Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
10)
#18 FVC
1) Occlusal reduction: 1.5 mm
2) Preparation centered on long axis of tooth (cusp tips and central groove position
maintained)
3) Retention and Resistance: 6-10 degrees taper with 4 mm buccal wall height
4) Axial reduction tooth morphology maintained
5) Functional bevel placement correct angulation and reduction
6) Non-functional bevel placement correct angulation and reduction
7) Chamfer finish line 0.5 mm supragingival
8) Chamfer finish line-axial depth half the depth of the chamfer bur
#3 FVC
1) Occlusal reduction: 1.5 mm
2) Preparation centered on long axis of tooth
3) Retention and Resistance: 6-10 degrees taper with 4 mm buccal wall height
4) Axial reduction tooth morphology maintained
5) Functional bevel placement correct angulation and reduction
6) Non-functional bevel placement correct angulation and reduction
7) Chamfer finish line 0.5 mm supragingifal
8) Chamfer finish line-axial depth half the depth of the chamfer bur
#3 Crown
1) Occlusal Reduction: 1.5 mm (L) to 1.5 to 0.5 mm (B)
2) Preparation centered on long axis of tooth
3) Retention and Resistance: 6-10 degrees taper with adequate wall height
4) Retention-Resistance Boxes (Axial Depth) Proper location and depth (0.8-1.2mm)
5) Functional Bevel Placement correct angulation and reduction
6) Non-functional Bevel Placement (Buccal cusps shoe): correct angulation and
reduction (0.2-0.3 mm)
7) Buccal Angles of Exit (from box forms): 135 degrees with 0.75 mm clearance
8) Isthmus depth and width: 2.0-2.5 (D) and 1.5 mm (W)