Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
CRT4279
DEH-P510UB/XN/UC
CD RECEIVER
DEH-P510UB
/XN/UC
DEH-P5100UB/XN/UC
DEH-P5150UB/XN/ES
DEH-P5150UB/XN/ES1
DEH-P5190UB/XN/ID
This service manual should be used together with the following manual(s):
Model No.
CX-3240
Order No.
CRT4050
Mech.Module
S10.5COMP2-iPod/USB
Remarks
CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
PIONEER CORPORATION
SAFETY INFORMATION
CAUTION
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safety repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safety, you should not risk trying to do so
and refer the repair to a qualified service technician.
WARNING
This product contains certain electrical parts contain chemicals which are known to the State of
California to cause cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 - Proposition 65
B
CAUTION:
USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE
SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.
CAUTION
CLASS 1M INVISIBLE LASER RADIATION WHEN OPEN. DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS
D
CAUTION
Danger of explosion if battery is incorrectly replaced.
Replaced only with the same or equivalent type recommended by the manufacture.
Discord used batteries according to the manufacture's instructions.
DEH-P510UB/XN/UC
1
1. Product safety
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by
following the safety instructions described in this manual.
1 Use specified parts for repair.
Use genuine parts. Be sure to use important parts for safety.
2 Do not perform modifications without proper instructions.
Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as
radio/TV interference and foreign noise.
3 Make sure the soldering of repaired locations is properly performed.
When you solder while repairing, please be sure that there are no cold solder and other debris.
Soldering should be finished with the proper quantity. (Refer to the example)
4 Make sure the screws are tightly fastened.
Please be sure that all screws are fastened, and that there are no loose screws.
5 Make sure each connectors are correctly inserted.
Please be sure that all connectors are inserted, and that there are no imperfect insertion.
6 Make sure the wiring cables are set to their original state.
Please replace the wiring and cables to the original state after repairs.
In addition, be sure that there are no pinched wires, etc.
7 Make sure screws and soldering scraps do not remain inside the product.
Please check that neither solder debris nor screws remain inside the product.
8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.
Damaged power cords may lead to fire accidents, so please be sure that there are no damages.
If you find a damaged power cord, please exchange it with a suitable one.
9 There should be no spark traces or similar marks on the power plug.
When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure
connections and suitable usage. Please exchange the power cord if necessary.
a Safe environment should be secured during servicing.
When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries.
Please pay attention to your surroundings and repair safely.
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.
Adjustments should be performed in accordance with the procedures/instructions described in this manual.
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper
cleaning should be performed to restore their performances.
DEH-P510UB/XN/UC
5
CONTENTS
SAFETY INFORMATION ..................................................................................................................................... 2
1. SERVICE PRECAUTIONS ............................................................................................................................... 5
1.1 SERVICE PRECAUTIONS......................................................................................................................... 5
1.2 NOTES ON SOLDERING .......................................................................................................................... 5
2. SPECIFICATIONS ............................................................................................................................................ 6
2.1 SPECIFICATIONS...................................................................................................................................... 6
2.2 DISC/CONTENT FORMAT ........................................................................................................................ 8
2.3 PANEL FACILITIES .................................................................................................................................... 9
2.4 CONNECTION DIAGRAM ....................................................................................................................... 13
3. BASIC ITEMS FOR SERVICE........................................................................................................................ 18
3.1 CHECK POINTS AFTER SERVICING..................................................................................................... 18
3.2 PCB LOCATIONS .................................................................................................................................... 19
3.3 JIGS LIST ................................................................................................................................................ 20
3.4 CLEANING............................................................................................................................................... 20
4. BLOCK DIAGRAM.......................................................................................................................................... 22
5. DIAGNOSIS.................................................................................................................................................... 24
5.1 OPERATIONAL FLOWCHART ................................................................................................................ 24
5.2 ERROR CODE LIST ................................................................................................................................ 25
5.3 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 27
6. SERVICE MODE ............................................................................................................................................ 28
6.1 DISPLAY TEST MODE ............................................................................................................................ 28
6.2 CD TEST MODE ...................................................................................................................................... 31
7. DISASSEMBLY............................................................................................................................................... 32
8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 35
8.1 CD ADJUSTMENT................................................................................................................................... 35
8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT.................................................... 36
8.3 PCL OUTPUT CONFIRMATION .............................................................................................................. 38
9. EXPLODED VIEWS AND PARTS LIST.......................................................................................................... 40
9.1 PACKING ................................................................................................................................................. 40
9.2 EXTERIOR(1) .......................................................................................................................................... 42
9.3 EXTERIOR(2) .......................................................................................................................................... 44
9.4 CD MECHANISM MODULE..................................................................................................................... 46
10. SCHEMATIC DIAGRAM ............................................................................................................................... 48
10.1 TUNER AMP ASSY(GUIDE PAGE) ....................................................................................................... 48
10.2 KEYBOARD UNIT.................................................................................................................................. 54
10.3 CD MECHANISM MODULE(GUIDE PAGE) .......................................................................................... 56
10.4 WAVEFORMS ........................................................................................................................................ 62
11. PCB CONNECTION DIAGRAM ................................................................................................................... 66
11.1 TUNER AMP ASSY ............................................................................................................................... 66
11.2 KEYBOARD UNIT.................................................................................................................................. 70
11.3 CD CORE UNIT(S10.5iPod-Code3) ...................................................................................................... 72
12. ELECTRICAL PARTS LIST .......................................................................................................................... 74
DEH-P510UB/XN/UC
1
1. SERVICE PRECAUTIONS
1.1 SERVICE PRECAUTIONS
A
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.
Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).
DEH-P510UB/XN/UC
5
2. SPECIFICATIONS
2.1 SPECIFICATIONS
A
DEH-P510UB/XN/UC, DEH-P5100UB/XN/UC
General
Power source..........................14.4 V DC (10.8 V to 15.1 V
allowable)
Grounding system................ Negative type
Max. current consumption
...............................................10.0 A
Audio
Maximum power output ...... 50 W 4
50 W 2/4 + 70 W 1/2
(for subwoofer)
Continuous power output .. 22 W 4 (50 Hz to 15 000
Hz, 5 % THD, 4 load, both
channels driven)
Load impedance ................... 4 to 8 4
4 to 8 2 + 2 1
Preout max output level ...... 4 V
Equalizer (7-Band Graphic Equalizer):
Frequency....................... 50/125/315/800/2k/5k/12.5k
Hz
Gain .................................. 12 dB
HPF:
Frequency...................... 50/63/80/100/125 Hz
Slope............................... 12 dB/oct
Subwoofer (mono):
Frequency....................... 50/63/80/100/125 Hz
Slope................................18 dB/oct
Gain ................................. +6 dB to 24 dB
Phase .............................. Normal/Reverse
Bass boost:
Gain ................................. +12 dB to 0 dB
CD player
System ..................................... Compact disc audio system
Usable discs .......................... Compact disc
Signal-to-noise ratio............. 94 dB (1 kHz) (IHF-A network)
Number of channels ............ 2 (stereo)
MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3
USB
USB standard specification
.............................................. USB 2.0 full speed
Maximum current supply ... 500 mA
Minimum memory capacity
............................................... 256 MB
USB Class............................... MSC(Mass Storage Class)
File system.............................. FAT16, FAT32
MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3
WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch
audio)
(Windows Media Player)
AAC decoding format...........MPEG-4 AAC (iTunes encoded only) (.m4a)
(Ver. 7.7 and earlier)
WAV signal format ................ Linear PCM & MS ADPCM
(Non-compressed)
FM tuner
Frequency range....................87.9 MHz to 107.9 MHz
Usable sensitivity................... 9 dBf(0.7 V/75 , mono,
S/N: 30 dB)
Signal-to-noise ratio............. 72 dB (IHF-A network)
AM tuner
Frequency range................... 530 kHz to 1 710 kHz (10
kHz)
Usable sensitivity.................. 25 V (S/N: 20 dB)
Signal-to-noise ratio............. 62 dB (IHF-A network)
CEA2006 Specifications
Note
Specifications and the design are subject to modifications without notice due to improvements.
DEH-P510UB/XN/UC
1
Audio
Maximum power output ...... 50 W 4
50 W 2/4 + 70 W 1/2
(for subwoofer)
Continuous power output .. 22 W 4 (50 Hz to 15 000
Hz, 5 % THD, 4 load, both
channels driven)
Load impedance ................... 4 to 8 4
4 to 8 2 + 2 1
Preout max output level ....... 4 V
Equalizer (7-Band Graphic Equalizer):
Frequency....................... 50/125/315/800/2k/5k/12.5k
Hz
Gain .................................. 12 dB
HPF:
Frequency....................... 50/63/80/100/125 Hz
Slope................................12 dB/oct
Subwoofer (mono):
Frequency....................... 50/63/80/100/125 Hz
Slope................................18 dB/oct
Gain .................................. +6 dB to 24 dB
Phase .............................. Normal/Reverse
Bass boost:
Gain .................................. +12 dB to 0 dB
CD player
System ..................................... Compact disc audio system
Usable discs .......................... Compact disc
Signal-to-noise ratio............. 94 dB (1 kHz) (IEC-A network)
Number of channels ............ 2 (stereo)
MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3
WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch
audio)
(Windows Media Player)
USB
FM tuner
Frequency range................... 87.5 MHz to 108.0 MHz
Usable sensitivity.................. 9 dBf (0.7 V/75 , mono,
S/N: 30 dB)
Signal-to-noise ratio............. 72 dB (IEC-A network)
D
AM tuner
Frequency range................... 531 kHz to 1 602 kHz (9 kHz)
530 kHz to 1 640 kHz (10
kHz)
Usable sensitivity.................. 25 V (S/N: 20 dB)
Signal-to-noise ratio............. 62 dB (IEC-A network)
(ES, ES1)
Note
Specifications and the design are subject to modifications without notice due to improvements.
DEH-P510UB/XN/UC
5
DEH-P510UB/XN/UC, DEH-P5100UB/XN/UC
B
DEH-P510UB/XN/UC
1
DEH-P510UB/XN/UC, DEH-P5100UB/XN/UC
SW/BASS button
Press to switch to subwoofer setting menu.
When operating subwoofer menu, press to
switch menu.
Press and hold to switch to bass boost
menu.
What s what
Head unit
USB port 1
Use to connect a USB storage device and
an iPod.
When connecting, open up the USB connector lid.
Use a USB cable to connect the USB storage device to the USB port 1. Since the
USB storage device is projected forward
from the unit, it is dangerous to connect
directly.
Pioneer CD-U50E USB cable is also available. For details, consult your dealer.
(detach) button
Press to remove the front panel from the
head unit.
AUX input jack (3.5 mm stereo jack)
Use to connect an auxiliary device.
E
(repeat)/LOC button
Press to switch the repeat play range while
using CD, USB or iPod.
Press to switch local settings while using
tuner as the source.
(random)/iPod button
Press to turn random function on or off
while using CD or USB.
DEH-P510UB/XN/UC
5
DISP/SCRL button
Press to select different displays.
Press and hold to scroll through the text information.
BAND/ESC button
Press to select among three FM bands and
one AM band.
Press to return to the ordinary display when
operating the menu.
Remote control
/ / / buttons
Press to perform manual seek tuning, fast
forward, reverse and track search controls.
Also used for controlling functions.
AUDIO button
Press to select an audio function.
button
Press to turn pause on or off.
FUNCTION button
Press to select functions.
LIST/ENTER button
Press to display the disc title list, track title
list, folder list, file list or preset channel list
depending on the source.
While in the operating menu, press to control functions.
Operation is the same as when using the buttons on the head unit.
Screw
BPZ20P060FTC
VOLUME buttons
Press to increase or decrease the volume.
MUTE button
Press to turn off the sound. To turn on the
sound, press again.
10
DEH-P510UB/XN/UC
1
(eject) button
Press to eject a CD/CD-R/CD-RW.
What s what
Head unit
SRC/OFF button
This unit is turned on by selecting a source.
Press to cycle through all the available
sources.
/LIST button
Press to display the disc title list, track title
list, folder list, file list or preset channel list
depending on the source.
Press and hold to switch to link play mode
while using an iPod.
For details, refer toPlaying songs related to
the currently playing song.
S.Rtrv button
Press to switch advanced sound retriever
settings.
For details, refer toUsing advanced sound
retriever.
MULTI-CONTROL
Move to perform manual seek tuning, fast
forward, reverse and track search controls.
Also used for controlling functions.
Turn to increase or decrease the volume.
SW/BASS button
Press to switch to subwoofer setting menu.
When operating subwoofer menu, press to
switch menu.
Press and hold to switch to bass boost
menu.
Disc loading slot
Insert a CD/CD-R/CD-RW to play.
USB port
Use to connect a USB storage device and
an iPod.
When connecting, open up the USB connector lid.
Use a USB cable to connect the USB storage device to the USB port. Since the
USB storage device is projected forward
from the unit, it is dangerous to connect
directly.
Pioneer CD-U50E USB cable is also available. For details, consult your dealer.
(detach) button
Press to remove the front panel from the
head unit.
AUX input jack (3.5 mm stereo jack)
Use to connect an auxiliary device.
(repeat)/LOC button
Press to switch the repeat play range while
using CD, USB or iPod.
Press to switch local settings while using
tuner as the source.
(random)/iPod button
Press to turn random function on or off
while using CD or USB.
While using an iPod, press to shuffle all
tracks.
Press and hold to switch the control mode
while using an iPod.
For details, refer toOperating this units iPod
function from your iPod.
If using the iPod with an interface adapter
(CD-IB100 ), press to switch the shuffle
function.
DISP/SCRL button
Press to select different displays.
F
DEH-P510UB/XN/UC
5
11
LIST/ENTER button
Press to display the disc title list, track title
list, folder list, file list or preset channel list
depending on the source.
While in the operating menu, press to control functions.
Remote control
Operation is the same as when using the buttons on the head unit.
Screw
BPZ20P060FTC
(Service)
VOLUME buttons
Press to increase or decrease the volume.
MUTE button
Press to turn off the sound. To turn on the
sound, press again.
/ / / buttons
Press to perform manual seek tuning, fast
forward, reverse and track search controls.
Also used for controlling functions.
E
AUDIO button
Press to select an audio function.
button
Press to turn pause on or off.
FUNCTION button
Press to select functions.
12
DEH-P510UB/XN/UC
1
Rear output
Dock connector
Antenna jack
Rear speaker
Left
Front speaker
Green/black
Green
White/black
White
Multi-CD player
(sold separately)
Rear speaker
Right
Front speaker
Rear speaker
Front speaker
Subwoofer
Power amp
(sold separately)
Rear speaker
Front speaker
Subwoofer
Power amp
(sold separately)
Blue/white
Connect to system control terminal of the power
amp or auto-antenna relay control terminal (max.
300 mA 12 V DC).
To subwoofer
output
To front output
To rear output
Power amp
(sold separately)
Violet/black
Violet
Gray/black
Gray
Yellow/black
If you use an equipment with Mute function,
wire this lead to the Audio Mute lead on that
equipment. If not, keep the Audio Mute lead
free of any connections.
IP-BUS cable
USB port 2
Use a USB cable to connect the USB storage
20 cm
device to the USB port 2.
(7-7/8 in.) Pioneer CD-U150E USB cable is also available.
For details, consult your dealer.
Orange/white
Connect to lighting switch terminal.
Red
Connect to terminal controlled by
ignition switch (12 V DC).
Yellow
Connect to the constant 12 V supply terminal.
Fuse (10 A)
This product
Front output
Subwoofer output
Interface cable
iPod
50 cm (20 in.)
DEH-P510UB/XN/UC
5
8
DEH-P510UB/XN/UC
13
14
Rear output
Dock connector
Antenna jack
Front output
Subwoofer output
Fuse (10 A)
This product
Note
Change the initial setting of this unit.
The subwoofer output of this unit is monaural.
Violet/black
Violet
Gray/black
Gray
Subwoofer (4
Green/black
Green
Violet/black
Violet
Right
Front speaker
Blue/white
Connect to system control
terminal of the power amp or
auto-antenna relay control
terminal (max. 300 mA 12 V DC).
Subwoofer
(4 ) 2
Green/black
Green
White/black
White
Orange/white
Connect to lighting switch terminal.
Subwoofer (4
Front speaker
Left
M
Multi-CD
player
(old separately)
Red
Connect to terminal controlled by ignition switch (12 V DC).
IP-BUS cable
Yellow
Connect to the constant 12 V supply terminal.
Yellow/black
If you use an equipment with Mute function, wire this lead to the Audio
Mute lead on that equipment. If not, keep the Audio Mute lead free of
any connections.
Interface cable
iPod
USB port 2
Use a USB cable to connect the USB storage
20 cm
device to the USB port 2.
