip.com
Tacho Universal
Mercedes
Page 91
Tacho Universal
Tacho Universal
www.efichip.com
Mercedes
Page 92
Tacho Universal
www.efichip.com
Model 323
Model 626
Model 626 Soldering work
Model MX-5
Model MPV
Model Premacy
Model Tribute < Update Juli 03
Model E2200
Model 6
Model 121
Model Xedos 9
Tacho Universal
Mazda
page 1
Tacho Universal
www.efichip.com
Model 323
Use this board and clip:
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mazda
page 2
Tacho Universal
www.efichip.com
Model 323
Use this board and clip:
Tacho Universal
Mazda
page 3
Tacho Universal
www.efichip.com
Model 626
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mazda
page 4
Tacho Universal
www.efichip.com
Model 626
Use this board and clip:
Tacho Universal
Mazda
page 5
Tacho Universal
www.efichip.com
Tacho Universal
Mazda
page 6
Tacho Universal
Tacho Universal
www.efichip.com
Mazda
page 7
Tacho Universal
www.efichip.com
Model MX-5
Use this board and clip:
Look for the 8 pin Chip 93C46 (or Chip AD0970 or S130 (IC2)).
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Adjust KM.
Mazda
page 8
Tacho Universal
www.efichip.com
Model MPV
Use this board and clip:
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Adjust KM.
Mazda
page 9
Tacho Universal
www.efichip.com
Model Premacy
Use this board and clip:
Adjust KM.
Tacho Universal
Mazda
page 10
Tacho Universal
www.efichip.com
Model Tribute
Lift the pins for the blue and the yellow cable at the processor
Tacho Universal
Mazda
page 11
Tacho Universal
www.efichip.com
Mazda
page 12
Tacho Universal
www.efichip.com
Model E2200
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mazda
page 13
Tacho Universal
www.efichip.com
Model 6
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Mazda
page 14
Tacho Universal
www.efichip.com
Model 121
Tacho Universal
Mazda
page 15
Tacho Universal
www.efichip.com
Mazda
page 16
Tacho Universal
www.efichip.com
Model Xedos 9
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
Adjust KM.
Mazda
page 17
Tacho Universal
www.efichip.com
Lincoln
Model Towncar before Year 95
Tacho Universal
Lincoln
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Lincoln
page 2
Tacho Universal
www.efichip.com
Tacho Universal
Lincoln
page 3
Tacho Universal
www.efichip.com
Model LX 470
Model Harrier Jeep
Model LX 470 2003
Model IS 200 2002 with 2 Eps
Tacho Universal
Lexus
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Lexus
page 2
Tacho Universal
www.efichip.com
Tacho Universal
Lexus
page 3
Tacho Universal
www.efichip.com
Tacho Universal
Lexus
page 4
Tacho Universal
www.efichip.com
Model LX 470
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Lexus
page 5
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Lexus
page 6
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Lexus
page 7
Tacho Universal
www.efichip.com
Tacho Universal
Lexus
page 8
Tacho Universal
www.efichip.com
Model Freelander
Model Defender
Tacho Universal
Landrover
page 1
Tacho Universal
www.efichip.com
Model Freelander
Use this board and clip:
Tacho Universal
Landrover
page 2
Tacho Universal
www.efichip.com
Model Defender
Tacho Universal
Landrover
page 3
Tacho Universal
www.efichip.com
Tacho Universal
Landrover
page 4
Tacho Universal
www.efichip.com
Tacho Universal
Landrover
page 5
Tacho Universal
www.efichip.com
Tacho Universal
Landrover
page 6
Tacho Universal
www.efichip.com
Tacho Universal
Landrover
page 7
Tacho Universal
Tacho Universal
www.efichip.com
Lancia
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Grn:green
Lancia
Blau:blue
Rot:red
page 2
Tacho Universal
www.efichip.com
Model Y
Model Y2001
Lancia Zeta
Model Thesis
Model Y2002
Tacho Universal
