Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Note: For this exercise open the Getting Started Pipe.dwg file in the Pipe folder under
C:\CP_Gen2_3_1\Commercial.
1. On the Design pulldown menu or the Design toolbar select Options.
3. On the Design pulldown menu or the Design toolbar select Start a Run.
Figure #1
b. On the Design pulldown menu or the Design toolbar select Auto Route.
Note: This can be done in a Top View too but for this exercise we will do it in the ISO View.
On the Command line, Select Fitting Center [Fitting/Elevation/Roll/replace
Previous/Join/Lock toggle/Undo]: E, Enter
Use the on screen tooltip to bring the pipe up to 22, see figure #2
Figure #2
Pull the pipe at 0 degrees 8 using the on screen tooltip, see figure #3
Figure #3
Figure #4
Pull the pipe at 270 degrees 10 long using the on screen tooltip and then Enter to get out of
the command, see figure #5
Figure #5
c. On the Design pulldown menu or the Design toolbar select Insert into Pipe.
Figure #6
4. On the Design pulldown menu or the Design toolbar select Start a Run.
On the Command line, Digitize new elevation <KB Option>: Select the piece of pipe to the
left of the Valve
On the Command line, <From point>: In the Top View select above the same pipe and pull up
the screen and left click your mouse.
a. On the Pressure Pipe pulldown menu or the Pressure Pipe toolbar select Default Length,
see figure #7
Figure #7
b. On the Design pulldown menu or the Design toolbar select Insert into Pipe.
Figure #8
c. On the Design pulldown menu or the Design toolbar select Join To.
On the Command line, cpmnu_join Pipe/Fitting to Join to: Select the Branch of the Tee
d. On the Pressure Pipe pulldown menu or the Pressure Pipe toolbar select Cut to Length.
Figure #9
5. On the Design pulldown menu or the Design toolbar select Auto Routing Line.
On the Command line, Select Run to Process: Select the first piece of pipe in the run,
see figure #10
Figure #10
Note: This feature allows you to change the size, system and category of the pipe.
Delete the pipe off the routing line.
On the Design pulldown menu or the Design toolbar select Edit Routing Line Spec.
Then on the same pulldown menu and toolbar you can use Auto Elbow and Auto Pipe to
recreate the run.
6. On the Hanger pulldown menu or the Hanger toolbar select Configure Hanger.
7. On the Hanger pulldown menu or the Hanger toolbar select Place Hanger.
On the Command line, Select pipe/duct on run: In the Top View select the Cut to Length Pipe on
the left side of the Tee
On the Command line, Select Placement point on pathline: In the Top View select the Centerline
The Place Single Hanger will toggle through until you are done placing Hangers so place 1 more to
the right of the Valve, see figure #11
Figure #11
8. On the Utilities pulldown menu or the Utilities toolbar select Pipe Reports.
Figure #12
Note: The Display, Excel and Label reports all give the cut to lengths.