Sei sulla pagina 1di 6

WIRING DIAGRAM

Programing Jumpers

LYNX

CAR ALARM SYSTEM

Shock Sensor
LYNX

GreenUnlock Out (-)


Blue-lock Out(-)
LED
Valet Switch

White-Parking Light Output (+)


Red- 12V+ Battery (+)
Yellow-Ignition Input
Black Battery (-)

Orange-Starter Interrupt Output (-)


Blue-Hood Trunk Trigger (-)
Black /White-Interior Light Output (-)
Brown/White 3rd Channel Output (-)
Gray-Trunk Release Output (-)
Brown Siren Output (+)
Green Door Trigger Input (-)
Purple- Door Trigger Input (+)
White Input (-) ACJ. By Doors

PANTHER ELECTRONICS INC.


www.panthersecurity.com
8/05

* Two 4 Button Transmitters


* 2nd Channel for Trunk release
* Door Entry Protection
* Personal/Panic Feature
* Shock Sensor
* Dome Light Supervision
* Five Function LED Plug-In
* Silent Arm/Disarm
* Horn Output (-)
* Two Step Disarm

* Anti Carjack 3 Way


* 6 Tone Siren
* Last Door Automatic Arming
* Flashing Parking Lights
* Starter Disable Output
* Valet Override Switch Plug-In
* Audible/Visual Intrusion Alert
* Door Lock & Unlock with Ignition
* Remote Door Lock/Unlock Plug-In
* Double Pulse for Unlock

SYSTEM CONTENTS
12111-

Brain Module
4 Button Remote Transmitter
Mini 6 Tone Siren
Impact Sensor Dual Zone
9 pin wiring harness

11111-

4 pin Wire Harness W/2 Fuse Holders


2 pin door lock harness
4 pin wiring harness For Sensor
Red Status L.E.D.
Push Button Switch

engine will be disabled (permanent negative signal)


Immediately: The Anti car-jack will shutdown the engine immediately after 45 second from beginning

Back to Normal Operation: Turn on the IGNITION, within 5 seconds, press Valet Switch 5

times, you will hear one long siren chirp. Press Button 1 and Button 2 together, Siren will

1 second ON (-) signal and 1 second OFF for 60 seconds, after 60 seconds from beginning the

(in the second 45 the system will send permanent negative signal)

REMOTE OPERATION

10. Engine Disabled in Anti car-jack. Slowing: The anti car-jack will shutdown the engine slowly:

chirp 6 times and parking light will flash 6 times and will go back to Normal Operation. Then,
turn off the IGNITION, system will go back to normal.

Button

Functions

Press button #1 once

Arm & lock doors.

CODING TRANSMITTERS

Press button 1 then 3 within 2 sec.

Arm bypassing shock sensor

Press button 1 then 2 within 2 sec.

Arm bypassing shock and door trigger input

To code new transmitters or to add additional transmitters


follow the steps below.

Press button 2 once

Disarm & unlock doors

Press and hold button 4 for 2 sec.

Trunk release.

Press button 1 for 3 sec

a. Car finder

a. Armed

Press and hold button 3 for 3 sec.

b. Remote panic

b. Ign. Off

Press and hold button 3 for 3 sec.

C. Enter anti car-jacking.

c. Ign. On

Press button 3 then 2 within 2 sec.

Silent disarming.

Press Button 3 & 4 for 3 seconds.

3rd Channel Brown/White wire.


1

1. Turn on the ignition key On, Off, On, Off, and back On.
The siren will chirp 3 times.
2. Press and hold the Override switch for 5 seconds.
The siren will chirp 5 times.
3. Press Button 1 on the first transmitter.
The siren will chirp once.
4. Repeat steps 3 for each transmitter.

10

2
4

1
3

SYSTEM PROGRAM OVERVIEW


1. Passive Door Locking: When selecting Passive Arming, you could choose the Door Lock
Output will be activated or not.

SYSTEM OPERATION CONDITION


INDICATION-LED CONDITIONS:
Arm: LED flash slowly as 1 time per sec.

2. Ignition Controlled Locks: Selects whether or not the system will unlock the doors with
the ignition.

Disarm: LED OFF.


Rearming mode: LED fast flash.

3. Door Input Monitoring: Selects whether the system begins monitoring the door inputs
after 30 seconds or 60 seconds or without delay time. For vehicles with interior lights that remain
on for extended period after the doors are closed, set for 30 or 60 seconds.
4.Door Unlock Pulse: Selects between one pulse or two pulse operation for the door unlock
output. Some Vehicles that require two pulse onlock for doors can be programed the system for
double unlock pulse.