(7-7/8 in.) Pioneer CD-U150E USB cable is also available.
For details, consult your dealer.
50 cm (20 in.)
DEH-P510UB/XN/UC
1
3
4
DEH-P510UB/XN/UC, DEH-P5100UB/XN/UC
DEH-P510UB/XN/UC
Rear output
Dock connector
Antenna jack
Not used.
Green/black
Green
White/black
White
Violet/black
Violet
Gray/black
Gray
Yellow/black
If you use an equipment with Mute function,
wire this lead to the Audio Mute lead on that
equipment. If not, keep the Audio Mute lead
free of any connections.
IP-BUS cable
Multi-CD player
(sold separately)
Rear speaker
Front speaker
Subwoofer
Power amp
(sold separately)
Rear speaker
Front speaker
Subwoofer
Power amp
(sold separately)
Blue/white
Connect to system control terminal of the power
amp or auto-antenna relay control terminal (max.
300 mA 12 V DC).
To subwoofer
output
To front output
To rear output
Power amp
(sold separately)
Orange/white
Connect to lighting switch terminal.
Red
Connect to terminal controlled by
ignition switch (12 V DC).
Yellow
Connect to the constant 12 V supply terminal.
Fuse (10 A)
This product
Front output
Subwoofer output
Interface cable
iPod
50 cm (20 in.)
USB port 2
Use a USB cable to connect the USB storage
20 cm
device to the USB port 2.
(7-7/8 in.) Pioneer CD-U150E USB cable is also available.
For details, consult your dealer.
If using this system, we recommend that this units internal amp is turned off.
For more details, refer to operation manual.
5
7
8
DEH-P510UB/XN/UC
A
DEH-P510UB/XN/UC
15
16
22. Green
16. White/black
15. White
25. Violet/black
24. Violet
18. Gray/black
17. Gray
28. Yellow/black
If you use an equipment with Mute
function, wire this lead to the Audio Mute
lead on that equipment. If not, keep the
Audio Mute lead free of any connections.
37. Subwoofer
37. Subwoofer
34. Blue/white
Connect to system control terminal of the
power amp or auto-antenna relay control
terminal (max. 300 mA 12 V DC).
3
31. To subwoofer output
13. Orange/white
Connect to lighting switch terminal.
12. Red
Connect to terminal controlled by
ignition switch (12 V DC).
8. IP-BUS cable
9. Multi-CD player
(sold separately)
3
30. To front output
11. Yellow
Connect to the constant 12 V supply terminal.
6. Antenna jack
2
29. To rear output
5. Subwoofer output
2. This product
4. Front output
3. Rear output
1
3
4
DEH-P510UB/XN/UC
3. Rear output
28. Yellow/black
If you use an equipment with Mute
function, wire this lead to the Audio Mute
lead on that equipment. If not, keep the
Audio Mute lead free of any connections.
8. IP-BUS cable
23. Green/black
22. Green
16. White/black
15. White
25. Violet/black
24. Violet
18. Gray/black
17. Gray
39. Subwoofer (4 )
23. Green/black
22. Green
25. Violet/black
24. Violet
21. Right
34. Blue/white
Connect to system control
terminal of the power amp or
auto-antenna relay control
terminal (max. 300 mA 12 V DC).
42. Subwoofer
(4 ) 2
39. Subwoofer (4 )
20. Left
9. Multi-CD player
(sold separately)
38. Note
Change the initial setting of this unit.
The subwoofer output of this unit is monaural.
2. This product
13. Orange/white
Connect to lighting switch terminal.
12. Red
Connect to terminal controlled by
ignition switch (12 V DC).
11. Yellow
Connect to the constant 12 V supply terminal.
6. Antenna jack
5. Subwoofer output
4. Front output
5
7
8
DEH-P510UB/XN/UC
17
To keep the product quality after servicing, please confirm following check points.
No.
1
Procedures
Confirm whether the customer complain has
been solved.
If the customer complain occurs with the
specific media, use it for the operation check.
Play back a CD.
(Track search)
Check FM/AM tuner action.
(Seek, Preset)
Switch band to check both FM and AM.
Check whether no disc is inside the product.
Appearance check
2 CD
3 FM/AM tuner
B
Item to be confirmed
The customer complain must not be
reappeared.
Display, audio and operations must be
normal.
No malfunction on display, audio and
operation.
Display, audio and operations must be
normal.
The media used for the operating check must
be ejected.
No scratches or dirt on its appearance after
receiving it for service.
See the table below for the items to be checked regarding audio:
Item to be checked regarding audio
Distortion
Noise
Volume too low
Volume too high
Volume fluctuating
Sound interrupted
18
DEH-P510UB/XN/UC
1
B Keyboard Unit
B
C CD Core Unit
(S10.5iPod-Code3)
A:DEH-P510UB/XN/UC
B:DEH-P5100UB/XN/UC
C:DEH-P5150UB/XN/ES
D:DEH-P5150UB/XN/ES1
E:DEH-P5190UB/XN/ID
Unit Number
:
Unit Number
:
Unit Number
:
Unit Name
:
Unit Number
:
Unit Number
:
Unit Name
:
Unit Number
:
Unit Name
:
QWM3065(A)
QWM3064(B)
QWM3066(C,D,E)
Tuner Amp Assy
(A)
(B,C,D,E)
Keyboard Unit
CWX3678
CD Core Unit(S10.5iPod-Code3)
DEH-P510UB/XN/UC
5
19
Name
Test Disc
L.P.F.
Jig No.
TCD-782
Remarks
Checking the grating
Checking the grating (Two pieces)
Grease No.
GEM1024
GEM1045
Remarks
CD Mechanism Module
CD Mechanism Module
- Grease List
Name
Grease
Grease
3.4 CLEANING
Cleaning tools
Cleaning liquid : GEM1004
Cleaning paper : GED-008
20
DEH-P510UB/XN/UC
1
DEH-P510UB/XN/UC
5
21
4. BLOCK DIAGRAM
OSC
ANTENNA
CN401
AM ANT
19
20
21
NC
NC
DO
18
NC
14
NC
DI
11
NC
CK
DI
IC5
5V 3.3V
IC3 EEPROM
5.0V
CE1
10 9
CK
5
SL
NC
CE2
ROM_VDD
13
CE1
VDD
DO
CE2
SL
LPF
FMRF
ATT
2,3
IC2
2.5V
IC1
3.3V
FM ANT
3
ATT
Lch
MIXER, IF AMP
FMRF
23
DET, FM MPX,
RF adj
ANT adj
DGND
AUDIOGND
NC
17
OSCGND
12
15
22
16
CF52
IC4
3.3V 3.3V 2.5V 2.5V
VCC
RFGND
VDD_3.3
T51
TUNL
CDL
TUNER3V
1
A8V
IC451
NJM2885DL1-33
A8V
BUSL+
BUSL-
CN101
7
11
A :DEH-P510UB/XN/UC
B :DEH-P5100UB/XN/UC
C :DEH-P5150UB/XN/ES
IP BUS
5
1
IP-BUS DRIVER
IC101
HA12241FP
L+
LBUS-
BUS+
BUS-
28
ROUT 2
BUS+
27
STBY
ASENB
19
BUP
79
D :DEH-P5190UB/XN/ID
D
80
Q102
USB 5V
IC501
BD9781HFP
1
BUP
C CD CORE UNIT(S10.5iPod-Code3)
PICKUP UNIT
(P10.5)(SERVICE)
VDD2
CN101
LD
LDMD
15
15
VREF 8
Q101
142
REFO
HOLOGRAM
UNIT
FOM
MD
FOCUS ACT.
TRACKING ACT.
SPINDLE
MOTOR
133
PD
3
FOP
2
TOP
1
TOM
4
LD+
14
VBUS
VOUT
VIN
12
FOM
11
FOP
14
TOP
13
TOM
X201
16.93MHz
/PUEN
IC201
PE5661A
SD,MD
D-
D+
12
13
10
Q102
VDD2
DP
LOUT
16
22
SOP
LOEJ
15
SOM
21
18
LCOP CLCONT
17
9
CONT
LCOM
IPPW
ASENBO
OELPW
40
51
3A
DP 16
DM
LOUT
55
USBCTL2
BUP
FLG2
A
1
52
USSEL
ILMPW
4B2
SYSTEM
CONTROLLER
IC 601(2/2)
PEG509A8: A B
PEG576A8: C D
3B2
1B1
1A
2B1
2A
4
7
4 DP
17
3 DM
13
ROT1
LOUT
ROT0
C D
20
41
Q201
CLCONT
VDD
VDD3
11
12
VDD
CONT
/ADENA
MECHA 3.3V
VDD2
LOEJ
/RESET
41
4A
CN701
SYNC
VDD
28
20
SW
39
CN701
DM
22
SW USB
IC761
TC7MB3257FK
2
VCC
TD,FD
EN 3
OC 4
IC301
BA5839FP
14
IC571
BD6538G
XTAL 50
CD
DRIVER
LOADING/CARRIAGE
MOTOR
X205
48MHz
/XTAL 52
FOM
3
FOP
2
TOP
1
TOM
4
USB IF2
USB
/USBXTAL 2
REFOUT
AC,BD,E,F
AMPM
RX2
VIN
EN
CN591
USBXTAL 1
LD
RX
85
1
USB5V
MUTE
TX
SYSPW
Q101
:DEH-P5150UB/XN/ES1
DIN1
IC731
NJM2885DL1-33
KYDT(RWRX)
DPDT(RWTX)
1
35
36
30
29
VDD
17
/RESET
16
RESET
92
CDRST
12EJ
SWVDD
BRST,BRXEN,BSRQ
8EJ
DSCSNS
9
HOME
38
BRST,BRXEN,BSRQ,BDATA,BSCK
10
S904
12EJ
S905
8EJ
BDATA,BSCK
18
19
VD
Q751
MECHA VD
DSENS
VDSENS
11
CPRDY,CPRST
SDA,SCL
VDCONT
USBCTL1
FLG1
DEH-P510UB/XN/UC
1
91
BUP
Q752
42
iPod CP
22
VD
S903
DSCSNS
IC205
341S2162
VD
VD
S901
HOME
USB5V
45
87
A
CN151
89
KEYAD
SYSTEM
CONTROLLER
IC 601(1/2)
PEG509A8: A B
PEG576A8: C D
CE2
TUNPCE2
70
TUNPCE1
46
TUNPDI
47
TUNPDO
48
TUNPCK
95 SL
CE1
DI
DO
CK
SL
FL
RESET
IC651
S-80835CNNB-B8U
FL
10
RCA OUT
Q301
11
XOUT
RL
RL
13
SWL
SWL
X601
15.000MHz
Q304
Q303
(2/2)
Q901
1
WIRED
REMOTE
Q303
(1/2)
BUP
CN302
SP601
BUZZER
XIN
VDD
PEE 24
69
KEYD
KEYAD
KEYD
VDD
VDD
Q902
RESET
DALMON
67
BUP
BSENS
BSENS
CN981
73
B.UP
16
Q921
ELECTRONIC VOLUME/
SOURCE SELECTOR
ASENS
93
Noise_ 20
DET_out
14
MUTE
57
72
ASLIN
ACC
ISENS
TELIN
TEL
Front_L
8
Rear_L
IN3_L
9 IN1_L
CDL
BUSL-
6
10
AUXL
40
FL+
38
14
39
VP
EVOL VP+B
RLIN
6,20
BUP
43
VCC
MUTE
22
OELB
Q242
IN4-_L
FL-
AMP
IC351
PA2030A
FLIN
12
Q241
IN4+_L
Q961
PRE/SW_L
TUNL
12
Q931
IC201
PML017A
BUSL+
ILL
TEL IN
EMUTE
SAOUT, SACLK
14
ISENS
ASENS
81
RL+
RLB.REM
STBY
4
21
FL+
FL-
23
5
3
RLBREM
GND
RL+
25
SOURCE
CONNECTOR
8
11
15
MUTE
A8V
IN2_L
Q381
VST,VCK,VDT
B C D
BUP
MUTE
SYSPW
AMPM
A8V
VIN
VOUT
BUP
CTRL
OEL+B
Q851
OELB
Q852
IC851
NJM2360AM
6,7
OELPW
SYS+B
IC911
NJM2388F84
Q351
BUP
Q352
85
20
B KEYBOARD UNIT
AUX
IC181
NJM2794V
1
OUT1
IN1+
IN1-
AUXL
12
AUXG
19
18
18
Q822
16
16
ILLUMI
KEY MATRIX
Q1833
98
ILM+B
XOUT
11
X1901
16MHz
DIM
XIN
D1831
D1833
D1835
D1840
13
A
ILMPW
KD0-3,KS0-2
41
Q1831
SYSTEM
ONTROLLER
C 601(2/2)
09A8: A B
76A8: C D
99
ILL
ROT0
KYDT(RWRX)
DPDT(RWTX)
ROT1
35
36
ROT0
30
KYDT
DPDT
29
SWVDD
SWVDD
VDD
11
13
13
11
ROT0
ROT1
38
DSENS 20
OEL+B
10
USB IF1
T
USBCTL1
FLG1
S1837
LOC/RPT
S1832
S1835
SOURCE/OFF
BAND/ESC
DISP
S1833
S1836
S1839
S1834
LIST
SRTrv/SAT
IPod/RDM
TA/NEWS
S1838
S1840
S1838
MUTE/SW BASS
BACK/SCRL
D[0-15]
USB5V
45
87
1
3
4
VIN
EN
OC
IC551
BD6538G
VOUT
20
10
88
Phase_A
KYDT
28
27
DPDT
VDD3.3V
1,3
SWVDD
Q842
91
10
Phase_B
OPT IN
DSENS
S1834
CLK/DISP OFF
A[1-17,19]
ROTARY COMMANDER
Q841
SWVDD
S1831
EJECT
MICRO
COMPUTER
IC1901
PEG511A8
S1811
ROT1
FRONT
AUX
AUXL 2
AUXG 1
AUXG
Q821
ILM+B
BUP
AUXR 3
19
AUXL
D1834
ILM+B
L2
14
CN1821
CN1801
CN801
5
IC1951
S-1200B33-M5
REMOTE
CONTROL SENSOR
14
3
1
97
IC1931
GP1UXC14RK
DSENS
JOYST
43
2
12
KYDT
23
DPDT
33
VCC1
60
VCC2
96
Vref
14
42
RD
46
CS2
47
CS1
48
CS0
AVCC
REM
OE
A19
A18
ROM
IC1981
PD8184A: A
PD8185A: B C D
CE
VCC
BYTE
CN1961
22
O-DC
23
O-CSB
24
O-RST
26
O-CIN
33
O-SID
35
O-SCLK
5
3
4
8
7
6
DC
CSB
RSTB
OSCIN
D7(SDIN)
D6(SCLK)
OEL
UNIT
11 VDD
2.
VCC
12
OEL+B
F
CN1851
5 US5V
USDP
USDM
12
12
14
14
US5V
USB5V
USDP
USDP
USDM
USDM
1
3
USB
DEH-P510UB/XN/UC
5
23
5. DIAGNOSIS
5.1 OPERATIONAL FLOWCHART
A
Power ON
Vcc = 5 V
Pin 14
BSENS
Pin 73
B
BSENS = L
ASENS
Pin 72
ASENS = L
DSENS
Pin 91
2.0 V < DSENS < 4.5 V
ASENBO <- H
Pin 80
Starts
communication
with Grille
microcomputer.
SWVDD <- H
Pin 38
500 ms
300 ms
Source keys
operative
Source ON
E
SYSPW <- H
Pin 1
24
DEH-P510UB/XN/UC
1
6-digit display
ERR-xx
4-digit display
E-xx
11
Electricity
Focus Servo NG
12
Electricity
Spindle Lock NG
Subcode NG
17
Electricity
Setup NG
30
Electricity
44
Electricity
ALL Skip
50
Mechanism
CD On Mech Error
System
Power Supply NG
Remarks: Mechanical errors are not displayed (because a CD is turned off in these errors).
Unreadable TOC does not constitute an error. An intended operation continues in this case.
Upper digits of an error code are subdivided as shown below:
1x: Setup relevant errors, 3x: Search relevant errors, Ax: Other errors.
DEH-P510UB/XN/UC
5
25
iPod
Message
Cause
Action
Message
Cause
Action
NO AUDIO
No songs
ERROR-19
Communication
failure
Disconnect the
cable from iPod.
Once iPod main
menu is displayed,
connect the cable
again.
Reset the iPod.
iPod failure
Disconnect the
cable from iPod.
Once iPod main
menu is displayed,
connect the cable
again.
Reset the iPod.
NO DEVICE
The connected
TRK SKIPPED USB storage device contains
WMA files that
are protected by
Windows
Media DRM 9/
10
PROTECT
Connect a USB
storage device that
is USB Mass Storage Class compliant.
