Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
EM-3330-3B
EM-3320-1A
EM-3320-1N
EM-3310-4E
EM-3310-1B
EM-3310-2A
EM-3310-3H
EM-3390-2A
EM-3390-2B
EM-3390-2C
EM-3390-3A
EM-3390-4A
CIRCUIT DIAGRAMS:
Fig-1. Circuit diagram for wound-rotor induction motor with added rotor resistance
Fig-2. Connection diagram for wound-rotor induction motor with added rotor resistance
PROCEDURE: (Part-1: added rotor resistance)
CAUTION: Do not make or modify any connections with the power on unless otherwise is
specified. If any danger occurs, immediately press the EMERGENCY OFF button on the
three-phase power supply module. Terminate this exercise and consult your laboratory
assistant.
Set up the equipment as shown in Fig-1 and Fig-2.
1. Mechanically couple the wound-rotor induction machine to magnetic powder brake
unit using a coupling. Install the coupling guard and shaft end guard. Electrically
connect the brake controller to the magnetic powder brake using the RS232 cable.
Before using the brake controller and magnetic powder brake unit, you must first
calibrate the torque display of the brake controller to 0 kg.m by adjusting the zero adj
knob located on the rear panel of magnetic powder brake unit with power on.
2. Install the required modules in the experimental frame. Construct the circuit in
accordance with the circuit diagram in Fig-1 and the connection diagram in Fig-2.
Note: The thermal switches of the wound-rotor induction machine and magnetic
powder brake unit must be connected together. The stator windings of the motor are
connected in delta.
1 (1.8 )
n (rpm) I (A)
2 (1.0 )
n (rpm) I (A)
Knob Position
3 (0.8 )
n (rpm) I (A)
4 (0.4 )
n (rpm) I (A)
5 (0.05 )
n (rpm) I (A)
0.00
0.05
0.10
0.15
0.20
0.25
0.30
2
rad / s
60
RESULTS:
Explain the main features you have learned from the experiments. Discuss on the
tables/graphics obtained from the tests and comment on the results in your report.