Lancia
page 3
Tacho Universal
www.efichip.com
Tacho Universal
Lancia
page 4
Tacho Universal
www.efichip.com
Model Lybra
Tacho Universal
Lancia
page 5
Tacho Universal
www.efichip.com
Model Lybra V4
Schwarz:black
Tacho Universal
Grn:green
Lancia
Blau:blue
Rot:red
page 6
Tacho Universal
www.efichip.com
Model Y
Peugeot406/Fiat/Lancia-plug:
Version1
Tacho Universal
Lancia
page 7
Tacho Universal
www.efichip.com
Version 2
Tacho Universal
Lancia
page 8
Tacho Universal
www.efichip.com
Model Y2001
Peugeot 406/Fiat/Lancia-Plug:
Lift the 2 processor-pins(3rd and 5th from corner) and connect them to the 2
points in the picture
Blau:blue Grn:green Masse: Ground
Tacho Universal
Lancia
page 9
Tacho Universal
www.efichip.com
Lancia zeta
Tacho Universal
Lancia
page 10
Tacho Universal
www.efichip.com
Model Y2002
The Tacho Universal does not show you the old value
Tacho Universal
Lancia
page 11
Tacho Universal
www.efichip.com
Tacho Universal
Lancia
page 12
Tacho Universal
www.efichip.com
Model Thesis
Tacho Universal
Lancia
page 13
Tacho Universal
www.efichip.com
Tacho Universal
Lamborghini
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Lamborghini
page 2
Tacho Universal
Tacho Universal
www.efichip.com
Lamborghini
page 3
Tacho
Universal
www.efichip.com
Model Rio
Model Sportage
Model Sorento
Model Carnival
Model Carens
Tacho Universal
Kia
page 1
Tacho Universal
www.efichip.com
Model Rio
Tacho Universal
Kia
page 2
Tacho Universal
www.efichip.com
Model Sportage
Tacho Universal
Kia
page 3
Tacho Universal
www.efichip.com
Model Sorento
Tacho Universal
Kia
page 4
Tacho Universal
www.efichip.com
Model Carnival
Tacho Universal
Kia
page 5
Tacho Universal
www.efichip.com
Model Carens
Tacho Universal
Kia
page 6
Tacho Universal
www.efichip.com
Model S-Type
Model X-Type
Model S-Type 2003
Model XJ 2003
Tacho Universal
Update Juli03
Update Juli03
Jaguar
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Jaguar
page 2
Tacho Universal
www.efichip.com
Ensure to have a strong power supply (more than 3 Amp). Supply the plug with
power (not the Tacho Universal, only the plug!). Give as much power as
necessary to make the voltage display in the instrument show 12,5 V. Remove
all bulbs before programming, only the bulb for the backlight is ok. The
Software programs three different model-years of cars, with STOP you
choose different positions in the dataset. If you find the right one, press OK
and program the new value.
Tacho Universal
Jaguar
page 3
Tacho Universal
www.efichip.com
Gelb
Bla u
Brc ken
Connect the cables as shown in the picture and join the two points.
Tacho Universal
Jaguar
page 4
Tacho Universal
www.efichip.com
Model S-Type
Jaguar
page 5
Tacho Universal
www.efichip.com
Model X-Type
Tacho Universal
Jaguar
page 6
Tacho Universal
www.efichip.com
Kabel=cable Minus=Ground
Tacho Universal
Jaguar
page 7
Tacho Universal
www.efichip.com
Tacho Universal
Jaguar
page 8
Tacho Universal
www.efichip.com
Schwarz=black cable
Tacho Universal
Jaguar
page 9
Tacho Universal
www.efichip.com
Model XJ 2003
Tacho Universal
Jaguar
page 10
Tacho Universal
www.efichip.com
Schwarz=black cable
Tacho Universal
Jaguar
page 11
Tacho Universal
www.efichip.com
Model Trooper
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Isuzu
page 1
Tacho Universal
www.efichip.com
Model Pickup
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Isuzu
page 2
Tacho Universal
www.efichip.com
Model Santa Fe
Model Matrix
Model XG30
Model Getz U
Model Accent U
Tacho Universal
Hyundai
page 1
Tacho Universal
www.efichip.com
Model Santa Fe
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Hyundai
page 2
Tacho Universal