CHECK USB
Disconnect the
USB storage device and do not
use it. Turn the
ignition switch to
OFF, then to ACC
or ON and then
connect the compliant USB storage
device.
ERROR-19
Communication
failure
ERROR-23
26
iPod failure
Disconnect the
cable from iPod.
Once iPod main
menu is displayed,
connect the cable
again.
Reset the iPod.
ERROR-A1
CHECK USB
iPod is not
charged but operates correctly
NO SONGS
No songs
STOP
No songs in the
current list
NO DEVICE
DEH-P510UB/XN/UC
1
FRONT
OUTPUT
REAR
OUTPUT
GND D+
D- VBUS
ANTENNA
IP-BUS INPUT
SUBWOOFER
OUTPUT
8 9 10 11
1 3 5 7 9 11 13 15
2 4 6 8 10 12 14 16
5 6
1 2 3 4
1.
2.
3.
4.
5.
6.
7.
8.
FR+
RR+
FRRRFL+
RL+
FLRL-
9.
10.
11.
12.
13.
14.
15.
16.
TEL
NC
B.REM
ILL
NC
ACC
GND
BUP
1. BUS1
2. GND
3. GND
4. NC
5. BUS2
6. GND
7. BUSL1
8. ASENB1
9. BUSR1
10. BUSR2
11. BUSL2
D
DEH-P510UB/XN/UC
5
27
6. SERVICE MODE
6.1 DISPLAY TEST MODE
A
S.Rtrv Key
S.Rtrv+CLOCK Key
S.Rtrv Key
To the display of ROM correction version information
on the display microcomputer function test mode.
S.Rtrv+CLOCK Key
To the static display of the display mode.
S.Rtrv Key
The display microcomputer function Test Mode
to the display usually.
S.Rtrv+CLOCK Key
S.Rtrv Key
To all turning on
the display microcomputer function test mode.
S.Rtrv Key
(To all turning off
the display microcomputer function test mode.)
S.Rtrv Key
To the bus connection confirmation of
the display microcomputer function test mode.
S.Rtrv Key
28
DEH-P510UB/XN/UC
1
UNIT
: WW number
? ? ? ? : Unit number information of System microcomputer
& & & & : Unit number information of Display microcomputer
(When the Unit number is QWW3007, it is displayed as 3007.)
PD
X X X X : PD number information of System microcomputer
Y Y Y Y : PD number information of Display microcomputer
(When the Unit number is PEG511A, it is displayed as 511A.)
Z Z Z Z Z : PD number information of Image ROM
(When the Unit number is PD8184A, it is displayed as 8184A.)
Ver.
: System microcomputer Ver.Info
: Display microcomputer Ver.Info
: Image ROM Ver.Info
: EEPROM Ver.Info
: CH use information (1:Use / 0:Not use Corresponds from the left to CH1, CH2, CH3, CH4)
When information couldn't be acquired from EEPROM.
$ $ $ $ $ $ $ $ $ : Error information
NO_EEPROM (ROM CORRECTION is not connected)
ROM_ERROR (ROM CORRECTION data error)
If nothing is displayed on the screen:
There may be a problem with the communication, or the display microcomputer may have an error.
If a number apparently strange is displayed as the EEPROM version:
There may be a problem with the communication.
If a version display is being made but the number of CH used is not displayed properly:
The connection with the EEPROM may be defective.
DEH-P510UB/XN/UC
5
29
All lights on
A
: OK or NG
If nothing is displayed on the screen:
There may be a problem with the communication, or the display microcomputer may have an error.
If NG is displayed somewhere:
The connection between the display microcomputer and the image ROM may be defective. For example, even
if NG is displayed for the data bus, it is not necessarily a data bus connection defective.
A problem with the address bus may also cause an error during data bus check.
30
DEH-P510UB/XN/UC
1
Contents
Display
[CD] or [SOURCE]
Source On
TRK
MIN
SEC
[BAND]
[3]
Power On
(T.Offset is adjusted)
TRK MIN SEC
00
[BAND]
MIN
SEC
Power Off
MIN
SEC
[BAND]
Power Off
TRK
MIN
91
SEC
99
99
TRK
MIN
SEC
[2]
[4]
RF AMP *1
Gain switching
TRK MIN SEC
SPINDLE *9
Speed switching
TRK MIN SEC
GG
GG
GG
SP
[1]
SEC
0X
0X
0X
00 00 00
or 99 99 99
[6]
[3]
T.Close
Applicable servomechanism
TRK MIN SEC
SP
[<]
CRG -
*8
00 00 00
or 99 99 99
*8
00 00 00
or 99 99 99
[<]
8X 8X 8X
or 9X 9X 9X
8X 8X 8X
or 9X 9X 9X
[>]
[<]
[1]
[3]
[6]
CRG/TR jump
value switching*5
TRK MIN SEC
TRK
??
??
CRG/TR Jump -
*4
*4
TRK
SEC
??
OL
OL
OL
T.Balance adjustment /
T.BAL coefficient display
TRK MIN SEC
??
??
??
[2]
CRG/TR Jump +
MIN
??
[2]
CRG -
??
??
??
[5]
Self-adjusting
switching *3
TRK MIN SEC
CRG +
F,T,RF AGC*7
F.Bias display switching
TRK MIN SEC
??
[2]
CRG +
[>]
RF AGC /
RF AGC coefficient display
TRK MIN SEC
??
SP
[>]
Tracking Servo
Close
*2
TRK
91
[1]
T.Close & AGC
Applicable servomechanism
[BAND]
99
[6]
Focus Close
S curve check
TRK MIN SEC
91
TRK
00
[3]
Power Off
TRK
00
Power On
(T.Offset is not adjusted)
TRK MIN SEC
MIN
Tracking Open
SEC
8X 8X 8X
or 9X 9X 9X
*6
[BAND]
[2]
Power Off
TRK
*1)
MIN
Tracking Open
TYP
TRK
8X 8X 8X
or 9X 9X 9X
SEC
MIN
->
SEC
TRK
+ 6 dB
->
06MIN06SEC06
+ 12 dB
12MIN12SEC12
TRK
F EQ measurement setting
TRK
02MIN02SEC02
[Key]
[BAND]
[>]
[<]
[1]
*3) F.Offset Display -> RF.Offset -> T.Offset Display -> Switch to the
order of the original display
[2]
[3]
*4) 1TR/4TR/10TR/32TR/100TR
*5) Single -> 4TR -> 10TR -> 32TR -> 100TR -> CRG Move
9x(8x):91(81) 92(82)
93(83)
94(84)
95(85)
96(86)
[4]
[5]
*7) TRK/MIN/SEC -> F.AGC -> T.AGC Gain -> F Bias -> RF AGC
[6]
Operation
Test Mode
Power On/Off
CRG + / TR Jump +
(Direction of the external surface)
CRG - / TR Jump (Direction of the internal surface)
T. CLS & AGC & Applicable servomechanism /
AGC,AGC display setting
RF Gain switching / Offset adjustment display /
T.Balance adjustment / T. Open
F. Close,S Curve / Rough Servo and RF AGC /
F,T,RF AGC
SPDL 1X/2X switching
As for the double speed(2x), audio output cannot be
supported.
Error Rate measurement
ON : ERR 30 Counts Start
BER display data[%]
F. Mode switching / Tracking Close / CRGTR
Jump Switching
TYP (1X)
TRK
MIN
SEC
->
2X
->
22MIN22SEC22
TRK
1X
11MIN11SEC11
TRK
*10)
OFF(TYP)
TRK
MIN
->
SEC
FORCUS
->
70MIN70SEC70
TRK
TRACKING
71MIN71SEC71
TRK
DEH-P510UB/XN/UC
5
31
7. DISASSEMBLY
- Removing the Case (not shown)
A
CD Mechanism Module
2
Disconnect the connector and then remove the
CD Mechanism Module.
2
1
1
1
Panel Assy
Fig.1
3
2
3
3
F
32
Fig.2
DEH-P510UB/XN/UC
1
a
B
Upper Frame
B
B
D
B
B
A
Damper
A
Carriage Mechanism
Lower Frame
Damper
DEH-P510UB/XN/UC
5
33
Shorting Solder
Screw
B
CD Core Unit
Solder
Poly Washer
Change Arm
Inner Holder
Feed Screw
Planet Gear
Pickup Rack
Chassis
Pickup
34
DEH-P510UB/XN/UC
1
1) Cautions on adjustments
In this product the single voltage (3.3 V) is used for the
regulator. The reference voltage is the REFO1 (1.65 V)
instead of the GND.
If you should mistakenly short the REFO1 with the GND
during adjustment, accurate voltage will not be obtained,
and the servos misoperation will apply excessive shock
to the pickup. To avoid such problems:
a. Do not mix up the REFO1 with the GND when
connecting the (-) probe of measuring instruments.
Especially on an oscilloscope, avoid connecting the (-)
probe for CH1 to the GND.
b. In many cases, measuring instruments have the same
potential as that for the (-) probe. Be sure to set the
measuring instruments to the floating state.
c. If you have mistakenly connected the REFO1 to the GND,
turn off the regulator or the power immediately.
Before mounting and removing filters or leads for
adjustment, be sure to turn off the regulator.
For stable circuit operation, keep the mechanism
operating for about one minute or more after the
regulator is turned on.
2) Test mode
This mode is used to adjust the CD mechanism module.
To enter the test mode.
While pressing the 4 and 6 keys at the same time, reset.
To exit from the test mode.
Turn off the ACC and back up.
Notes:
a. During ejection, do not press any other keys than the
EJECT key until the loaded disc is ejected.
b. If you have pressed the (->) key or (<-) key during focus
search, turn off the power immediately to protect the
actuator from damage caused by the lens stuck.
c. For the TR jump modes except 100TR, the track jump
operation will continue even if the key is released.
d. For the CRG move and 100TR jump modes, the tracking
loop will be closed at the same time when the key is
released.
e. When the power is turned off and on, the jump mode
is reset to the singleTR (91), the RF amp gain is set to 0 dB,
and the auto-adjustment values are reset to the default
settings.
DEH-P510UB/XN/UC
5
35
Note :
The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism
module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU
unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the
PU unit must be changed, the grating should be checked using the procedure below.
Purpose :
To check that the grating is within an acceptable range when the PU unit is changed.
Symptoms of Mal-adjustment :
If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform
track search operations, or taking a long time for track searching.
Method :
Measuring Equipment
Measuring Points
Disc
Mode
CD CORE UNIT
C
REFO1
E
L.P.F.
E
Xch
100 kohm
100 kohm
390 pF
VREF
D
Oscilloscope
390 pF
VREF
Ych
L.P.F.
Checking Procedure
1. In test mode, load the disc and switch the 3 V regulator on.
2. Using the -> and <- buttons, move the PU unit to the innermost track.
3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking balance
adjustment the display should now read "81". Press key 3. The display will change, returning to "81" on the
fourth press.
4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase
difference is within 75 degrees. Refer to the photographs supplied to determine the phase angle.
5. If the phase difference is determined to be greater than 75 degrees try changing the PU unit to see if there is any
improvement. If, after trying this a number of times, the grating angle does not become less than 75 degrees then the
mechanism should be judged to be at fault.
Note
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be
seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the
average angle.
Hint
Reloading the disc changes the clamp position and may decrease the "wobble".
36
DEH-P510UB/XN/UC
1
Grating waveform
0 degrees
30 degrees
45 degrees
60 degrees
C
75 degrees
90 degrees
DEH-P510UB/XN/UC
5
37
- PCL output
In the normal operation mode (with the detachable panel installed, the ACC switched ON, the standby mode
cancelled), shift the TESTIN IC601(Pin 86) terminal to H.
The clock signal is output from the PCL terminal IC601(Pin 37).
The frequency of the clock signal is 468 750 Hz that is one 32th of the fundamental frequency.
The clock signal should be 468 750 Hz (- 10 Hz, + 15 Hz)
If the clock signal out of the range, the Xtal (X601) should be replaced with new one.
38
DEH-P510UB/XN/UC
1
DEH-P510UB/XN/UC
5
39
The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Screw adjacent to mark on the product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions,apply as you think it appropriate.)
"
9.1 PACKING
DEH-P510UB/XN/UC
DEH-P510UB/XN/UC
DEH-P5100UB/XN/UC
DEH-P5150UB/XN/ES
DEH-P5150UB/XN/ES1
DEH-P5190UB/XN/ID
40
DEH-P510UB/XN/UC
1
Description
Polyethylene Bag
Battery
CEX1065
CXC8885
12
Accessory Assy
13
Screw
14
Polyethylene Bag
CEG1160
Cord Assy
Cord Assy
Part No.
Unit Box
Contain Box
15
Handle
CND3707
QHP3002
16
Bush
QHP3003
17
Screw Assy
18
Polyethylene Bag
CEG-127
19
Screw
CRZ50P090FTC
Screw
TRZ50P080FTC
Protector
Protector
7
8
Description
11
Mark No.
Part No.
20
21
Case Assy
QXA3129
CRP1387
22
Screw
*
*
*
No.
Description
2
5
6
7
10-1
Polyethylene Bag
Cord Assy
Unit Box
Contain Box
Owner's Manual
CEG1173
QDP3003
QHG3033
QHL3033
QRD3026
CEG1173
QDP3003
QHG3034
QHL3034
QRD3027
QEG3001
QDP3004
QHG3035
QHL3035
QRD3028
QEG3001
QDP3004
QHG3039
QHL3039
QRD3028
QEG3001
QDP3004
QHG3036
QHL3036
QRB3025
10-2
10-3
10-4
10-6
10-7
Owner's Manual
Installation Manual
Service Network
Caution Card
Warranty Card
Not used
QRD3030
Not used
Not used
CRY1280
Not used
QRD3031
Not used
CRP1386
CRY1276
QRD3029
QRD3032
Not used
Not used
Not used
QRD3029
QRD3032
CRY1251
Not used
CRY1250
Not used
Not used
Not used
Not used
Not used
11
12
13
16
17
Cord Assy
Accessory Assy
Screw
Bush
Screw Assy
YDP5026
*QEA3004
BPZ20P060FTC
Not used
YEA5072
Not used
*QEA3004
BPZ20P060FTC
Not used
YEA5072
Not used
CEA9954
Not used
CNV3930
CEA3849
Not used
CEA9954
Not used
CNV3930
CEA3849
Not used
CEA9954
Not used
CNV3930
CEA3849
22
Screw
Not used
Not used
CBA1650
CBA1650
CBA1650
Language
QRD3026
QRD3030
QRD3027
QRD3031
QRD3028
QRD3029
QRD3032
QRB3025
English
DEH-P510UB/XN/UC
5
41
9.2 EXTERIOR(1)
DEH-P510UB/XN/UC
DEH-P5100UB/XN/UC
DEH-P5190UB/XN/ID
B
B
DEH-P5100UB/XN/UC
DEH-P510UB/XN/UC
DEH-P5100UB/XN/UC
42
DEH-P510UB/XN/UC
1
Description
Mark No.
Part No.
Description
Part No.
23
L-Plug(5P)(CN591)
Screw
BSZ26P060FTC
Screw
BSZ30P060FTC
24
Holder
25
Heat Sink
QNR3001
26
Pin Jack(CN302)
XKB7001
27
Holder
XNC7030
28
Fuse(10 A)
YEK5001
QDE3006
29
Chassis Unit
QXA3109
QNM3013
30
Button
CAC4836
31
Spring
CBH2367
32
Spring(Silver)
CBH2961
BPZ26P070FTC
33
Spring(Black)
CBH2962
Cover
CNN1665
CNV9311
Screw
BSZ30P200FTC
Earth Plate
CNC8915
Cushion
CNM8890
>
Cable
Insulator
Cord Assy
10
11
Screw
12
Screw
BSZ26P060FTC
34
13
Screw
BSZ26P200FTC
35
Arm
36
Arm
CNV9312
37
Panel
QNS3072
14
Plug(CN981)
CKM1376
15
Connector(CN701)
CKS3833
16
Connector(CN151)
38
IC(IC351)
PA2030A
IC(IC911)
NJM2388F84
Transistor(Q751, Q901)
2SD2396
41
Choke Coil(L981)
CTH1280
42
Screw
17
Connector(CN101)
CKS5271
18
Connector(CN801)
CKS6050
40
19
Antenna Jack(CN401)
CKX1070
20
Insulator
CNN2753
21
22
Holder
CKS4124
39
CWE2098
43
Holder
CND4324
44
Sheet
No.
