Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
METHOD STATEMENT
1.0 OBJECTIVE
The purpose of this method statement is to describe the activities and methods, which
will be used to carry out FLEXIBLE PAVEMENT (Rehabilitation and Resurfacing).
2.1.3 Compaction shall be carried out using the specified equivalent type
of rollers and compacted in accordance with the specification.
2.1.4 Rolling shall be commenced from the lower to the higher side. The
final rolling temperature shall not less than 110o C.
Ref. No. :
Revision No. : Revision Date :
Page 2 of 6
METHOD STATEMENT
2.2.4 The surface to receive the premix shall be cleaned, free from dirt,
loose materials and standing water.
2.2.5 Supply and apply bituminous Tack Coat prior to the laying of
ACBC. The spray rate of the Tack Coat shall be between 0.15 to
0.30 liters/sq.m.
2.2.8 Supply and apply bituminous tack coat prior to the laying of ACWC.
2.3.1 Description
This Work shall include the breaking, mixing compacting and shaping the
cement stabilized base course in accordance with this specification and
the lines, levels, grades, dimensions and cross-sections shown on the
drawings and/or as required by the Engineer.
Ref. No. :
Revision No. : Revision Date :
Page 3 of 6
METHOD STATEMENT
2.3.5 Pre-Treatment
If the base is wet and above the Optimum moisture content, the base
material need to be pre-treated. The process of pre-treatment using the
stabilizer machine or any other mechanical mean approved by the
Engineer is by pulverized the base material to dry-out the material until
below the Optimum moisture Content before the process of spreading the
cement for stabilization.
Ref. No. :
Revision No. : Revision Date :
Page 4 of 6
METHOD STATEMENT
The quantity of the cement required for recycle stabilization area shall be
computed using the following formula:-
C = Ar x Tr x δc x Rc
100
Where C
Vibrating roller with 20 t static mass ideal is use with rolling pattern of 2
passes static and 6 passes vibration. Moisture content is the most critical
variable in achieving densification with minimum effort. Due to the time
delay between recycling and finishing off, a light application of water
should always be applied to the surface before final rolling.
Ref. No. :
Revision No. : Revision Date :
Page 5 of 6
METHOD STATEMENT
Ref. No. :
Revision No. : Revision Date :
Page 6 of 6
METHOD STATEMENT
Ref. No. :
Revision No. : Revision Date :