Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Copyright notice : This material can be freely used within the EOLES TEMPUS PROJECT consortium. Explicit authorisation of
the authors is required for its use outside this consortium EOLES TEMPUS PROJECT. This project has been funded with
support from the European Commission. This publication reflects the views only of the author, and the Commission cannot be
held responsible for any use which may be made of the information contained therein.
L3-EOLES TU07
3) Manipulations
a) Configuration of the waveform generator
The generator has to be configured under the following configuration:
waveform : sinusoide
frequency : 10 kHz
magnitude : 10 V peak-peak
internal impedance : 50
b) Role of the resistance r=10
Explain how is it possible to know the current iR(t) through the load with the resistance r.
c) Case #1 : Load R
Manipulation : Connect the load R at the output of the diode (green switch on open, red
switch on short).
Measure <VR>, VRMS, the form factor F and the ripple rate .
Is it possible to measure the threshold voltage of the diode (voltage between the anode and the
cathode of a diode when the diode is "ON")? Justify and give your results.
d) Case #2 : Load R in parallel with a capacitance C
Copyright notice : This material can be freely used within the EOLES TEMPUS PROJECT consortium. Explicit authorisation of
the authors is required for its use outside this consortium EOLES TEMPUS PROJECT. This project has been funded with
support from the European Commission. This publication reflects the views only of the author, and the Commission cannot be
held responsible for any use which may be made of the information contained therein.
L3-EOLES TU07
Manipulation : Connect successively capacitances C1 and C2 in parallel with the load R.
After observing the rectified voltage VR obtained for each capacitance, what is the optimal
capacitance between C1 and C2? Justify. Then, measure <VR>, VRMS, the form factor F and the
ripple rate for the optimal capacitance. Compare with the results obtained with the load R.
For this optimal capacitance, what is the ratio between the time when the diode is ON in
comparison to the period T of the signal.
Indicate if the current through the load iR(t) and the rectified voltage VR(t) are in phase.
e) Case #3 : Load R in serie with an inductance L
Manipulation : Connect successively inductances L1 and L2 in serie with the load R.
Indicate if the current through the load iR(t) and the rectified voltage VR(t) are in phase.
Justify. What is the problem concerning the rectified voltage VR(t)?
f) Case #4 : Load R in serie with an inductance, the RL load being in parallel with a diode
Manipulation : Connect successively inductances L1 and L2 in serie with the load R. Connect
also the flyback diode Df in parallel to the RL load.
What is the role of this diode Df? Is it playing correctly its role? Justify.
Copyright notice : This material can be freely used within the EOLES TEMPUS PROJECT consortium. Explicit authorisation of
the authors is required for its use outside this consortium EOLES TEMPUS PROJECT. This project has been funded with
support from the European Commission. This publication reflects the views only of the author, and the Commission cannot be
held responsible for any use which may be made of the information contained therein.