Description
9
10
23
24
42
Cord Assy
Tuner Amp Assy
L-Plug(5P)(CN591)
Holder
Screw
YDE5047
QWM3065
KM200NA5L
QNC3007
Not used
YDE5047
QWM3064
KM200NA5L
QNC3007
BMZ40P140FTC
Not used
QWM3066
Not used
QNC3006
Not used
Not used
QWM3066
Not used
QNC3006
Not used
Not used
QWM3066
Not used
QNC3006
Not used
43
44
Holder
Sheet
Not used
Not used
CNV7619
Not used
Not used
Not used
Not used
Not used
Not used
CNM9404
* Sheet (No.44: CNM9404) is NOT reusable. If you remove it, please replace it with the new one.
DEH-P510UB/XN/UC
5
43
9.3 EXTERIOR(2)
A
44
DEH-P510UB/XN/UC
1
Description
Mark No.
Part No.
Description
Holder
CND3598
CXC8885
19
Spacer
QNM3017
CNS7068
20
Holder
QNV3013
21
Jack(CN1821)
YKN5006
22
Connector(CN1851)
YKS5032
See Contrast table (2)
Cover
Cord Assy
Panel
QNS3073
Detachable Assy
Screw
Grille Unit
Door(USB)
QAT3001
25
Knob Unit
26
Spring
XBL7005
27
Case
YNB5014
QNS3071
28
Remoto IC(IC1931)
GP1UXC14RK
Button(SRC, BAND)
QAC3026
QAC3027
Spring
CBH2210
Button(EJECT)
QAC3024
10
Button(DETACH)
QAC3025
12
Lighting Conductor
QNV3010
29
13
Lighting Conductor
QNV3011
30
Button(LIST, DISP)
14
Connector(CN1961)
CKS6036
15
Connector(CN1801)
CKS6049
31
32
Cushion
CNM8673
33
Lighting Conductor
QNV3009
MXS8281
34
Cushion
QNM3019
16
17
OEL Module
23
*
BPZ20P100FTC
Cover
QNC3005
24
11
Holder
Part No.
18
QNM3011
No.
Description
4
6
23
25
Cord Assy
Detachable Assy
Grille Unit
Knob Unit
QDP3003
QXA3115
QXA3094
QXA3104
QDP3004
QXA3117
QXA3095
QXA3104
QDP3004
QXA3117
QXA3095
QXA3104
QDP3004
QXA3120
QXA3096
QXA3104
DEH-P510UB/XN/UC
5
45
27
19
(1)
19
29
13
48
20
5
19
57
(1)
66
16
13
(1)
25
54
44
23
(1)
31
9
44
(2)
58
15
73
72
60
69
21
(2)
46
70
71
33
38
39
62
70
4
36
40
28
32
4
(1)
(2)
18
61
49
(1)
6
64
8
51
53
52
(2)
45
12
(1)
(1)
47
17 35
37
14
41
50
(1)
(2)
(1)
(1)
63
68
(2)
(1)
65
55
(2)
(1)
59
51
(1)
43 10
(1)
56
74
3
(2)
(1)
22
34
(1)
(1)
19
(1)
(1)
26
11
42
24
(1)
(1)
(1)
30
19
67
24
(1) : GEM1024
(2) : GEM1045
46
DEH-P510UB/XN/UC
1
Description
Mark No.
Part No.
Description
Part No.
50
Rack
CNV8342
Roller
CNV8343
CNV8344
Connector(CN101)
CKS4808
Connector(CN701)
CKS5854
51
Screw
BMZ20P025FTC
52
Holder
BSZ20P040FTC
53
Arm
CNV8345
54
Guide
CNV9498
55
Arm
CNV8348
CNV8349
5
6
Screw
Screw(M2 x 3)
CBA1511
Screw(M2 x 4)
CBA1835
Washer
CBF1038
56
Arm
CNV9499
57
Arm
CNV8350
CBH2609
58
Clamper
CNV8365
59
Arm
CNV8386
60
Guide
CNV8396
9
10
Roller
Spring
11
Spring
CBH2612
12
Spring
CBH2614
13
Spring
CBH2616
61
Arm
CNV8413
Collar
CNV8938
14
Spring
CBH2617
62
15
Spring
CBH2620
63
Motor Unit(M2)
CXC4026
64
Arm Unit
CXC4027
65
Chassis Unit
CXC4028
16
Spring
CBH2855
17
Spring
CBH2937
18
Spring
CBH2735
66
Gear Unit
CXC4029
Frame Unit
CXC4031
19
Spring
CBH2854
67
20
Spring
CBH2642
68
Motor Unit(M1)
CXC7134
69
Screw Unit
CXC6359
70
Screw
JFZ20P020FTC
21
Spring
CBH2856
22
Spring
CBH2857
23
Spring
CBH2860
71
Screw
JGZ17P022FTC
Washer
YE20FTC
24
Spring
CBH2861
72
25
Spring
CBL1686
73
Pickup Unit(P10.5)(Service)
CXX1942
74
Screw
IMS26P030FTC
26
Arm
CND1909
27
Frame
CND2582
28
Bracket
CND2583
29
Arm
CND3831
30
Lever
CND2585
31
Arm
CND2586
32
Bracket
CND2587
33
Arm
CND2588
34
Lever
CND2589
35
Holder
CNV7201
36
Gear
CNV7207
37
Gear
CNV7208
38
Gear
CNV7209
39
Gear
CNV7210
40
Gear
CNV7211
41
Gear
CNV7212
42
Rack
CNV7214
43
Arm
CNV7216
44
Roller
CNV7218
45
Gear
CNV7219
46
Guide
CNV7361
47
Gear
CNV7595
48
Guide
CNV7799
49
Arm
CNV7805
DEH-P510UB/XN/UC
5
47
Q751
2SD2396
DM
R765 5R6
R771 5R6
R766 5R6
R772 5R6
1
C506
C505
220/16
EN
GND
INV
6
SW
FB
5
VIN
RT
C503
220P
R506
C504
82K
C553
NM
/OC
3
EN
GND
BD6538G
VOUT
1
A8V
USDP1
USDM1
US GND
US5V1
IC761
USB5V
FLG2
US5V2
BD6538G
NM
C573
EN
GND
/OC
VOUT
VIN
IC571
C572
C571
C761
10/16
75K
33K
US GND
USBCTL2
L571
NM
10
3A
13K
3B2
GND
3R9K
2A
11
R780
3B1
13
R781
2B2
14
12
R774
4A
TC7MB3257FK
A,B
CN591
4B2
2B1
A,B
USB IF2
USOE
US5V2
15
R782
4B1
1A
USSEL
L761
R783
3R9K
OE
1B2
NM
75K
33K
13K
1B1
1K
R779
16
Vcc
R778
R775
75K
R767
R761
75K
R768
R762
33K
R763
13K
R764
3R9K
4
5
R769
NM
USGND
2
3
R770
PGND
USSEL
USOE
33K
NM
AGND DGND
L702
R507
R01
12K
D501
C502
SW USB
C706
USGND3
R508
30K
FLG1
USBCTL1
VIN
C,D,E
DP
USB IF1
CDGND
PGND
1
C554
NM
RB060L-40
R1
C507
0R0
CDR
C705
150/6R3
R505
470P
R501
470 (1/10W)
33K
R504 C501
1K
US5V11
L551
NM
CDR
AGND
CDL
GND
IN
R47
US5V1
CDL
IC551
NM
US GND
US GND
8R2K
L701
R502
394.74 kHz
441.18 kHz
US GND
USB5V
C552
CDVDD
R776
R01
CDRST
13K
USGND
C733
1K
R777
C732
R709
DM 3
USGND
C731
22/6R3
CDRST
BRST
3R9K
BDATA
0R0
DP
220
DGND1
GND 6
PGND
R708
R773
4R7K
BDATA
BSRQ
100K
BRXEN
47K
R703
BSCK
220
C551
GND 10
AGND
R702
220
R707
SYNC Freq.
USGND
L501
VDD 11
LOUT
220
R706
RESET 12
ROUT
OUT
R047
220
R705
BRXEN
BDATA 13
CD/USB
:+0.6 dBs
D751
C753
R704
BSCK
R1
GND
BRST
BRXEN 14
SYNC
USB5V
MECHA
3.3VREG
NM
BRST 16
CN701
USGND
BRSQ
BSRQ 17
BSCK 15
R503
VD 18
Detailed page
A-b
DGND
IC501
C703NM
C701
A-a
VD
VD 19
D502
1SR139-400-TA
BD9781HFP
VDD
3.3V
GND
C704NM
CN701
IC731
NJM2885DL1-33
560
5 (1/4W)
6
VDCONT
MECHA
HZU7R5(B3)
100/16
R001
C752
C751
Guide page
BUP
USB 5V
VDCONT
R751
NM
R701
A-b
C702
A-a
BUP
Q752
RT3T22M
34
USBCTL2
SYNC
MECHA VD
VD2
7.4V
FLG2
A-a
Large size
SCH diagram
A-b
FLG1
A-a
USBCTL1
US GND
US GND
US5V2
US5V2
RCK
47K
RCK
R631
100K
LDET
SYNC
OELPW
BRXEN
2R2K
USBCTL2
41
ILMPW
NC(RWCE)
45
USBCTL1
46
TUNPDI
47
TUNPDO
15
17
18
16
NC
RCK
20
19
RX2
OELPW
LDET
NC
VCC
61
100K
ROT0
R629
R628
50
TUNPCK
NC
NC
SACLK
49
60
48
680
59
NC
44
58
VDCONT
43
A,B
C,D,E
SACLK
42
BRXEN
SYNC
NC(RWEPM)
40
R604
DPDT
47P
C651
SWVDD
39
NM
1K
KEYAD
R152
1K
KEYD
FLG2
NM
IPPW
KYDT
1K
DSENS
R116
ILMGND
DGND
6
5
ROT1
OEL+B
DPDT
KYDT
2
1
2R2K
R807 2R2K
USGND11
OELG
R808 NM
SWVDD
OELGND
SWVDD
USGND
4
3
R805 2R2K
R806
US5V12
ILMGND
L841
DGND
ILMDGND
GND
GND
D805
2
1
MC2850-11
ILM GND
DEH-P510UB/XN/UC
2
5.1V
Q841
LSA1576UB
NM
VDD
R843
DGND
1K
SWVDD
NM
NM
NM
OELGND
R804
R842
OELGND
R802
R803 2R2K
D801
USGND
10
ROT0
USDP1
R841
KYDT
11
USDM1
NM
US5V
12
C842
6
5
4
DPDT
13
ILM+B
R047
OEL+B
14
C841
ROT1
15
MC2848-11
USDP
16
MC2846-11
10
ROTO
17
D808
11
USDM
18
D809
RESET
MECHA
MECHA VDD
MECHA VD
SW USB
GRILLE
ILM+B
SWVDD
OEL+B
VDD
SYS+B
ASENS&BSENS
ISENS
B.REM
AANT
TEL IN
SOURCE CONNECTOR
12
ILM+B
US5V1
R801 2R2K
MC2848-11
CN1801
13
AUXR
DSENS
19
MC2846-11
AUXG
NC
20
D806
15
AUXL
D807
18
GND
DSENS
D804
19
NM
20
R811
CN801
USDP1
VDD
GRILLE
D803
GND
RX
R810
BUS-
TX
D802
DIN2
NM
ROUT
BUS+
EZJZ1V800AM
DIN1
VCC
NM
STBY
100K
USDM1
IC101
HA12241FP
C104
C601
IN
NM
C407
GND
C453
100/16
C406
OUT
R01
4R7
KEYAD
R151
R809
NM
L101
62
R101
1K
VDD
C103 R001
38
GND
14
PCL
BUSL-
16
48
NM
ROT0
37
BUSL+
R114
17
CK
GND
1
KEYD
GND
2
3
BUSR-
IP-BUS:+2.2 dBs
100
6
C102 R001
C101R1
100
R107
180
R103
CN151
GND
BUSR+
R105
R632
ROT1
36
VDD
Q102
LTC114EUB
180
R102
BUS1
R108
R106
BUSL1
BUS2
5
4
BUS+
1K
7
6
R113
BUSR2
ASENB1
8
L+
BUS-
BUSL2
BUSR1
4R7K
CN101
1K
DI
DO
WIRED REMOTE
BUP
ASENBO
22K
R603
GND
BUP
R117
R115
IP-BUS
R+
R01
2R2K
D452 NM
RF GND
Q101
LSA1576UB
R104
TUNER3V REG
D451 NM
RST1
1K
D151
RF GND
3
C452
1
2
3.3V
C451
22/6R3
C404
ZNR401
L401
GND
USBCTL1
R652
S-80835CNNB-B8U
IC451
NJM2885DL1-33
CN401
R602 100K
OUT
1
VSS
4
L402
IMSA-6801-01Y901-T
AM_ANT
RFGND
AMANT
VDD
2
RST1
A8V
FMANT
10
R608 100K
IC651
NC
3
NM
SL
1K
18K
CE2
R607
ILMPW
R651
CK
CE1
680
VDD
D651
NM
680
R-
RESET
NC
35
EMUTE
USBCTL2
680
PCL1
R601 100K
DO
R407
RF_GND
11
ROT1
ROT0
SY
NC
680
R406
TUN8V
NC
34
NC
R403
R405
NC(RWBUSY)
33
DI
R404
SL
NC(RWCLK)
32
SWVDD
NM
CE1
VCC
31
RWBUSY
BSRQ
RX
TX
DPDT(RWTX)
NC
680
CK
FM_ANT
L-
47/6R3
R01
R01
R401
CE2
SL
KYDT(RWRX)
RWCLK
468.75kHz
30
VDCONT
ILM GND
SP601
CPV1062
29
L404
WC 7
CE2 6
CE1
PEE
RFGND
DI
DI 10
CK 9
1K
28
KYDT
NM
LDET
R618
D152
OSCGND 12
LDET 11
C405
NM
C402
C403
C401
DGND
NM
C408
DO
TUN5V
DO 14
ROM_VDD 13
22K
X-2026
COMP 16
DGND 15
L403
TUN3V
17
27
DPDT
57
R-DA
R-CK
26
56
R-LOCK
RDS_DATA 19
RDS_CK 18
VDD_3.3
AGND
22K
CWE2098
R-HSLK
RDS_HSLK 21
RDS_LOCK 20
BSRQ
RX
TX
55
GND
54
NM
FM(30%):-24 dBs
AM(30%):-24 dBs
L-CH
ROT1
R-CH
Rch 24
Lch 23
BEGND 22
GND
NM
VDD
Y401
21
R644
22
BRST
PEE
ROMCK
NM
EMUTE
GND
ROMCS
R643
23
DO
R642
NM
24
GND
25
SK
DI
NC
NC
TEST
PEE
TUNER
CS
VCC
NM
C641
TUNL
BRST
TUNR
NM
ROMDATA
100K
C602
R641
FOR EPROM
IC641
A,B
GND
R609
ROM CORRECTION
VDD
USOE
US B 2
C H A R GE
CONNECT
USSEL
USB1
CONNECT
CHARGE
DISCONNECT
FLG2
53
L591
C610
USB REAR
CONNECTOR
NM
NM
R591
US GND
B1 Port
B2 Port
NM
OUTPUT,STATUS
A port
52
L
H
51
US S E L
L
L
100K
U S OE
USOE
USSEL
CONTROL
4
4R7K
NM
USGND21
4R7K
NM
R593
USGND22
R606
R592
USDP2
R605
USDM2
100K
EZJZ1V800AM
R645
GND (BLACK)
NM
D+ (GREEN)
NM
D592
VBUS (RED)
D- (WHITE)
D591
47K
Q842
LTC114EU
R308 22K
NM
NM
4R7K
FR
RR
R321
4R7K
RT3C99M
SWR
4R7K
R304
C304
10/16
39
C305
R305
10/16
39
22K
34
5
R323
4R7K
R312
Q303
2
RT3C99M
R324
R306
39
4R7K
RL
R314 0R0
SWR
SWR
R316 0R0
SWL
SWL
FR
FR
FL
FL
RCAGND
3
4
5
6
GND
GND
GND
GND
1
(3A)
C306
10/16
RL
BUSR-
BUSR+
TUNR
AGND
CDR
AUXR
C255
R1
AGND
CN302
RR
RR
R322
33
22K
FL
R310
Tout_RR
SVin_RR
Tout_PreR
RL
RCA OUT
NM
Q302
C310
39
22K
R303
NM
39
C303
10/16
R311
10/16
C311
SWL
NM
GND
C312
100P
NM
C223
AGND
4R7K
R302
C302
C308
22K
R309
C309
R319
C216
32
R320
5
6
22K
R242
1
6
RT3T22M
2
1
31
RT 3 C9 9 M
Q3 0 1
3
C313
C224
10/16
SVin_FR
Tout_FR
IN4-_R
39
R313
R22
C243
C241
47/16
R1
C242
C221
AGND
42
30
28
27
R301
C214
C218
C301
10/16
34
43
VP PGND 41
Pref
40
PRE/SW_L
39
Rear_L
38
Front_L
37
Front_R
36
Rear_R
35
PRE/SW_R2
34
PRE/SW_R1
29
IN4+_R
IN3_R
Q242
3
SVin_RL
Tout_RL