www.efichip.com
Model Matrix
Tacho Universal
Hyundai
page 3
Tacho Universal
www.efichip.com
Model XG30
Tacho Universal
Hyundai
page 4
Tacho Universal
www.efichip.com
Model Getz
Tacho Universal
Hyundai
page 5
Tacho Universal
www.efichip.com
Model Accent
Tacho Universal
Hyundai
page 6
Tacho Universal
www.efichip.com
Model Accord
Model Shuttle
Model HRV
Model Legend
Model S2000
Model Prelude
Model Jazz
Model Civic
Model Logo
Model Stream
Model Accord with Hc 05 Processor
Model CRV 2002
Tacho Universal
Honda
page 1
Tacho Universal
www.efichip.com
Model Accord
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Honda
page 2
Tacho Universal
www.efichip.com
Model Shuttle
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Honda
page 3
Tacho Universal
www.efichip.com
Model HRV
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Honda
page 4
Tacho Universal
www.efichip.com
Model Legend
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Honda
page 5
Tacho Universal
www.efichip.com
Model Jazz
Tacho Universal
Honda
page 6
Tacho Universal
www.efichip.com
Model Civic
Tacho Universal
Honda
page 7
Tacho Universal
Tacho Universal
www.efichip.com
Honda
page 8
Tacho Universal
www.efichip.com
Model Logo
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Honda
page 9
Tacho Universal
www.efichip.com
Model Stream
Tacho Universal
Honda
page 10
Tacho Universal
www.efichip.com
Tacho Universal
Honda
page 11
Tacho Universal
www.efichip.com
the marked processor-pins must be lifted and connected to the other two points
Kabel Gelb=yellow cable Kabel Wei=white cable DATA Blau=blue Grn=green
Tacho Universal
Honda
page 12
Tacho Universal
www.efichip.com
Model S2000
Tacho Universal
Honda
page 13
Tacho Universal
www.efichip.com
Model Prelude
Look for the silver crystal near the chips and join its contacts
Put the clip on the Chip OKI 52615 93C56 (RED on Pin 1).
Tacho Universal
Honda
page 14
Tacho Universal
www.efichip.com
Tacho Universal
Honda
page 15
Tacho Universal
www.efichip.com
Tacho Universal
Honda
page 16
Tacho Universal
www.efichip.com
Tacho Universal
Honda
page 17
Tacho Universal
www.efichip.com
Model Scorpio
Model Focus
Model Fiesta
Model Puma
Model Cougar
Model Galaxy before 6/2000
Model Galaxy after 7/2000
Model Mondeo
Model Fiesta 2002
Model Transit
Model Fusion
Model Focus 03 Update Juli 03
Model Maverick Update Juli 03
Tacho Universal
Ford
page 1
Tacho Universal
www.efichip.com
Model Scorpio
Use the Scorpio Plug:
Rot=red
Tacho Universal
2*Schwarz=2*black
Ford
verbinden=connect
page 2
Tacho Universal
www.efichip.com
Model Focus
Use the Scorpio Plug:
GND(-)
RX (Data)
TX (Data)
12V (+)
12V (+)
Black
Blue
Yellow (always on the golden pin)
Red
Red
Processor version 1:
Connect Pin 1 ( left side down) and pin 2 (right from pin 1), ,
or connect black to test point 3 ( TP3 ).
Verbinden=connect
Tacho Universal
Ford
page 3
Tacho Universal
www.efichip.com
Processor version 2:
Connect pin 1 (middle upside) and pin 2 (left beside pin 1,
or connect black to testpoint 46 ( TP46 ).
Tacho Universal
Ford
page 4
Tacho Universal
www.efichip.com
Model Fiesta
Use the Scorpio Plug:
Version 1:
Schwarz (Masse)=black (ground) Blau=blue Grn=green
Durchschneiden=cut through
Tacho Universal
Ford
page 5
Tacho Universal
www.efichip.com
Version 2:
Only difference for version 2 is the blue and green cable.
For some Scorpio plugs the green cable may also be yellow, the functions are
the same!
Tacho Universal
Ford
page 6
Tacho Universal
www.efichip.com
Model Cougar
Use the Scorpio Plug:
Tacho Universal
Ford
page 7
Tacho Universal
www.efichip.com
Note:
If the display says ERROR repeat everything with a different value!
