Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Attachment 3
4-1
MX (kip-ft)
MX_total
Eccentricity
Settlement
MX_perm
VY (kips)
VY_total
VY_perm
P (kips)1
Net
Ptotal
Pperm
MX max
MX min
Ptotal_min
Controlling load
combination2
MX max
MX min
Ptotal_max
Controlling load
combination3
Bearing
Sliding
MX (kip-ft)
VY (kips)
Ptotal (kips)1
Gross
MX max
MX min
Ptotal_max
Controlling load
combination3
VY max
VY min
Ptotal_min
Controlling load
4
combination
Notes:
1) Axial force (P) is assumed positive if compressive.
2) Controlling load combination is the one resulting in the highest eccentricity.
3) Controlling load combination is the one resulting in the highest qn,u /qpn or qg,u /qR
ratio for foundations on soil, or qn,max /qpn or qg,max /qR ratio for foundations on rock.
4) Controlling load combination is the one resulting in the highest factored sliding
force/factored sliding resistance ratio.
4-1
MX (kip-ft)
MX_total
Eccentricity
Settlement
MX_perm
MY (kips)
MY_total
MY_perm
P (kips)1
Net
Ptotal
Pperm
MX max
MX min
MY max
MY min
Ptotal_min
Controlling load
combination2
MX max
MX min
MY max
MY min
Ptotal_max
Controlling load
combination3
Sliding
MX (kip-ft)
MY (kip-ft)
VX (kips)
VY (kips)
Ptotal (kips)1
Gross
MX max
MX min
MY max
MY min
Ptotal_max
Controlling load
combination3
VX max
VX min
VY max
VY min
Ptotal_min
Controlling load
combination4
Notes:
1) Axial force (P) is assumed positive if compressive.
2) Controlling load combination is the one resulting in the highest eccentricity.
3) Controlling load combination is the one resulting in the highest qn,u /qpn or qg,u /qR ratio
for foundationson on soil, or qn,max /qpn or qg,max /qR ratio for foundations on rock.
4) Controlling load combination is the one resulting in the highest factored sliding force/
factored sliding resistance ratio.
4-1
Table 5. Intermediate Supports (Bents & Piers) at Extreme Event-I Limit State (Seismic)
M (kip-ft)
Extreme EventI
Limit State
MX
MY
V (kips)
VX
VY
P (kips)
PTotal
M d1 -I1,2
M d2 -I
M d3 -I
M d4 -I
M d5 -I
M d6 -I
M d7 -I
M d1 -II
M d2 -II
M d3 -II
M d4 -II
M d5 -II
M d6 -II
M d7 -II
Notes:
1) Md1 -Md7 stand for cases where seismic overstrength moment ( Mo) and associated
shear (Vo) are applied at 15 degree increments (0- 90) to a symmetrical spread footing.
2) Cases I and II correspond to highest and lowest column axial forces resulted from
seismic overturning in multicolumn bents. For single-column bents the two cases
(I and II) will be summarized into one case.
4-1