Tout_PreL
C215
C217
C219
4
IN4-_L
Tout_FL
SVin_FL
C213
C211
C209
23
C206
C2101
C2081
10/16
AGND
IN2_R
Vref
22
R1
47/16
C202
R47
Noise_DET_out
DC_filter
MIC_in
IN1_R
GND
20
21
Vcc
19
C205
DATA
18
R201 1K
C212R22
L201
26
A8V
OELB
Q241
2SD1767
44
SVin_PreL
IC201
PML017A
CLK
17
STB
16
C222
MUTE
15
14
DGND
IN2_L
SA_clk
C220
13
25
100
R203
SA_out
IN4+_L
12
24
R202 100
IN1_L
11
DGND
10
47P
IN3_L
C207
C203
1R5K
VP12V
12.2V
R22
1
MC2850-11
EVOL VP+B
E.VOL
C201
SYSPW
BUSL-
VDD
D201
3
D241
HZU13(B1)
TUNL
BUSL+
AUXL
CDL
SAOUT
VST
SACLK
VCK
EMUTE
VDT
USBCTL2
USBCTL1
FLG2
A-b
10
P301
RXEF075P
(Poly SW)
2
C314
D301
BUP
22/16
C307
FL
FR
RL
RR
SWL
NM
6
1
RT3T22M
AMP
AGND
AGND
RL-
1K
RR
10K
RL
C363
FL
NM
(2125)
C367 NM
R621
GND
MUTE
2R7K
MC2848-11
D383
R363
C351
C356
100
NM
R365
330
10K
0R0
R384
R47
C362
2R2
2R2
FR+
AGND
FR-
Q352
LTC114EUB
C365
R1
FL+
FL-
3300/16
AGND
GND
105
TAB
PGND2
RL-
STBY
RL+
VCC
RR-
PGND1
RR+
10
SVR
11
RRIN
12
RLIN
13
AGND
14
FLIN
15
FRIN
16
ACGND
17
FR+
18
PGND3
19
FR-
20
VCC
21
FL+
22
MUTE
23
FL-
24
PGND4
25
B.REM
BUP
0R0
R627
RWCLK
KYDT
RWKYDT
DALMON
DALMON
3
4
R625 R626
0R0
NM
0R0
0R0
100K
NM
100K
NM
NM
0R0
C,D,E
RST1
CNVSS
DPDT
RWDPDT
1SR139-400
D941
BUP2
6
1
RT3T22M
C941
R047
>
BUP1
YEK5001
16
GND2 GND1
GND
15
GND
14
GND
DALMON
ILL1
BRE1
9
10
TEL1
GND
R984
RL-
RL-
FL-
FL-
RL+
RL+
FL+
FL+
RR-
RR-
FR-
FR-
RR+
RR+
FR+
FR+
B.UP
16
10A
GND
15
ACC
14
13
13
12
12
11
11
10
10
ILL
B.REM
TEL
RLFLRL+
FL+
RR-
FRRR+
FR+
C981
AUXL
AUXR
R1
ILMPW
1K (1/4W)
R983
BUP
SWVDD
1SR139-400
D942
D982
D981
1SR154-400
1SR154-400
C904
680
R902
R903
680
GND
RWCNVSS
SOURCE
CONNECTOR
CN981
ACC1
R627
NM
NM
34
B.REM
L981
600uH
5
6
VDD2
1500/16
RWBUSY
RWCLK
BUP3
D902
1SR139-400
Q902
UDZS5R6(B)
100K
R624
0R0
R625
NM
VDD
Q901
2SD2396
R901
8.4V
RWBUSY
VDD1
5.2V
SYSPW
SYSPW
CN601
VDD
VDD
D901
VST
C903R01
VDT
76
8V
C902R1
77
A8V
VCK
BSENS&ASENS
OUT2 7
IN2+
NJM2794V
ISENS
GND
C931
R931
D931
10K
1SS355
VDD
TEL IN
R962
Q851
2SD1760F5
R1
D852
IC851 NJM2360AM
6
1
RT3T22M
DGND
OEL GND
NM
(1/4W)
180
R857
R858
D961
MC2848-11
R964
4R7K
L961
15K
C961
R961
TELIN
Q852
HZU10(B1)
INVIN
R855
1K
7 (1/10W)
C858
GND
NM
V+
C857
SI
100/16
CD
ES
Q961
LSA1576UB
BUP
9.4V
C856
C854 330P
CS
CT
R1
2
3
C855
R01
R852
GND
1
1
C853
(3216)
15K
NM
OEL9V
R856
Frq=72kHz
R854
Q842
LTC114EUB
R853
47/25
NM
47K
C851
1K
R842
NM
NM
C842
R841
R047
C841
MC2848-11
R843
1R3K
5.1V
L852
D851
NM
Q841
LSA1576UB
NM
RB551V-30
15.5V
L851
R851 NM
L841
VDD
OEL+B
C852
SWVDD
D922
HZU6R8(B2)
ISENS
Q931
LTC114EUB
ILM GND
GND
OELB
47K
GND
ASENS
R1
10K
FM:+21.1 dBs
AM:+21.1 dBs
IP-BUS:+36.3 dBs
CD/USB:+35.7 dBs
AUX:+36.3 dBs
4R7K
R922
BSENS
R923
3
4
RT3CLLM
2
5
1
Q921
6
R824
47K
UDZS7R5(B)
R925
NC3
D921
100K
22K
1
6
RT3T22M
120
120
(1/10W)
C187
NM
R825
IN2-
Q822
34
R823
V+ 5
NC2 6
R047
GND 3
4
Vref
D821
NC4
R821
IN1-
22/16
NC5
11
C821
IN1+
C186 10
GND
BSEN1
R921
C921
BSEN2
BUP
180
ILM GND
13
C185 12
R001
NM
C189
22K
4700P
R183
R185
22K
C183
R181
4700P
R184
C182
NM
C188
180
AUXR
R186
R822
9.3V
OUT1 1
NC1 2
Q821
2SD1767
HZU10(B1)
C184 14
R1
C181
AUXG
R182
ILM+B
A8V
IC181
R924
ASENS
AUX
AUXL
MC2846-11
ROT0
ROT1
C361
33/10
2R7K
R361
2R7K
R359
2R7K
R356
D382
MC2848-11
22K
R364
10K
22K
SYS+B
IPPW
ROMDATA
ROMCK
BSENS
ASENS
ROMCS
C360
R47
R47
C366
85
ISENS
ASENBO
DGND
CE1
C359
R362
Q351
LTC114EUB
22/16
100K
R623
100K
CE2
R47
IC911
NJM2388F84
100K
R619
DALMON
RDT
RDSLK
RDS57K
SACLK
EMUTE
USOE
10/16
R47
AGND
BUP
RR+
GND
78
R612 4R7K
100K
R629
C358
Q381
2SC3052-12
C901
ROMDATA
47K
R624
FLG2
R47
AGND
R617
USSEL
100K
STEST
86
GND
C353
C355
MUTE1
R383
100K
75
ROMCS
ASENS
73
72
71
TUNPCE1
TUNPCE2
NC
69
68
70
DALMON
67
66
RDT
RDSLK
65
NC
VSS
NC
VCC
NC
SACLK
RDS57K
64
63
62
61
60
59
NC
USSEL
USOE
54
51
53
FLG2
50
52
49
VCK
VDT
VST
BUP
KEYAD
MUTE2
FLG1
ISENS 81
ASENBO 80
IPPW 79
TUNPCK
NC
NC
58
TUNPDO
48
EMUTE
TUNPDI
47
57
USBCTL1
46
ROMCK
NC(RWCE)
BSENS
44
D381
HZU8R2(B2)
MODEL0 83
MODEL1 82
74
NC
SAOUT
10K
R382
R630
VDCONT
R354
NC 88
FLG1 87
MUTE 85
NC 84
43
45
SYSPW
4
NC
NC
AMPM
6
BYTE
CNVSS
TELIN
RESET
ANTPW
10
11
XOUT
12
14
13
XIN
NMI
VSS1
VDD1
15
17
18
19
16
NC
RCK
LDET
KEYD
R620
4R7K
47K
ILMPW
SAOUT 90
KEYAD 89
22K
R357
MUTE
DSENS
R381
41
R622
TESTIN
2125SIZE
C357 R47
MUTE3
A8V
VIN
USBCTL2
MUTE
CDRST
CSRST 92
DSENS 91
GND
40
A,B:PEG509A8
C,D,E:PEG576A8
ASLIN
VOUT
NC(RWEPM)
VDD
AVSS 94
ASLIN 93
100/25
105
39
SL
CTRL
SWVDD
100K
RX2
PCL
38
42
20
ROT0
95
SL
IC601
NC
37
ROT1
NC
36
SYS.MICRO
47K
NC
96
VREF
R47
C354
R01
34
97
C352
RR-
B,C,D,E
AGND
AMPM
C913
NC
98
BSI
C912
33
BDATA
85
C911 100/10
NC(RWBUSY)
99
R911
32
BSCK
100K
NC(RWCLK)
100
R626
31
35
21
22
SYNC
KYDT(RWRX)
OELPW
BRST
30
DGND
RL+
(3216)
C364
1K (1/4W)
R615
VSS
AVCC
56
29
BSCK
BSO
55
28
BSRQ
RX
TX
DPDT(RWTX)
BRXEN
PEE
23
24
25
NC
27
IC351
PA2030A
R366
FR
26
RF GND
AGND
AGND
1R8K
1R8K
R360
1R8K
R358
1R8K
R355
4R7K
R353
4R7K
R352
R351
NM
C608
R01
C607
C606
10/16
R616
100K
SYSPW
KEYD
AMPM
TELIN
RWCNVSS
1K
GND
1K
R613 47K
Q304
R307
1SS355
SYSPW
R614
R611
0R0
VCC2
GND
AANT
RST1
RCK
LDET
47K
100K
RCK
R631
X601
20P C604
C603 20P
R610
SYNC
OELPW
BRXEN
2R2K
R609
BRST
PEE
NM
C602
15.000MHz
CSS1774
SWR
VDD
L601
5.2V
R1
1K
GND
NM : No Mount
OELPW
NOTE :
Symbol indicates a resistor.
No differentiation is made between chip resistors and
discrete resistors.
Symbol indicates a capacitor.
No differentiation is made between chip capacitors and
discrete capacitors.
GND
F
Decimal points for resistor
and capacitor fixed values
are expressed as :
2.2 t 2R2
0.022 t R022
DEH-P510UB/XN/UC
5
A
49
EMUTE
VST
C603 20P
X601
20P C604
15.000MHz
CSS1774
L201
SACLK
10
8V
100K
R631
16
VCC2
A,B:PEG509A8
IC601
100
AGND
R47
C205
R201 1K
R203
AGND
22
21
20
19
18
17
16
15
14
13
12
DGND
R1
47P
R202 100
SYS.MICRO
NC
47K
R610
15
NMI
14
VDD1
GND
Vcc
42
43
41
VP PGND
Pref
40
PRE/SW_L
39
Rear_L
38
Front_L
37
Front_R
36
Rear_R
35
PRE/SW_R2
34
PRE/SW_R1
SVin_PreL
44
C224
AGND
100P
C223
GND
Q241
2SD1767
BUP
SYSPW
MUTE
C304
10/16
R304
39
R303
39
R302
C352
5
6
Q302
96
97
98
93
NC 88
SAOUT 90
KEYAD 89
CSRST 92
DSENS 91
ASLIN
R622
22K
R630
R620
100K
10K
KEYAD
SAOUT
DSENS
CDRST
ASLIN
SL
BDATA
99
SL 95
AVSS 94
VREF
AVCC
BSI
BSCK
100
DGND
VSS
5.2V
GND
BUP
MUTE
AMPM
HZU8R2(B2)
D381
MUTE2
VDD
AGND
100K
R383
Q381
MUTE1
AGND
B,C,D,E
4R7K
R357
FR
10K
R362
330
R364
C355
C354
C353
R47
C359
C360
R47
R47
R47
100
R365
R47
C358
R47
Q352
LTC114EUB
MUTE3
R47
2125SIZE
C357 R47
AGND
2R2
2R2
C366
R1
C365
C362
C361
10/16
(3216)
C364
NM
(2125)
C367 NM
FL
R366
C363
AGND
RL
Q351
LTC114EUB
A8V
6
1
RT3T22M
10K
AGND
1K
Q304
4R7K
R324
RT3C99M
4R7K
R323
4R7K
R321
4R7K
R319
RR
1SS355
R307
39
10/16
D301
R306
C306
39
R305
C305
10/16
39
10/16
Q303
4R7K
R322
RT3C99M
4R7K
R320
RT 3 C9 9 M
Q3 0 1
3
SWR
RR
FR
FL
RL
SWL
C303
10/16
C302
39
VDD
AGND
R301
C301
10/16
L601
1
6
RT3T22M
34
Q242
OELB
34
10/16
VP12V
12.2V
EVOL VP+B
AGND
BSCK
BSO
BUSL-
IC201
PML017A
Noise_DET_out
DC_filter
MIC_in
DATA
CLK
STB
MUTE
SA_clk
SA_out
AMPM
VDT
13
XIN
R615
C201
R611
0R0
BUSR+
C203
C218
3
1
MC2850-11
SAOUT
RST1
IN1_R
AUXR
SYSPW
R1
TELIN
Vref
BUSL+
IN4+_R
E.VOL
C220
VDD
VCK
12
VSS1
11
XOUT
CDR
1K
47/16
C202
AANT
RESET
RWCNVSS
CNVSS
ANTPW
R613 47K
TELIN
1K
11
CDL
C207
TUNL
R22
C211
AUXL
C209
10
IN1_L
DGND
IN2_L
IN2_R
Tout_FR
C213
IN3_L
IN4+_L
IN4-_L
Tout_FL
C219
4
SVin_FL
Tout_RR
SVin_RR
Tout_PreR
SVin_FR
C241
28
IN4-_R
BUSR-
10/16
31
C215
C217
27
Tout_RL
1
32
C222
29
C221
3
SVin_RL
2
Tout_PreL
1
1
33
47/16
R1
C242
C606
30
IN3_R
TUNR
100K
R616
C255
D241
HZU13(B1)
C607
A-a A-b
R354
D201
10/16
SYSPW
R22
23
1R8K
R355
2R7K
R356
C206
C243
24
D383
A-b
R01
C2081
NM
C2101
D382
MC2848-11
C608
25
R614
BYTE
NC
R242
26
SYSPW
KEYD
1R5K
SWR
R351
SWL
4R7K
R352
22K
NC
RL
C212R22
R382
C307
C214
RR
4R7K
R353
1R8K
R358
2R7K
R359
R384
AMPM
FR
1R8K
R360
2R7K
R361
22/16
R309
22K
R310
22K
22K
R312
22K
C216
KEYD
FL
1R8K
2R7K
0R0
NM
MC2848-11
10K
DEH-P510UB/XN/UC
C351
C356
FL
FL+
FR-
FR+
RR+
RR-
RL+
RL-
RCAGND
FL
FR
SWL
RL
SWR
R314 0R0
R316 0R0
GND
GND
GND
GND
FL
FR
SWL
SWR
RL
RR
10
AMP
NM
C314
CN302
STBY
22
MUTE
FL+
VCC
21
FR20
PGND3
19
18
FR+
ACGND
17
FRIN
16
FLIN
AGND
15
14
RLIN
13
RRIN
SVR
RR+
PGND1
RR-
VCC
12
11
10
RL+
RL-
PGND2
2
3
TAB
1
IC351
PA2030A
RF GND
P301
RXEF075P
(Poly SW)
AGND
RR
RCA OUT
A:DEH-P510UB/XN/UC
B:DEH-P5100UB/XN/UC
C:DEH-P5150UB/XN/ES
D:DEH-P5150UB/XN/ES1
E:DEH-P5190UB/XN/ID
33/10
R363
R308 22K
22K
NM
C308
NM
C309
NM
C310
R313
NM
1
R311
50
C311
F
NM
E
C312
D
NM
C
C313
(3A)
1
4
A,B:PEG509A8
D,E:PEG576A8
VCC
RDT
AUXG
OELB
NM
L851
ILM GND
R182
180
R181
NM
180
AUXR
R186
AUXL
A-b
VDD
842
14EUB
7K
843
60
NC
61
VSS
62
NC
63
GND
RDS57K
15.5V
86
R617
13
11
D851
C,D,E
GND
CT
ES
CS
V+
SI
CD
INVIN
Frq=72kHz
L852
0R0
NM
NM
GND
A8V
R855
1K
7 (1/10W)
R856
OEL9V
R822
9.4V
GND
34
5
1
6
RT3T22M
Q851
2SD1760F5
Q852
1
6
RT3T22M
Q822
ILM+B
GND
RWDPDT
CNVSS
DALMON
RWKYDT
RWCLK
RWBUSY
ILM GND
Q821
2SD1767
DPDT
RWCNVSS
RST1
DALMON
KYDT
RWCLK
RWBUSY
VDD
10
NM
CN601
NM
R857
BUP
BUP
R858
(1/4W)
180
OELPW
BUP
TELIN
ISENS
BSENS
ASENS
DALMON
SYSPW
SYSPW
8.4V
A8V
D381
8V
MUTE2
AGND
IC911
NJM2388F84
HZU8R2(B2)
SYS+B
BUP
BUP
MUTE
MUTE
GND
MUTE1
D382
MC2848-11
4R7K
R357
VDD1
10K
Q901
2SD2396
AGND
10K
R362
MC2848-11
Q902
D922
UDZS7R5(B)
4R7K
GND
D961
MC2848-11
TEL IN
HZU6R8(B2)
GND
ASENS
D921
R1
C961
15K
R964
BUP3
Q352
LTC114EUB
MUTE3
R47
C360
D902
1SR139-400
100
R365
R47
C359
GND
L981
600uH
105
3300/16
C366
R1
C365
L961
DEH-P510UB/XN/UC
BUP
2R2
2R2
GND
AGND
C362
C361
NOTE :
Symbol indicates a resistor.