Tacho Universal
Ford
page 8
Tacho Universal
www.efichip.com
OBD II
Audi A6 old
VW new
Tacho Universal
Ford
page 9
Tacho Universal
www.efichip.com
Model Mondeo
Tacho Universal
Ford
page 10
Tacho Universal
Tacho Universal
www.efichip.com
Ford
page 11
Tacho Universal
www.efichip.com
Model Maverick
Tacho Universal
Ford
page 12
Tacho Universal
www.efichip.com
Tacho Universal
Ford
page 13
Tacho Universal
www.efichip.com
Model Puma
Use the Scorpio Plug:
Version 1:
Schwarz (Masse)=black (ground) Blau=blue Grn=green
Durchschneiden=cut through
Tacho Universal
Ford
page 14
Tacho Universal
www.efichip.com
Version 2:
Only difference for version 2 is the blue and green cable.
For some Scorpio plugs the green cable may also be yellow, the functions are
the same!
Tacho Universal
Ford
page 15
Tacho Universal
www.efichip.com
Tacho Universal
Ford
page 16
Tacho Universal
www.efichip.com
Model Transit
Tacho Universal
Ford
page 17
Tacho Universal
www.efichip.com
Model Fusion
Tacho Universal
Ford
page 18
Tacho Universal
www.efichip.com
Model Focus 03
Tacho Universal
Ford
page 19
Tacho Universal
www.efichip.com
Model Ulysse
Model Scudo
Model Multipla
Model Multipla2001
Model Doblo
Model Seicento
Model Palio
Model Stilo
Model Doblo Nec
Model Ducato Dely Nec 2002 < Update Juli 03
Tacho Universal
Fiat
page 1
Tacho Universal
www.efichip.com
Tacho Universal
Fiat
page 2
Tacho Universal
www.efichip.com
The Tacho Universal does not show you the old value.
Tacho Universal
Fiat
page 3
Tacho Universal
www.efichip.com
Fiat
page 4
Tacho Universal
www.efichip.com
Hochlten=lift pin
Verbinden=connect
Tacho Universal
Fiat
page 5
Tacho Universal
www.efichip.com
Verbinden=connect
Note:
If the Tacho Universal displays you the double of the original value, you have to
program the double of the desired value!
Tacho Universal
Fiat
page 6
Tacho Universal
www.efichip.com
Scorpio-plug
The Tacho Universal does not show you the old value (??????).
Tacho Universal
Fiat
page 7
Tacho Universal
www.efichip.com
Grn=green
Blau=blue
Schwarz=black
Rot=red
Tacho Universal
Fiat
page 8
Tacho Universal
www.efichip.com
The Tacho Universal does not show you the old value.
Tacho Universal
Fiat
page 9
Tacho Universal
www.efichip.com
Tacho Universal
Fiat
page 10
Tacho Universal
www.efichip.com
The Tacho Universal does not show you the old value.
Tacho Universal
Fiat
page 11
Tacho Universal
www.efichip.com
Tacho Universal
Fiat
page 12
Tacho Universal
www.efichip.com
Tacho Universal
Fiat
page 13
Tacho Universal
www.efichip.com
908 Plug:
Note:
There are several shapes of the circuit board. Important for programming are
only the 3 points on the left side of the board!
Tacho Universal
Fiat
page 14
Tacho Universal
www.efichip.com
Model Ulysse
Tacho Universal
Fiat
page 15
Tacho Universal
www.efichip.com
Model Multipla
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Fiat
page 16
Tacho Universal
www.efichip.com
Model Multipla2001
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Fiat
page 17
Tacho Universal
www.efichip.com
Model Doblo`
Tacho Universal
Fiat
page 18
Tacho Universal
www.efichip.com
Model Seicento
Note: Use the new board
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Fiat
page 19
Tacho Universal
www.efichip.com
Model Scudo
908 Plug:
Important: Lift the pins at the processor, which be connected with the cable
Tacho Universal
Fiat
page 20
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Fiat
page 21
Tacho Universal
Tacho Universal
www.efichip.com
Fiat
page 22
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Fiat
page 23
Tacho Universal
www.efichip.com
912 Plug
Tacho Universal
Fiat
page 24
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Fiat
page 25
Tacho Universal
www.efichip.com
Doblo NEC
Tacho Universal
Fiat
Eeprom 95020
page 26
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Fiat
page 27
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts .
Tacho Universal
Fiat
page 28
Tacho Universal
www.efichip.com
Modena
Tacho Universal
Ferrari
page 4
Tacho
Universal
Tacho Universal
www.efichip.com
Ferrari
page 4
Tacho Universal
www.efichip.com
Tacho Universal
Ferrari
page 4
Tacho Universal
www.efichip.com
Tacho Universal
Ferrari
page 4
Tacho Universal
www.efichip.com
Model YRV
Look for the silver chrystal near the chip and join its contacts .
Connect the clip to Port 0.
Tacho Universal
DAIHATSU
Page2
Tacho Universal
www.efichip.com
Model Terios
Tacho Universal
DAIHATSU
Page2
Tacho Universal
www.efichip.com
Tacho Universal
DAIHATSU
Page2
Tacho Universal
www.efichip.com
Update Juli 03
Update Juli 03
Update Juli 03
VW
page 1
Tacho Universal
www.efichip.com
Connect the power plug with the instrument and press the 4 pin
programming plug into the fitting hole:
The Tacho Universal does not show you the old value.
Tacho Universal
VW
page 2
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 3
Tacho Universal
www.efichip.com
Connect the power plug with the instrument and press the 4 pin
programming plug into the fitting hole:
The Tacho Universal does not show you the old value.
Tacho Universal
VW
page 4
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 5
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 6
Tacho Universal
www.efichip.com
Turn ignition on
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
Note:
You can distinguish between VDO and MotoMeter with the program Service:
VDO is called VDO
MotoMeter is called MM or BOO
Tacho Universal
VW
page 7
Tacho Universal
wwww.efichip.com
The Tacho Universal shows you the right value in one of the two versions.
Tacho Universal
VW
page 8
Tacho Universal
www.efichip.com
Turn ignition on
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
Note:
You can distinguish between VDO and MotoMeter with the program Service:
VDO is called VDO
MotoMeter is called MM or BOO
Tacho Universal
VW
page 9
Tacho Universal
www.efichip.com
OBD II
VW new
Connect those plugs together. If the VW new does not fit to the A6 old, you
have to remove one of the pins in the A6 old plug. You can see which one it is,
otherwise the plugs will not fit together. The A6 plug will still keep all
functions!
Turn ignition on
Connect the Tacho Universal with the plug and the diagnostic port.
Note:
You can distinguish between VDO and MotoMeter with the program Service:
VDO is called VDO
MotoMeter is called MM or BOO
Tacho Universal
VW
page 10
Tacho Universal
www.efichip.com
If the program has found the access code the new value will be
programmed.
Note:
You can distinguish between VDO and MotoMeter with the program Service:
VDO is called VDO
MotoMeter is called MM or BOO
Tacho Universal
VW
page 11
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 12
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 13
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 14
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 15
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 16
Tacho Universal
www.efichip.com
Connect the power plug with the instrument and press the 4 pin
programming plug into the fitting hole
The Tacho Universal does not show you the old value.
Tacho Universal
VW
page 17
Tacho Universal
www.efichip.com
Connect the power plug with the instrument and press the 4 pin
programming plug into the fitting hole:
The Tacho Universal does not show you the old value.
Tacho Universal
VW
page 18
Tacho Universal
www.efichip.com
Turn ignition on
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
For some versions you have to enter the old and the new value before
you can program.
Note:
Passat modell 2000 also can have
Volkswagen-Golf4-DiagnoseMM .
Tacho Universal
VW
page 19
Tacho Universal
www.efichip.com
The Tacho Universal shows you the right value in one of the two versions.
Tacho Universal
VW
page 20
Tacho Universal
www.efichip.com
Look for the silver crystal near the chip and join its contacts.
Tacho Universal
VW
page 21
Tacho Universal
www.efichip.com
Connect the power plug with the instrument and press the 4 pin
programming plug into the fitting hole:
The Tacho Universal does not show you the old value.