Passive arming: LED fast flash.


Valet mode: LED continuously ON.
Anti car-jack mode: LED fast flash.
SIREN SOUND & PARKING LIGHTS FLASH:
Trigger by doors, hood or trunk.90 seconds
Trigger by Ignition180 seconds

5. Arming Chirps. Selects between normal and silent operation.


6. Extended Parking Lights: When selected this, the parking lights will remain on for 30 seconds
after disarming the system.

Trigger by Sensor.45 seconds


If the door, hood or trunk is opened and closed the system will be trigger only 90 seconds and
will be rearm automatically to protect all Vehicle, but if door is not left open the system will be trigger

7. Disarm with Auxiliary 1: When selected, activating the Auxiliary 1 output (usually used
to open the trunk) will disarm the alarm.

5 cycles of 90 seconds and after this period will be rearm automatically and bypass the defective zone.
If the Ignition is turned ON and OFF the system will be triggered for only 180 seconds but if Ignition is

8. Anti car-jack by remote. Enables Anti car-jack by remote transmitter.


9. 3rd Channel Output: Output pulse only for the time that B3 & B4 are pressing
For Horn: The horn will sound when the alarm is triggered by SENSOR, IGNITION, DOOR, PANIC.

not turned OFF the system will be trigger 5 cycles of 90 seconds and after this period will be rearm
automatically but the engine will remain disabled and if the system is turned OFF and ON again the
system will trigger again.

Also when ARM, DISARM, CAR FINDER and Anti-Hijack Mode been activate.

ANTI-CARJACK OPERATION CONT.

SYSTEM OPERATION
ARMING:
Press button 1. Siren will chirp and parking lights will flash once, Doors locked, LED will flash,

Orange wire sends negative signal on and off every 1 second for second 60, After 60 seconds the LED will be

Disables engine starter (if starter disable relay connected). If any door is open, LED will blink quickly,

fast flash, parking lights keep flashing and siren keeps sounding and the engine will be disabled (negative

and the siren will chirp once and also 3 long chirps for notification, the parking lights also

signal from orange wire), After turn Ignition OFF, the siren stops sound and the parking lights stop flashing,

will flash 4 times. Then, the door trigger is bypassed. 3 second later, alarm is armed. If shock

the engine disabled and the LED keeps flash quickly.

sensor or external sensor is triggered within 3 seconds, the circuit will be bypassed. System will

EXIT ANTI Car-jacking MODE: Any time after the Anti car-jack was activated or triggered with

rearm normally by itself only when sensor is stable for over 3 seconds.

Ignition ON press VALET switch once and the Anti car-jack will be canceled or disarmed and the transmitters

DISARMING:

could work again.

(This system has two step disarm mode.


Press button 2. Siren will chirp 2 times and Parking Light will also flash 2 times. If siren chirp

Notes:

and parking lights flash 4 times, which means the alarm has been activated, Doors will be
unlocked Enable engine ( if starter disable relay connected).
SILENT ARMING/DISARMING:
a. Press button 3 once and then press button 1 once within 2 sec. To silent arming.
b. Press button 3 once and then press button 2 once within 2 sec. To silent disarming.
EMERGENCY DISARMING-OVERRIDE:
If remote control is failed or lost in armed mode, perform the following steps:
Turn Ignition ON, Press valet switch 6 times siren will chirp 2 times and the parking lights will
flash 2 times, which indicates that the system is valet/disarmed. Or exits the anti car-jacking mode.
NOTE: The only way to disarm the Anti car-jack will be with the procedure to disarm the Anti car-jack
features. You will find the step to cancel the Anti car-jack functions.
PANIC:
When Ignition OFF. Press and hold button 3 for 3 seconds, the siren will sound, and parking
lights will flash for 30 seconds. Press button 1 or 2 to stop the panic.
3

ANTI-CARJACK OPERATION

SYSTEM OPERATION CONT.

This system have 3 different ways to activate the Anti car-jack function:

CAR FINDER:

1. Anti car-jack by remote transmitter.

When the alarm system is armed, press button 1 for 3 sec., the siren will chirp 6 times and the

2. Anti car-jack by driver door.

parking lights will flash 6 times. Press button 1 or 2 to stop car finder.

3. Anti car-jack by Ignition ON.

SHOCK SENSOR:

1. Anti car-jack by remote transmitter:

Sensitivity is adjustable.