No differentiation is made between chip resistors and
discrete resistors.
1K
R961
BSEN1
R962
10K
R922
100K
R921
VDD
Q961
LSA1576UB
GND
BSEN2
R47
R47
AGND
VDD2
330
R364
BSENS&ASENS
1
6
RT3T22M
34
VDD
Q351
LTC114EUB
A8V
NM : No Mount
D931
1SS355
R931
ISENS
GND
5.2V
VDD
Q381
2SC3052-12
100K
R383
A-a A-b
GND
Q931
LTC114EUB
VDD
C355
C354
33/10
, , ,
FL-
FL+
FR-
FR+
BUP1
C941
RRFRRR+
FR+
RRFRRR+
FR+
R1
FLIN
FRIN
ACGND
FR+
PGND3
FRVCC
FL+
MUTE
FLPGND4
B.REM
14
15
16
17
18
19
20
21
22
23
24
25
GND
>
15
16
13
12
11
10
9
8
7
6
5
4
3
2
1
13
12
11
10
9
8
7
6
5
4
3
2
1
14
10A
YEK5001
14
15
16
CN981
FR+
RR+
FR-
RR-
FL+
RL+
FL-
RL-
TEL
B.REM
ILL
ACC
GND
B.UP
SOURCE
CONNECTOR
B.REM
FM:+21.1 dBs
AM:+21.1 dBs
IP-BUS:+36.3 dBs
CD/USB:+35.7 dBs
AUX:+36.3 dBs
FL+
FL+
RL+
FLFLRL+
RLRL-
TEL1
BRE1
ILL1
ACC1
GND2 GND1
BUP2
GND
GND
AGND
13
OEL GND
NM
100K
0R0
9.3V
0R0
NM
VST
VDT
VCK
IPPW
ASENBO
ISENS
MUTE
FLG1
KEYAD
SAOUT
DSENS
CDRST
R627
0R0
SL
ASLIN
R625 R626
OEL+B
OUT2 7
V+ 5
NC2 6
GND 3
4
Vref
OUT1 1
NC1 2
GND
DGND
100K
NM
R624
NM
NJM2794V
IN2+
NC3
IN2-
NC4
IN1-
NC5
IN1+
100K
47K
IC181
R623
R621
STEST
100K
10K
22K
IC851 NJM2360AM
C187
C186 10
C185 12
RB551V-30
NM
R185
100K
100K
R619
C184 14
AUX
76
ISENS 81
ASENBO 80
79
VCK IPPW
VDT
78
VST
77
MODEL0 83
MODEL1 82
MUTE 85
NC 84
TESTIN
R630
R620
SAOUT 90
KEYAD 89
NC 88
FLG1 87
R622
93
CSRST 92
DSENS 91
ASLIN
R624
CTRL
47K
47K
GND
R01
SL 95
AVSS 94
85
100/10
C911
R381
VOUT
C912
IC601
64
RDS57K
C851
85
R384
C903R01
SYS.MICRO
NM
SWVDD
RDSLK
R1
65
RDSLK
C181
66
RDT
TUNPCE2
69
TUNPCE1
70
CE2
ROMCK
74
ROMDATA
75
ROMDATA
100K
0R0
DALMON
67
R612 4R7K
DALMON
R626
AUXL
NC
68
47/25
C852
100K
0R0
R627
AUXR
ROMCS
(3216)
ILMPW
ASENS
71
ROMCS
C182
C183
CE1
NM
R851
R823
BSENS
72
4700P
R183
R852
4700P
R184
73
ASENS
R853
R854
HZU10(B1)
BSENS
22K
22K
15K
NM
1R3K
120
120
(1/10W)
ROMCK
R01
C853
C902R1
VIN
C913
R911
22/16
C901
0R0
C351
VREF
C854 330P
R824
NM
R825
1500/16
AMPM
D982
96
C921
NM
D901
1
6
UDZS5R6(B)
2
5
R625
R001
C188
47K
R821
NM
C857
22/16
R1
C855
R047
C821
R1
C189
100/16
C856
D821
D852
4R7K
R382
100/25
105
C931
22K
RT3CLLM
1SR154-400
97
R984
AVCC
1K (1/4W)
D383
R901
3
4
Q921
10K
R902
R903
R923
D941
D942
C356
C904
R363
680
R924
1SR154-400
R983
680
47K
D981
R1
R047
22K
1
7
C858
R925
22K
HZU10(B1)
1K (1/4W)
1SR139-400
1SR139-400
C981
5
8
51
USGND
USGND3
USGND
DM 3
DP
PGND 5
GND 6
LOUT
AGND 8
ROUT
GND 10
VDD 11
RESET 12
BDATA 13
BRXEN 14
BSCK 15
BRST 16
D- (WHITE)
D+ (GREEN)
GND (BLACK)
USGND21
Rch 24
Lch 23
DO 14
ROM_VDD 13
COMP 16
DGND 15
RDS_CK 18
VDD_3.3 17
RDS_LOCK 20
RDS_DATA 19
BEGND 22
RDS_HSLK 21
Y401
TUNER
GND
DO
TUN5V
TUN3V
R-CK
R-DA
R-LOCK
R-HSLK
L-CH
R-CH
NM
R593
AGND
DGND
US5V1
R766 5R6
R765 5R6
A,B
US GND
NM
R592
US5V2
USGND22
USDP2
USDM2
US5V2
USB REAR
CONNECTOR
NM
C706
AGND DGND
PGND
DM
DP
PGND
CDGND
CDL
AGND
CDR
DGND1
NM
NM
L404
L403
FM(30%):-24 dBs
AM(30%):-24 dBs
L591
R772 5R6
R771 5R6
C,D,E
GND
2A
2B2
2B1
1A
1B2
1B1
3A
3B2
3B1
4A
4B2
A,B
10
11
12
13
14
15
16
IC731
NJM2885DL1-33
1K
220
220
220
220
220
3.3V
L
H
L
L
H
US S E L
U S OE
CONTROL
OE
Vcc
4B1
TC7MB3257FK
IC761
SW USB
R709
CDRST
NM
R708
CDVDD
R707
BDATA
R704
BRXEN
BUP
560
5 (1/4W)
6
VDCONT
R751
R706
R702
BSCK
C705
D751
47K
R703
R047
C753
USGND
8
1
R001
DGND
7
2
R705
L701
C703NM
GND
C704NM
HZU7R5(B3)
100K
4R7K
Q752
RT3T22M
34
R779
NM
1K
VDD
DISCONNECT
CONNECT
CHARGE
USB1
OUTPUT,STATUS
B1 Port
B2 Port
A port
US GND
VDD
L761
MECHA
3.3VREG
R778
US5V2
USOE
USSEL
GND
OUT
MECHA VD
GND
C732
Q751
2SD2396
6
3
C H A R GE
CONNECT
US B 2
US GND
USOE
USSEL
CDRST
BDATA
BRXEN
BSCK
BRST
BSRQ
VDCONT
TUNL
TUNR
USDM1
USDP1
CDR
CDL
USB5V
USB5V
USB5V
R502
US5V1
470P
US5V11
L571
NM
US5V2
L551
NM
1K
2
NM
R644
NM
R643
ILM GND
DO
R642
NM
NM
SK
CS
DI
US GND
R618
GND
TEST
NC
VCC
SP601
CPV1062
FOR EPROM
IC641
100K
R641
ROM CORRECTION
GND
VDD
US GND
8R2K
L501
BD9781HFP
IC501
USB 5V
GND
USB IF1
US GND
INV
VD2
C731
22/6R3
US GND
USB IF2
PEE
ROMCK
ROMCS
ROMDATA
US GND
C505
USBCTL2
FLG2
PCL1
SWVDD
36
38
37
35
ROT0
34
ROT1
VDCONT
33
32
31
RWBUSY
30
KYDT
29
RWCLK
28
DPDT
26
27
FLG1
TX
468.75kHz
A,B
394.74 kHz
441.18 kHz
SYNC Freq.
BUP
USBCTL1
RX
BSRQ
USBCTL1
FLG1
USGND
SYNC
D502
1SR139-400-TA
220/16
7.4V
5
4
BRST
BRSQ
USGND
CN591
VBUS (RED)
CD/USB
:+0.6 dBs
CN701
VD 18
BSRQ 17
VD
NM
R47
100/16
R1
VD 19
L702
C701
MECHA
NM
10/16
C751
75K
33K
R761
R762
R763
R764
D591
NM
R773
0R0
R505
R503
IN
R01
0R0
R501
C641
C752
R767
R768
R769
R770
R780
NM
R701
NM
75K
33K
75K
33K
13K
3R9K
1
1
C733
R774
R775
R776
R777
75K
33K
13K
3R9K
R781
R782
R783
13K
3R9K
C761
150/6R3
C551
C571
1K
NM
D501
1
1
33K
R504 C501
C554
VIN
1
C552
C572
C502
RT
3
IC551
470 (1/10W)
NM
VOUT
VIN
1
5
VOUT
VIN
1
RB060L-40
R1
C507
GND
4
82K
12K
R507
R01
R508
30K
SW
2
R645
FB
GND
GND
IC571
220P
C504
C503
4
/OC
EN
3
EN
BD6538G
BD6538G
R506
NM
NM
C573
4
/OC
EN
3
1
C506
C553
NM
A-a A-b
4R7K
R605
SYNC
4R7K
R606
CN701
CWE2098
X-2026
C401
NM
FLG2
GND
C602
25
SYNC
R609
NC(RWBUSY)
NC(RWCLK)
KYDT(RWRX)
BSRQ
RX
TX
DPDT(RWTX)
SWVDD
PCL
ROT0
ROT1
NC
NC
BRXEN
2R2K
R591
C408
NM
NC
RCK
13K
C402
PEE
24
PEE
A8V
100K
R631
USBCTL2
BRST
23
BRST
22
BRXEN
21
SYNC
OELPW
20
OELPW
LDET
RCK
3R9K
NM
D592
R01
R01
19
RX2
18
RCK
47K
16
C603 20P
X601
20P C604
15.000MHz
CSS1774
L201
SAOUT
R1
A-b
SACLK
47/16
C202
A,B:PEG509A8
IC601
SYS.MICRO
NC
17
LDET
VST
11
C702
C403
C405
DEH-P510UB/XN/UC
47/6R3
13
XIN
R610
VDT
VDD1
15
NMI
VCK
12
VSS1
VCC2
14
EMUTE
C201
R611
0R0
XOUT
RST1
AANT
52
TELIN
A-a
R613 47K
F
10
E
9
D
8
C
RESET
B
3
ANTPW
A
2
TELIN
1
4
R+
BUS+
BUS-
L+
10
R-
11
L-
CN101
GND
RFGND
100
R102
BUSL1
ASENB1
BUSR1
BUSR2
BUSL2
BUS2
R407
R406
R405
R404
R403
R401
DGND
C401
C402
180
DIN1
GND
DIN2
ROUT
GND
R116
IC451
NJM2885DL1-33
RF GND
GND
Q102
LTC114EUB
3.3V
1K
IP-BUS:+2.2 dBs
22K
BUP
C451
22/6R3
BUS-
BUS+
VCC
STBY
R117
L402
NM
L404
IP-BUS
WIRED REMOTE
AUX IN
E.VOL
E.VOL VP+B
ASL
RCA
AMP
MUTE
TUNER
TUNER 3V REG
USB 5V
USB IF1
USB IF2
USB REAR
SYSTEM MICRO
ROM COLECTION
1K
R114
1K
R113
IC101
HA12241FP
180
R105
680
680
680
NM
680
680
Q101
LSA1576UB
R106
2R2K
R104
VDD
RF GND
CN401
L401
RFGND
AMANT
FMANT
TUN8V
SL
CE2
CE1
CK
DI
LDET
DO
TUN5V
IP-BUS
AM_ANT
RF_GND
FM_ANT
VCC
SL
WC 7
CE2 6
CE1
DI 10
CK 9
OSCGND 12
LDET 11
DO 14
ROM_VDD 13
COMP 16
DGND 15
R01
R01
CWE2
X-2026
NM
ZNR401
L403
100/16
C406
VDD_3.3
C101R1
47/6R3
NM
C407
TUN3V
4R7
RESET
MECHA
MECHA VDD
MECHA VD
SW USB
GRILLE
ILM+B
SWVDD
OEL+B
VDD
SYS+B
ASENS&BSENS
ISENS
B.REM
AANT
TEL IN
SOURCE CONNECTOR
D452 NM
TUNER3V REG
D451 NM
A8V
RX
TX
IPPW
ASENBO
SL
CE2
CE1
CK
DO
DI
11
12
13
14
15
16
17
18
19
20
A-a A-b
DGND
ILMGND
SWVDD
OELGND
OELGND
USGND
KYDT
US5V
DPDT
OEL+B
ROT1
USDP
ROTO
USDM
NC
ILM+B
AUXR
AUXG
AUXL
DSENS
10
11
12
13
14
15
16
17
18
19
20
GRILLE
CN151
CN1801 10
BUSL-
BUSL+
BUSR+
BUSR-
BUP
OUT
1
VSS
4
VDD
ILM GND
GND
1K
R152
KEYD
1K
KEYAD
R151
DGND
ILMGND
SWVDD
OELG
USGND11
KYDT
US5V12
DPDT
OEL+B
ROT1
USDP1
ROT0
USDM1
ILM+B
DSENS
GND
NM
NM
ILMDGND
OELGND
1K
R618
USGND
R808 NM
R807 2R2K
R806 2R2K
R805 2R2K
R804
R803 2R2K
R802
R801 2R2K
CN801
2
3
VDD
WIRED REMOTE
S-80835CNNB-B8U
VDD
2
NC
3
IC651
RESET
SP601
CPV1062
D651
17
R101
R103
62
100
C102 R001
IN
C452
OUT
R01
GND
C453
NM
1
DEH-P510UB/XN/UC
GND
GND
1K
R652
VDD
RST1
KEYD
KEYAD
RST1
PEE
CK
DO
DI
GND
D805
NM
R632
R603
US5V1
GND
1K
PCL1
680
R604
R602 100K
R607 1K
R608 100K
R601 100K
468.75kHz
ILM GND
VDD
MC2850-11
USBCTL1
ILMPW
USBCTL2
SWVDD
ROT0
ROT1
VDCONT
RWBUSY
RWCLK
NM
C408
L101
C104
BUS1
C103 R001
NM
C610
USDM1
R-DA
KYDT
KYDT
USDP1
NM
NM
NM
100K
R628
DPDT
C403
IMSA-6801-01Y901-T
R115
22K
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
TX
DPDT(RWTX)
TUNPDO
TUNPDI
USBCTL1
NC(RWCE)
NC
VDCONT
ILMPW
USBCTL2
NC(RWEPM)
SWVDD
PCL
ROT0
ROT1
NC
NC
NM
L841
TUNPCK
NC
NC
NC(RWBUSY)
NC(RWCLK)
KYDT(RWRX)
FLG2
DPDT
R629
R01
C404
22K
NC
C405
4R7K
R107
R108
NC
5.1V
DGND
A,B:PEG509A8
C,D,E:PEG576A8
IC601
SYS.MICRO
Q841
LSA1576UB
SWVDD
56
C651
D151
D152
R651
NM
NM
R809
GND
OELB
NM
L851
ILM GND
AU
AUXL
AUXG
A-b
VDD
Q842
LTC114EUB
47K
R843
NC
59
R-CK
18K
100K
D801
VCC
60
RDS_DATA 19
RDS_CK 18
NM
EZJZ1V800AM
NC
61
AGND
R810
D802
VSS
62
R-LOCK
NM
RDT
R-HSLK
R811
D803
NC
68
BEGND 22
RDS_HSLK 21
RDS_LOCK 20
100K
EZJZ1V800AM
47P
C601
D806
D807
ROT1
MC2848-11
ROT0
D808
D809
DSENS
MC2848-11
MC2846-11
MC2846-11
51
100K
R047
C841
FLG2
USSEL
52
USSEL
USOE
53
USOE
NC
54
NM
C842
55
NM
R841
SACLK
58
SACLK
1K
64
RDS57K
RDS57K
NC
63
SWVDD
EMUTE
57
EMUTE
R842
C851
DALMON
67
R612 4R7K
DALMON
RDSLK
65
RDSLK
C181
66
RDT
R1
47/25
NM
C852
5
8
A-a
53
D804
CN1851
USB
RE
1801~1810
USB5V
1
2
OELGND 5
AUXR
17
AUXG
18
AUXL
19
DSENS
20
R1
S1811
3
2
Phase_B 10
D8
3A
C7
4B
1 Phase_A
2 Enc_Com
Push 9
CN1821
JOYST
5 Com
GND 6
10K
AUX
ILM+B
R1818
ILM+B
16
GRILLE MIC
AUX:+2.2 dBs
2R2K
NC
15
R1819
14
1901~1930
1K
13
USDM
R1816
12
ROT0
USB
DPDT
1K
USDP
KEY&ILM
1851~1860
SWVDD 5.1V
33K
ROT1
11
AUX
KYDT
10K
9
10
2R2K
ROTARY C
1821~1830
2R2K
R1811
DPDT
OEL+B
R1801
R1802
1811~1820
1 8 3 1 ~1 8 5 0
10K
R1814
PUSH
ILMGND
R1812
JOYST(V)
over~under
0.00
0.33
0.86
0.33
0.86
1.52
2.44
1.52
2.97
2.44
3.30
2.97
SW
A(UP)
B(LEFT)
C(DOWN)
D(RIGHT)
PUSH
RELEASE
R1813
KYDT
US5V
ILMGND
ROTARY COMMANDER
ILM+B 9.3V
CN801
USGND
33K
R1803
OELGND 4
DGND
SWVDD
C1851
ILMGND
EZJZ1V800AM
SWVDD
EZJZ1V800AM
D1852
ILMGND
D1851
DGND
L1851
CN1801
CONNECT O
CSX1120
ILMGND
R1815
3R3K
DGND
OEL+B 15.5V
OELGND
KEY&ILM
SWILM
NM
DISPOFF
VDD 3.3V
SWVDD5.1V
ILM+B 9.3V
SWILM
R1833
KS1
Q1831
4
KS2
KS2
6 UMD3N 1
KS1
SMLE12BC7T(NP)
D1831
SMLE12BC7T(NP)
D1834
SMLE12BC7T(NP)
D1837
C1831
C1834
C1837
SWILM
NM
R1831
R1832
NM
KS0
ILMGND
ILMGND
NM
(Ta=25C,IF=5mA)
Type
Rank
"N"
14~22 mcd
"P"
22~36 mcd
CLOCK
LOC
SMLE12BC7T(NP)
D1832
SMLE12BC7T(NP)
D1835
SMLE12BC7T(NP)
D1838
C1832
C1835
NM
(NP)
S1837
CSG1155
S1834
CSG1155
EJECT
Part No.