Tacho Universal
VW
page 22
Tacho Universal
www.efichip.com
Diagnostic programming
Turn ignition on
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
Tacho Universal
VW
page 23
Tacho Universal
www.efichip.com
Model T4 2002
Diagnostic programming
Turn ignition on
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
Tacho Universal
VW
page 24
Tacho Universal
www.efichip.com
Turn ignition on
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
Note:
If the display says ERROR repeat everything with a different value!
Tacho Universal
VW
page 25
Tacho Universal
www.efichip.com
OBD II
Audi A6 old
VW new
Connect those plugs together. If the VW new does not fit to the A6 old, you
have to remove one of the pins in the A6 old plug. You can see which one it is,
otherwise the plugs will not fit together. The A6 plug will still keep all
functions!
The diagnostic port near your left knee when you sit on the drivers seat.
Turn ignition on
Connect the Tacho Universal with the plug and the diagnostic port.
Tacho Universal
VW
page 26
Tacho Universal
www.efichip.com
The diagnostic port near your left knee when you sit on the drivers seat.
Turn ignition on
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
For some versions you have to enter the old and the new value before
you can program.
Tacho Universal
VW
page 27
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 28
Tacho Universal
www.efichip.com
Model Lupo
Diagnostic programming:
Turn ignition on
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
Tacho Universal
VW
page 29
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 30
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 31
Tacho Universal
www.efichip.com
Connect the power plug with the instrument and press the 4 pin
programming plug into the fitting hole:
The Tacho Universal does not show you the old value.
Tacho Universal
VW
page 32
Tacho Universal
www.efichip.com
The diagnostic port is in the fuse box in the drivers floor space.
Turn ignition on
Connect the Tacho Universal with the OBD II plug and the diagnostic port.
Tacho Universal
VW
page 33
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 34
Tacho Universal
www.efichip.com
Model LT VDO
The Tacho Universal does not show you the old value.
Tacho Universal
VW
page 35
Tacho Universal
www.efichip.com
LT Kienzle
Sprinter Kienzle-Plug
Now you see on the right side a small blck cover that is protected with a
red plastic button. You have to break and remove this red button to get
access to the programming contacts.
Connect the Kienzle-Plug with the programming contacts (red mark up)
and the Tacho Universal.
Turn ignition on
Tacho Universal
VW
page 36
Tacho Universal
www.efichip.com
Service-Display
Select the menue : Volkswagen-Service
model
channel
Polo / Lupo
Original-value meaning
10
11
12
------------------Polo SW 17 / Golf 10
4
11
12
------------------Sharan
5
8
------------------VAG Model 2000 2
150
300
36
---------15
30
36
---------15
30
---------0
40
Audi TT
41
Note:
Keep doors closed when programming the service display!
Writing of a 0 in channel 2 resets the values of the cluster.
Note:
Before reading the channels, you will see some information about the instrument:
MM0 or B00
VDO
UN4
MM4 or M73
TRW
Tacho Universal
:
:
:
:
:
Motometer
VDO
UKNSI
Magneti Marelli
TRW
VW
page 37
Tacho Universal
www.efichip.com
Example: VW Golf4
The Tacho reads out the SERVICE. Now you can check the important
channels for this car (Golf 4 - channels 10, 11 & 12).
Channel 10: Actual Oilservice-value
Channel 11: Actual 30000 Service-value
Channel 12: Actual Year/Day-Service-value
You have to program the channels 10 and 11, the value of the oilservice will be
1-down-counted every 1000km, the Service-value also.
Example:
original KM-value :
New KM-value :
13250km
11250km
Tacho Universal
VW
page 38
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 39
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 40
Tacho Universal
Tacho Universal
www.efichip.com
VW
page 41
Tacho Universal
www.efichip.com
Tacho Universal
VW Gol 908
VW
page 42
Tacho Universal
Tacho Universal
www.efichip.com
VW
page 43
Tacho Universal
www.efichip.com
Tacho Universal
VW
page 44
Tacho Universal
www.efichip.com
Model Touareg
Tacho Universal
VW
page 45
Tacho Universal
www.efichip.com
Model Touran
Tacho Universal
VW
page 46
Tacho Universal
www.efichip.com
Model Phaeton
Tacho Universal
VW
page 47
Tacho Universal
www.efichip.com
Model Passat w8
Tacho Universal
VW
page 48