Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1. Experiment No.:
EC (EE) 391/04
Title:
Analog & Digital
Electronic Circuit Lab
Prepared by:
SIC(s)
S.Mukherjee
Approved
by: HOD
Dr. A. Sil
Doc No.
Issue
No.
Revision
No.
Effective
Date
WI/EC(EE)391/04
01
00
17.07.12.
Page
1 of 4
WORK INSTRUCTION
Item
Qty.
Makers Name
Range
Title:
Analog & Digital
Electronic Circuit Lab
Class C:
Prepared by:
SIC(s)
S.Mukherjee
Approved
by: HOD
Dr. A. Sil
Doc No.
Issue
No.
Revision
No.
Effective
Date
WI/EC(EE)391/04
01
00
17.07.12.
Page
2 of 4
WORK INSTRUCTION
Push-Pull Amplifier:
6.2. Results
(CLASS A)
Sl No
Frequency
(Hz)
Output Voltage
(Volts)
Gain = Vo/Vi
Gain(Db) =
20log(Vo/Vi)
Efficiency
Frequency
(hz)
Output voltage
(volts)
Gain = vo/vi
Gain(db) =
20log(vo/vi)
Efficiency
()
7. Safety Precautions:
i. Do not wear loose garments inside the laboratory.
ii. Do not enter in the laboratory with the bare foots.
iii. Do not switch ON the circuits without permission of the concerned teacher.
iv. Do not touch the circuit haphazardly.
v. Make sure that the circuit is switched OFF before leaving the laboratory.
8. Instructions for Writing the Report:
9 Attach the rough sheet with the final report.
9 The 1st Page of the report shall be as per the format shown in Annexure 1.
9 Write the final report as per the work instruction.
Title:
Analog & Digital
Electronic Circuit Lab
Prepared by:
SIC(s)
S.Mukherjee
Approved
by: HOD
Dr. A. Sil
Doc No.
Issue
No.
Revision
No.
Effective
Date
WI/EC(EE)391/04
01
00
17.07.12.
Page
3 of 4
WORK INSTRUCTION
ANNEXURE 1
NAME: ___________________________________________________________
ROLL NO.:_____________
DEPARTMENT: _____________________
CO-WORKERS
NAME
ROLL NO.
1._______________________________
_________________
2._______________________________
_________________
3._______________________________
_________________
4._______________________________
_________________
TITLE:________________________________________________________________________
________________________________________________________________________
OBJECTIVE:
________________
Marks Obtained
Title:
Analog & Digital
Electronic Circuit Lab
Prepared by:
SIC(s)
S.Mukherjee
_________________
Signature of the
Sessional in - charge
Approved
by: HOD
Dr. A. Sil
Doc No.
Issue
No.
Revision
No.
Effective
Date
WI/EC(EE)391/04
01
00
17.07.12.
Page
4 of 4