SMLE12BC7T
NM
NM
2
1
S1831
CSG1155
KD0
C1838
NM
DPDT
NM
S1832
CSG1155
SOURCE
S1835
CSG1155
S1838
CSG1155
BAND
DISP
SMLE12BC7T(NP)
D1833
SMLE12BC7T(NP)
D1836
C1833
C1836
NM
KS0
KYDT
KD1
SMLE12BC7T(NP)
D1839
C1839
NM
NM
ROMCS
ROMCK
S1836
CSG1155
S1839
CSG1155
LIST
S.Rtrv
iPod
ROMDATA
KD2
OELGND
SMLE12BC7T(NP)
D1840
C1840
NM
2
NM
RO
KD3
S1840
CSG1155
R1845
R1838
LED
270
R1840
NM
Q1833
LTC123JUB
R1839
NM
Q1832
NM
NM
R1836
NM
R1837
C1961
680
1R5K
R1842
680
1R5K
R1841 3R3K
1R5K
1R5K
R1843
R1834
R1835
R1844
SW
DIM
F
ILMGND
B
54
DEH-P510UB/XN/UC
1
NM
OEL+B 15.5V
R1942
S1833
CSG1155
D11
5
KEYBOARD UNIT
GRILLE MICRO
100
R1911
100
D9
D7
5
D8
D6
6
D10
D5
7
D4
8
D3
5
D2
6
D1
7
R1912
8
1
D0
100
8
220
1K
R1908
DPDT
R1910
1
JOYST
KD3
KD2
R1907
DISPOFF
KYDT
GRILLE MICRO
ROM
1901~1930
KD0
OEL
1981~1990
KD1
3V REGULATOR
1 9 6 1 ~1 9 8 0
USB
ROMCK
1951~1960
KEY&ILM
ROMDATA
AUX
1851~1860
ROMCS
1821~1830
1 8 3 1 ~1 8 5 0
ROM CORRECTION
1941~1950
REMOT E
ROTARY COMMANDER
1931~1940
1811~1820
DIM
CONNECT OR
A:DEH-P510UB/XN/UC
B:DEH-P5100UB/XN/UC
C:DEH-P5150UB/XN/ES
D:DEH-P5150UB/XN/ES1
E:DEH-P5190UB/XN/ID
VDD 3.3V
GP1UXC14RK
IC1931
R1905
DGND
78
D8
D9 77
D10
76
NC12
35
O_SCLK
HOLD 36
NC13
37
RDY
38
NC14
39
HOLD
40
NC15
41
NC16
42
RD
43
NC17
44
NC18
45
NC19
46
CS2
47
CS1
48
CS0
49 A19
A18
50
O_SID
71
70
69
8
100
1
1
R1 9 1 6
8
68
A2
67
A3
66
D12
KYDT
D15
A1
A4
A5
64
A6
63
A7
62
A8
R1917
R1918
8
100
100
1
58
A10
57
A11
56
A12
55
A13
54
A14
53
A15
52
A16
60
C1903
59
R01
51
R1913
C
A9
R1919
100
DGND
A17
100
100
A19
ROMCE
CS1
CS2
10K
R1922
D14
47K
D13
65
VDD3.3V
D7
79
D6
80
81
D5
82
D4
D3
83
D2
84
86
85
D1
D0
NC20
87
88
NC21
JOYST
89
90
NC22
91
KD3
KD2
92
94
93
KD1
95
Vref
KD0
AVSS
96
AVCC
DGND
R1909
8
1
1
8
R1923
DGND
10K
47K
72
34
R1906
33
R1921 10K
R1901
DPDT
NC7
10K
A15
A16
A17
O_RST
R1927 10K
R1
KD0
25
A14
NC11
24
1SS355
C1902
A13
NC10
150K
D1901
A12
NC9
R1903
A11
32
DGND
1
1K
100
61
A9
TX
VSS2
A10
31
KS0
A7
VCC2
CLK
A6
A8
BUSY
A5
NC8
26
KS1
A4
f=2.6MHz
KS2
A3
30
R1904
KS2
A2
RX
KS1
A1
29
47K
R1902
A0
IC1901
PEG511A
R1915
73
74
D15
28
KS0
75
D11
D12
D13
D14
O_CIN
DPDT
KYDT
1
2
C1901
R01
VDD 3.3V
SWVDD5.1V
DGND
27
DGND
OFF
DIM
3 ROMOT
ROMCK
4
REM
5
ROMCS
CNVSS 6
BYTE
R1926
7
CNVSS
8
1K
NC2
9
RESET
NC3
10
RESET
11
XOUT
12
VSS1
13
XIN
14
VCC1
15
NMI
16
NC4
17
KS3
18
KS2
19
KS1
20
KS0
21
NC5
22
O_DC
23 O_CSB
REMOTE
X1901
CSS1616
16MHz
97
99
NC25
ILL
2R2
10
R1933
10K
R1932
C1931
98
100
NC
DGND
DGND
1 REM
2 GND
100
OYST
3 VCC
R1931
100K
R1920
R1914
DGND
RD
100
VDD3.3V
VDD3.3V
VDD3.3V
O_SCLK
O_SID
O_CIN
SWVDD5.1V
O_RST
O_DC
O_CSB
KD1
PD8184A :(A)
ROM IC1981 PD8185A :(B,C,D,E)
1
IC1951
IC1941
DGND
NM
R1
C1954
C1952
C1953
ILMGND
A6
A5
A4
A3
A2
10
A1
11
ROMCE
12
O_CSB
O_DC
O_SCLK
O_SID
4
R1965
R1966
RD
14
D0
15
D8
16
D1
17
D9
18
19
D10
20
D3
21
R1970
NM
NC2
A18
A19
A17
A8
A7
A9
A6
A10
A5
A11
A4
A12
A3
A13
A2
A14
A1
A15
A0
CE
Vss1
OE
A16
BYTE
Vss2
D15/A-1
D0
D7
D8
D14
D1
D6
D9
D13
D2
D10
D5
D12
D4
Vcc
44
43
CS2
42
A9
41
A10
40
A11
39
A12
38
A13
37
A14
36
A15
35
A16
34
A17
33
32
31
D15
30
D7
29
D14
28
D6
27
D13
26
D5
25
D12
24
23
D4
C1981
R01
DGND
NM
C1962
NC1
D3
22 D11
D11
1
f=2.6MHz
NM
R1964
R1971
C1965
NM
1
R1969
NM
NM
11.8V
CVCC
R1968
C1963
Q1962
NM
NM
R1963
CSB
VCC
AGND 1
4
RSTB
D6(SCLK) 6
D7(SDIN) 7
DGND 9
OEL UNIT
OSCIN
REGOUT 10
VCC 12
VDD 11
ROWOUT 13
AGND 15
DGND
ROWIN 14
NM
TH1961
NM
A7
D2
CN1961
OELGND
R1
NM
C1967
R1961
C1966
DIM
100
100
C1964
Q1961
NM
NM
R1962
NM
C1961
O_CIN
TP2
TP1
A8
13
OEL
L1961
(2R2)
100
KD3
A19
3V REGULATOR
DGND
ROM CORRECTION
VIN
VOUT
1
5
S-1200B33-M5
R1967
NM
VSS
O_RST
GND
CS1
L1951
2R2K
NC
R1
R1951
ON/OFF
NM
R1942
TEST
DO
NM
DC 5
DI
R1941 4
KD2
NC
3.3V
SK
ROMDATA
VCC
R1
CS
C1951
NM
NM
ROMCS
ROMCK
C1941
R1943 1
MXS8281
B
DEH-P510UB/XN/UC
55
C-a
PICKUP UNIT(P10.5)(SERVICE)
F
T
C
S
f
T
T
F
T
F
F
F
F
T
T
T
D
SWITCHES:
CD CORE UNIT(S10.5COMP2-IPOD-C3)
S901:HOME SWITCH.........ON-OFF
S903:DSCSNS SWITCH....ON-OFF
S904:12EJ SWITCH...........ON-OFF
S905:8EJ SWITCH.............ON-OFF
M1 CXC7134
SPINDLE MOTOR
S
S
M2 CXC4026
LOADING/CARRIAGE MOTOR
4
5
F
F
T
T
2
1
C
56
DEH-P510UB/XN/UC
1
C-b
C
CD CORE UNIT(S10.5iPod-Code3)
SIGNAL LINE
FOCUS LINE
TRACKING LINE
CARRIAGE LINE
SPINDLE LINE
F
T
C
S
B
b
CN701
C
DEH-P510UB/XN/UC
5
57
C-a C-b
58
SIGNAL LINE
FOCUS LINE
TRACKING LINE
CARRIAGE LINE
SPINDLE LINE
CD CORE UNIT(S10.5iPod-Code3)
1
2
C-b
DEH-P510UB/XN/UC
3
4
CN701
C-a C-b
C-b
DEH-P510UB/XN/UC
5
59
60
3
F
T
T
C
S
F
T
PICKUP UNIT(P10.5)(SERVICE)
C-a C-b
1
3
4
C-b
C-a
DEH-P510UB/XN/UC
C-a C-b
M2 CXC4026
LOADING/CARRIAGE MOTOR
M1 CXC7134
SPINDLE MOTOR
SWITCHES:
CD CORE UNIT(S10.5COMP2-IPOD-C3)
S901:HOME SWITCH.........ON-OFF
S903:DSCSNS SWITCH....ON-OFF
S904:12EJ SWITCH...........ON-OFF
S905:8EJ SWITCH.............ON-OFF
5
7
8
C-b
DEH-P510UB/XN/UC
C-a
61
C
S
10.4 WAVEFORMS
- CD CORE UNIT
1DSCSNS
28SNS
312SNS
4LOEJ
5 V/div
5 V/div
5 V/div
5 V/div
Note : 1. The encircled numbers denote measuring points in the circuit diagram.
