Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
uk
http://www.fordwiki.co.uk/index.php?title=Instrument_Cluster_Self-Diagnostic_Mode
The Ford Mondeo hit our roads in 1993, and has consistently been a sales success. Now on its 4th incarnation, it remains a drivers favourite.
For more information, visit the Ford Mondeo (http://www.talkford.com/forum/596-mondeo/) forum on TalkFord.com (http://www.talkford.com), the definitive
resource site covering all Fords from the present day to the 1970's.
Contents
thumbnail to destination
Overview Guide
1 Applicability
2 Entering Self-Diagnostic Mode
3 Available information
4 Cluster DTCs
Ford Model:
Mondeo/Focus
Estimated Cost:
zero
Difficulty?
Easy
5 minutes
Applicability
This is for the MK3 Mondeo but will also work on the Focus (Mk1 and Mk2) and most other Ford vehicles with a digital trip meter.
1 din 3
12.05.2015 08:50
http://www.fordwiki.co.uk/index.php?title=Instrument_Cluster_Self-Diagnostic_Mode
To enter the instrument cluster Self-Diagnostic Mode simultaneously press and hold the tripmeter reset button and turn the ignition switch to position II.
When tESt is displayed in the LCD release the button.
The instrument cluster will enter the gauge sweep test.
To navigate through the Self-Diagnostic Mode tests press the tripmeter RESET button repeatedly as required.
The self-test is deactivated when the ignition switch is turned to the OFF position or when the tripmeter reset button is pressed and held for 5 seconds.
Available information
Your car may differ from these slightly in content and sequence:
Gauge test
All LCD are illuminated
Indicator bulbs
ROM level (r----)
NVM (EEPROM) level (Er----) - this (e.g. Er0206) is often mistakenly assumed to be an error code!
DTC revision level (dtC985)
DTC. The DTCs stored will be displayed. The DTC codes will scroll through if there is more than one, or "nOnE" if there are none. See below for interpretation.
Road speed mph (SP----)
Road speed km/h (SP----)
Averaged speed, some sort of hex reading (S60---), probably not useful to the end user.
Engine speed rpm (TA----)
Averaged tacho signal, some sort of hex reading (T60---), probably not useful to the end user.
Odometer counter (od ---)
Fuel level sensor (F ---, 010 (empty) - 254 (full))
Averaged fuel level (F60---, range as above)
Fuel flow rate (FL --, hex counter)
Fuel percentage/remaining? Hex? (FP --)
Cylinder head temperature (---C)
Battery voltage (bAt---)
There are many other pieces of information not of interest to the end user, but you'll eventually get back round to the gauge sweep.
Cluster DTCs
To read the complete list of codes, you'll need a dedicated fault code reader plugged into the diagnostic port. Some codes are available via the cluster, listed under the DTC entry
2 din 3
12.05.2015 08:50
http://www.fordwiki.co.uk/index.php?title=Instrument_Cluster_Self-Diagnostic_Mode
3 din 3
12.05.2015 08:50