With Ignition ON press button 1 and button 2 at same time for 3 seconds, the parking lights will flash

If receives a light impact, Siren will chirp (warn-away). If receiving a heavy impact, the siren will

twice to and LED will flash quickly indicating that Anti car-jack was triggered. This Anti car-jack by

sound full cycle and parking lights will flash.

remote could be programmed. To enable or disabled this function.

AUTOMATIC REARMING: (PERMANENT FEATURE / NOT PROGRAMMABLE)

2. Anti car-jack by Door:

When alarm is disarmed, and doors are not opened, 30 sec later, the system will be automatically

With Ignition ON if the driver door is open and closed the parking lights will flash twice and LED will

rearmed and locks all doors.

flash quickly indicating that Anti car-jack was triggered. This Anti car-jack by doors could work only if

PASSIVE ARMING:

the installer connect the white wire (negative input for Anti car-jack by doors).

Every time Ignition is turned OFF and after last door is closed, the system will be automatically

3. Anti car-jack with Ignition:

armed in 30 seconds, after the last door is closed and when system starts the countdown parking

Every time ignition is turn ON the Anti car-jack will be trigger, the parking lights will flash twice and LED

lights will flash once to alert that system will arm in 30 seconds.

will flash quickly indicating that Anti car-jack was triggered.


This Anti car-jack by Ignition could be programmed by jumper to be enable or disable and from factory
comes disabled.

ANTI Car-jacking APPEARANCE


When the system enters anti Car-jacking mode the transmitters will be blocked.
The Anti car-jack could be activated or triggered by transmitter, Door or Ignition ON and if the Anti car-jack is
activated the appearance is the following: LED flash quickly for 30 Seconds, Parking light will flash and
siren will sound long and continues sounding for 60 seconds, Engine will be disable in the following way.

SYSTEM PROGRAMING

SYSTEM PROGRAMING CONT.

SYSTEM PROGRAMMING:

Factory Default
Button #1

To enter system Programming:


1. Turn ON Ignition.
2. Enter in VALET Mode.
3. After VALET MODE press the valet switch 5 times.
The siren will provide one long chirp, indicating that you have entered Programming mode.

. .. ... ....

. ..

4. Press the valet switch the number times of chart you want to change. The siren will chirp
each time the valet switch is pressed. (1--5

) (5 /6

/7

5. Within 5 seconds, press the transmitter button corresponding to the desired operating mode for
that System Parameter. The siren chirps to indicate the setting.
1 chirp = Button 1

2 chirps = Button 2

3 chirps = Button 3

1
2
3
4
5
6
7
8
9
10

Button #2

Passive Door Locking (Enabled)


Ignition Controlled Locks (ON)
Door Input Monitoring (NO Delay)
Door Unlock Pulse (Single)
Arming Chirps (Normal)
Extended Parking Lights (Two Flash)
Disarm with Aux.1 (Enabled)
Anti car-jack by remote (Enabled)
HORN (W/ J4 OFF)
Engine Disable in Anti car-jack (Pullsing)

Disabled
Off
30 Seconds

Button #3
Lock Only
60 Seconds

Double
Silent
Stay ON 30 sec.
Disable
Disabled
3rd. Channel (B3 and B4)

ON in 45 seconds

When you are finished, turn OFF the ignition to save the changes.

JUMPER SELECTION:
There are 4 jumper selections (J1~J4). See the table as below.

DEFAULT RESTORE:

Important: All jumper selections have to be determined before installation. Otherwise, you have to power

Following the above procedure to inter Programming mode to factory default settings.

OFF the module again for reset.

1. Enter System Programming.

JUMPER MODE (CLOSE) DEFAUL

JUMPER MODE (OPEN)

2. Press Transmitter Button #4 and hold for 6 seconds. The siren will chirp 6 times indicating that
All system set to factory default settings.
3. Turn OFF ignition.

PASSIVE ARMING (ON)

J1

LOCK TIMER (0.5sec.)

J2

IGN. ANTI CAR-JACK (OFF)

J3

3rd. CHANNEL OUTPUT (ON) J4

X XX
X XX
XX X
XXX
6

PASSIVE ARMING (OFF)

J1

LOCK TIMER (3.5 SEC.)

J2

IGN. ANTI CAR-JACK(ON)

J3

HORN OUTPUT (ON)

J4

X XX
X XX
XX X
XXX

Potrebbero piacerti anche