2. Reference voltage REFO1(1.65 V)
500 ms/div 1DSCSNS
5CLCONT
4LOEJ
6VD
5 V/div
5 V/div
5 V/div
10 V/div
5 V/div
5 V/div
5 V/div
5 V/div
12 cm CD Loading operation
12 cm CD Loading operation
8 cm CD Loading operation
Ref.:
GND
Ref.:
GND
Ref.:
GND
Mode:
Normal
Mode:
Normal
Mode:
Normal
500 ms/div
7SIN
8CIN
9TIN
1 V/div
1 s/div
500 mV/div
1 V/div
0FIN
200 mV/div 500 ms/div @TE
!RFOK(MONI_3) 2 V/div
#FE
7SIN
2 V/div
Ref.:
REFO
Ref.:
REFO
Ref.:
REFO
Mode:
Normal
Mode:
Normal
Mode:
Normal
#FE
0FIN
@TE
9TIN
62
2 V/div
200 ms/div $MDX
500 mV/div
7SIN
2 V/div
5 s/div
500 mV/div
Ref.:
REFO
Ref.:
REFO
Ref.:
REFO
Mode:
Normal
Mode:
Normal
Mode:
Normal
0FIN
#FE
$MDX
7SIN
%RFAGC
@TE
9TIN
1 V/div
500 s/div
500 mV/div
500 mV/div
Ref.:
REFO
Ref.:
REFO
Ref.:
REFO
Mode:
TEST
Mode:
TEST
Mode:
TEST
DEH-P510UB/XN/UC
1
%RFAGC
@TE
9TIN
1 V/div
500 s/div
500 mV/div
500 mV/div
%RFAGC
@TE
9TIN
%RFAGC
@TE
9TIN
1 V/div
500 s/div
500 mV/div
500 mV/div
Ref.:
REFO
Ref.:
REFO
Ref.:
REFO
Mode:
TEST
Mode:
TEST
Mode:
TEST
%RFAGC
@TE
8CIN
7SIN
1 V/div
1 V/div
1 V/div
2 V/div
1 V/div
1 V/div
1DSCSNS
28SNS
312SNS
4LOEJ
200 s/div
5 V/div
5 V/div
5 V/div
5 V/div
12 cm CD Eject operation
Ref.:
REFO
Ref.:
AGND
Ref.:
GND
Mode:
Normal
Mode:
Normal
Mode:
Normal
1DSCSNS
5CLCONT
4LOEJ
5 V/div
5 V/div
5 V/div
5 V/div
5 V/div
5 V/div
5 V/div
1 V/div
1 V/div
1 V/div
1 V/div
8 cm CD Eject operation
Ref.:
GND
Ref.:
GND
Ref.:
REFO
Mode:
Normal
Mode:
Normal
Mode:
Normal
1 V/div
1 V/div
USB Play
50 ns/div
*DP
(DM
2 V/div
2 V/div
*DP
(DM
50 ms/div
500 ms/div
12 cm CD Eject operation
*DP
(DM
1 V/div
2 ms/div
500 mV/div
500 mV/div
2 V/div
2 V/div
500 s/div
50 ms/div
E
DEH-P510UB/XN/UC
5
63
*DP
(DM
2 V/div
2 V/div
50 ms/div
)CPRDY
SDA
SCL
2 V/div
2 V/div
2 V/div
)CPRDY
SDA
SCL
10 s/div
2 V/div
2 V/div
2 V/div
64
DEH-P510UB/XN/UC
1
DEH-P510UB/XN/UC
5
65
CN151
140
IP-BUS
D152
CN101
1
SIDE A
15
Capacitor
Connector
CORD ASSY
WIRED REMOTE
R151
D981
130
C941
R981
SIDE B
C981
D151
C101
R105
R108
R114
IC911
C913
120
C366
R102
R101
R103
P.C.Board
D982
R152
R113
R107
R106
Chip Part
10
L981
C912
R911
Q901
C953
C952
D901
R901
R902
C951
C903
D952
110
D953
D942
L961
Q902
IC951
R983
D922
R961
R925
D951
R924
R922
R921
R923
D902
R116
C104
IC101
L101
D961
90
C961
Q961
C921
R964
D921
C911
R962
R952
10
R951
R903
100
C904
C902
Q921
C901
D751
C753
Q752
80
R751
D502
Q751
C733
IC501
C572
R770
R769
R764
R763
R762
R761
R768
R767
R779
R778
Q821
1
L851
R810
D804
R803
20
CN801
10
20
30
40
50
60
DEH-P510UB/XN/UC
2
15
10
R808
R805
D803
66
R806
L801
D807
D806
D851
10
R811
D808
C851
R807
R851
D809
R809
C854
C852
R709
R707
C842
C841
R822
R821
R701
R703
R841
E
D802
Q822 D821
C706
D801
R824
R823
R825
C855
C705
IC851
20
L841
L702
C821
C501
R856
Q841
R771
R842
Q842
L852
5
R765
R804
R855
R854
R853
R852
C853
R843
C554
10
10
IC761
R773
Q852
CN
R702
R766
R772
R802
15
R781
R782
R783
C856
CN1801
C704
R780
R774
R775
R776
R777
D852
C858
C703
L551
R501
C752
C551
L761
R857
C552
C857
R858
C573
R503
R504
R502
C761
30
C751
L591
IC551
C502
Q851
C504
40
C732
L701
C553
C507
R506 C503
R505
C731
R508 R507
5 IC571
60
C571
C505
R593
L571
D501
50
D592
R591
L501
R592
D591
IC731
CN591
C506
USB
70
70
SIDE A
SY
IC351
10
CN302
20
RCA OUT
10
C365
C363
25
P301
D301
C362
R313
R306
R307
R362
C404
C216
VR251
C254
R253
C214
C406
L402
R202
R203
C407
R254
C206
C202
R407
C252
R406
R405
R404
C201
R403
R402
R252
733
D251
D201
R251
C203
C641
D651
75
70
1
R408
55
R708
R704
R706
R709
R707
R705
C401
1
Q402
R631
25
R701
R703
1
R642
R645
C609
L403
20
C704
Q401
C405 C402
R619
R617
R612
IC601
15
C752
03
C604
C603
R610
10
X601
C701
C403
R401
C408
65
C751
R614
R613
R611
L701
IC641
R643
1
R616
R641
R644
60
R652
C607
C702
100
C732
R615
95
C606
C731
L404
5
20
C651
R621
R627
R625
R624
R623
R626
C608
90
L601
85
R622
R620
R630
R651
80
IC651
15
IC731
C208
C255
R201
C212
C205
20
15
Q102
C210
C207
C218
IC201
L201
MIC251
1
10
C242
C219
C217
C215
C211
C213
C209
1
C243
D241
R964
R962
R104
R115
R117
C223
C251
C220
10
L101
D961
C253
Q242
25
IC101
951
C241
Y401
L401
C222
R961
C301
R351
C221
30
C104
C302
R352
Q241
E
R241
R242
C103
Q101
C224
35
C102
R358
R353
C351
C364
R116
ZNR401
R365
C356
40
C961
Q961
Q301
R381
R382
C314
R355
R360
R364
D941
R357
D942
L961
R383
D953
CN401
C303
C305
C307
R363
ANTENNA
R303
R305 1
R322
C304
Q304
C367
Q381
D381
R310
Q302
Q351
Q352
1
R324
C306
R302
C309
R359
R354
E
R384
D382
C353
R356
R361 C354
Q931
C931
D383
C355
R366
C352
R931
C310
R301
R320
R319
D931
R317
R316
R321
C312
R312
Q303
R309
C358
C359
R984
C357
C360
C313
R308
C308
C361
R304
15
R323
R314
R315
R311
C311
1
1
R629
C602
30
CN701
R702
R609
35
40
45
R606
R618
R605
50
R604
R632
C601
C610
C452
SP601
R628
R603
R602
15
R601
R608
R607
C451
C453
10
Q841
D451
L841
D452
L702
IC451
C705
C706
CN701
841
C189
D807
C181
R181
D805
R801
10
R184
R182
C183
15
R185
C182
R183 C187
C186
C185
C184
D802
D801
R809
R803
R805
D806
IC181
10
D808
R806
R811
CN601
C188
841
10
C842
R186
20
FRONT
CN801
70
80
90
100
110
120
130
140
150
160
170
DEH-P510UB/XN/UC
5
67
STEST
PCL1
A
68
170
160
150
140
130
120
110
100
DEH-P510UB/XN/UC
1
90
SIDE B
150
140
1
1
130
120
110
100
90
80
70
D
60
50
40
E
30
1
20
10
F
Y
90
80
70
60
50
40
30
20
10
DEH-P510UB/XN/UC
5
69
10
S1835
20
S1838
30
iPod
40
C1837
D1837
ROTARY
COMMANDER
S1811
5
10
D1840
50
LOC
S1837
SW
60
R1907
R1806
C1901
C1902
R1902
R1923
R1903
70
R1818
80
R1908
R1970 R1909
R1966
R1927
R1906
CN1961
90
R1965
C1962
C1964
C1963
C1961
100
Q1961
Q1962
E
R1920
C1967
110
R1917
R1913
R1918
R1963
S1839
C1839
E
D1839
D1836
S1840
R1962
D1838
S.Rtrv
S1836
C1840
TH1961
C1838
DISP
C1833
D1833
C1836
40
120
10
15
30
C1981
IC1981
35
R1922
130
20
25
USB
AUX
140
CN1821
CN1851
150
C1851
160
S1834
D1834
C1834
IC1931
EJECT
1
C1835
D1835
BAND
C1832
S1833
S1831
D1831
CLOCK
2
10
20
30
D1832
1
2
1
LIST
D
15
S1832
OEL UNIT
10
SOURCE
40
C1831
70
KEYBOARD UNIT
B
1
1
3
4
L1961
R1921
R1967
C1966
D1901
DEH-P510UB/XN/UC
30
95
100
R1904
R1905
D
1
15
35
40
45
50
C1903
55
60
90
IC1901
85
65
75
70
R1803
X1901
70
R1926 R1943
R1942 R1941
IC1941
CN801
CN1801
60
C1954
R1802
L1951
C1941 IC1951
R1804
C1953
R1805
R1901 C1951
50
R1801
5
C1965
80
R1910
80
R1951
C1952
40
C1811
E
C1812
30
R1816
R1814
R1819
Q1831
20
Q1832
R1834 R1835
R1813
R1812
R1815
R1817
R1831
C
R1916
R1911
90
R1811
R1833
R1969
R1961
100
R1844
R1845
R1843
R1841
R1840
R1838
R1839
R1842
10
R1837
Q1833
R1836
R1914
R1915
110
R1832
25
20
15
10
1
R1919
R1912
120
1
20
C1822
C1821
130
R1968
L1851
D1852
140
C1823
A
R1931
R1932
C1931
150
10
160
D1851
D1822
D1821
10
20
30
40
DEH-P510UB/XN/UC
71
SIDE B
KEYBOARD UNIT
8
7
6
5
R1933
R1964
R1971
CD CORE UNIT(S10.5iPod-Code3)
SIDE A
PICKUP UNIT(P10.5)
(SERVICE)
CN701
REFO1
F
E
HOME
M2
LOADING/CARRIAGE
MOTOR
M1
SPINDLE MOTOR
C
72
DEH-P510UB/XN/UC
1
CD CORE UNIT(S10.5iPod-Code3)
SIDE B
A
8EJ
12EJ
DSCSNS
C
DEH-P510UB/XN/UC
5
73
NOTE:
Parts whose parts numbers are omitted are subject to being not supplied.
The part numbers shown below indicate chip components.
Chip Resistor
RS1/_S___J,RS1/__S___J
Chip Capacitor (except for CQS.....)
CKS....., CCS....., CSZS.....
The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Meaning of the figures and others in the parentheses in the parts list.
Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding
PC board.
IC 301 (A, 91, 111) IC NJM2068V
The expression of the unit in this manual is shown by u instead of . Please do not make a mistake.
Circuit Symbol and No.
A:DEH-P510UB/XN/UC
B:DEH-P5100UB/XN/UC
C:DEH-P5150UB/XN/ES
D:DEH-P5150UB/XN/ES1
E:DEH-P5190UB/XN/ID
Unit Number : QWM3065(A)
Unit Number : QWM3064(B)
Unit Number : QWM3066(C,D,E)
Unit Name : Tuner Amp Assy
Unit Number : (A)
Unit Number : (B,C,D,E)
Unit Name : Keyboard Unit
Unit Number : CWX3678
Unit Name : CD Core Unit(S10.5iPod-Code3)
model
A:DEH-P510UB/XN/UC
B:DEH-P5100UB/XN/UC
C:DEH-P5150UB/XN/ES
D:DEH-P5150UB/XN/ES1
E:DEH-P5190UB/XN/ID
A
Unit Number : QWM3065(A)
F
Part No.
74
(A,77,92) IC
HA12241FP
Part No.
IC 181
IC 201
IC 351
IC 451
(A,104,19) IC
(A,115,94) IC
(A,105,140) IC
(A,151,29) IC
NJM2794V
PML017A
PA2030A
NJM2885DL1-33
IC 501
IC 551
IC 571
IC 601
(A,38,53) Regulator IC
(A,48,51) IC
(A,50,58) IC(A,B)
(A,121,54) IC(A,B)
(A,121,54) IC(C,D,E)
BD9781HFP
BD6538G
BD6538G
PEG509A8
PEG576A8
IC 651
IC 731
IC 761
IC 851
IC 911
(A,103,67) IC
(A,69,68) IC
(A,47,38) IC(A,B)
(A,39,22) IC
(A,6,122) IC
S-80835CNNB-B8U
NJM2885DL1-33
TC7MB3257FK
NJM2360AM
NJM2388F84
Q
Q
Q
Q
Q
101
102
241
242
301
(A,83,94) Transistor
(A,82,90) Transistor
(A,93,99) Transistor
(A,92,95) Transistor
(A,137,112) Transistor
LSA1576UB
LTC114EUB
2SD1767
RT3T22M
RT3C99M
Q
Q
Q
Q
Q
302
303
304
351
352
(A,141,126) Transistor
(A,133,126) Transistor
(A,125,120) Transistor
(A,102,113) Transistor
(A,96,112) Transistor
RT3C99M
RT3C99M
RT3T22M
LTC114EUB
LTC114EUB
Q
Q
Q
Q
Q
381
751
752
821
822
(A,92,108) Transistor
(A,7,71) Transistor
(A,17,79) Transistor
(A,53,27) Transistor
(A,47,23) Transistor
2SC3052-12
2SD2396
RT3T22M
2SD1767
RT3T22M
Q
Q
Q
Q
Q
841
842
851
852
901
(A,63,34)
(A,63,29)
(A,13,36)
(A,18,30)
(A,7,105)
LSA1576UB
LTC114EUB
2SD1760F5
RT3T22M
2SD2396
Q
Q
Q
Q
D
902
921
931
961
201
(A,15,104) Transistor
(A,58,88) Transistor
(A,95,119) Transistor
(A,68,95) Transistor
(A,125,71) Diode
RT3T22M
RT3CLLM
LTC114EUB
LSA1576UB
MC2850-11
(A,95,94) Diode
HZU13(B1)
D 241
Transistor
Transistor
Transistor
Transistor
Transistor
DEH-P510UB/XN/UC
1
Part No.
D
D
D
D
301
381
382
383
(A,122,128) Diode
(A,88,108) Diode
(A,92,113) Diode
(A,88,113) Diode(A)
1SS355
HZU8R2(B2)
MC2848-11
MC2848-11
D
D
D
D
D
501
502
751
801
802
(A,28,59)
(A,43,73)
(A,14,79)
(A,73,15)
(A,77,15)
Diode
Diode
Diode
Varistor
Varistor
RB060L-40
1SR139-400
HZU7R5(B3)
EZJZ1V800AM
EZJZ1V800AM
D
D
D
D
D
805
806
807
808
809
(A,83,10)
(A,70,18)
(A,74,18)
(A,66,18)
(A,62,18)
Diode
Diode
Diode
Diode
Diode
MC2850-11
MC2848-11
MC2846-11
MC2848-11
MC2846-11
D
D
D
D
D
821
851
852
901
902
(A,50,23) Diode
(A,32,14) Diode
(A,22,30) Diode
(A,13,107) Diode
(A,36,89) Diode
HZU10(B1)
RB551V-30
HZU10(B1)
UDZS5R6(B)
1SR139-400
D
D
D
D
D
921
922
931
941
942
(A,53,94) Diode
(A,62,94) Diode
(A,93,122) Diode
(A,81,102) Diode
(A,77,102) Diode
UDZS7R5(B)
HZU6R8(B2)
1SS355
1SR139-400
1SR139-400
D 961
D 981
D 982
ZNR401
L 201
(A,68,92) Diode
MC2848-11
(A,44,129) Diode
1SR154-400
(A,48,129) Diode
1SR154-400
(A,161,112) Surge Protector IMSA-6801-01Y901
(A,106,80) Inductor
LAU2R2K
L
L
L
L
L
401
402
403
501
591
(A,155,100) Inductor
(A,145,89) Inductor
(A,151,50) Inductor
(A,20,57) Inductor
(A,56,58) Inductor(A,B)
L
L
L
L
L
601
761
852
961
981
(A,83,61) Ferri-Inductor
LAU100K
(A,31,37) Ferri-Inductor(A,B) LAU100K
(A,29,21) Inductor
CTF1660
(A,72,102) Inductor
LAU2R2K
(A,33,109) Choke Coil 600 uH CTH1280
X 601
P 301
SP601
Y 401
LCTAW220J2520
LAU1R0K
LAU2R2K
ATH7048
CTF1713
R
R
R
R
R
101
102
103
104
105
(A,42,124)
(A,41,124)
(A,44,124)
(A,80,95)
(A,26,125)
RS1/16SS620J
RS1/16SS101J
RS1/16SS101J
RS1/16SS222J
RS1/16SS181J
R
R
R
R
R
106
107
108
113
114
(A,40,125)
(A,38,125)
(A,27,125)
(A,37,125)
(A,28,125)
RS1/16SS181J
RS1/16SS223J
RS1/16SS223J
RS1/16SS102J
RS1/16SS102J
R
R
R
R
R
115
116
117
151
152
(A,80,92)
(A,74,97)
(A,85,92)
(A,18,134)
(A,18,130)
RS1/16SS472J
RS1/16SS102J
RS1/16SS223J
RS1/16S102J
RS1/16S102J
R
R
R
R
R
181
182
183
184
201
(A,99,12)
(A,99,10)
(A,108,11)
(A,103,11)
(A,114,84)
RS1/16S181J
RS1/16S181J
RS1/16SS223J
RS1/16SS223J
RAB4C102J
R
R
R
R
R
202
203
242
301
302
(A,110,85)
(A,111,85)
(A,90,97)
(A,143,112)
(A,132,112)
RS1/16SS101J
RS1/16SS101J
RS1/16SS152J
RS1/16SS390J
RS1/16SS390J
R
R
R
R
R
303
304
305
306
307
(A,144,124)
(A,136,124)
(A,138,125)
(A,130,125)
(A,123,122)
RS1/16SS390J
RS1/16SS390J
RS1/16SS390J
RS1/16SS390J
RS1/16SS102J
R
R
R
R
R
308
309
310
311
312
(A,140,112)
(A,134,112)
(A,144,126)
(A,135,126)
(A,138,126)
RS1/16SS223J
RS1/16SS223J
RS1/16SS223J
RS1/16SS223J
RS1/16SS223J
R
R
R
R
R
313
314
316
319
320
(A,130,126)
(A,133,129)
(A,144,129)
(A,146,112)
(A,144,112)
RS1/16SS223J
RS1/16SS0R0J
RS1/16SS0R0J
RS1/16SS472J
RS1/16SS472J
R
R
R
R
R
321
322
323
324
351
(A,141,129)
(A,141,124)
(A,132,129)
(A,134,123)
(A,122,102)
RS1/16SS472J
RS1/16SS472J
RS1/16SS472J
RS1/16SS472J
RS1/16SS472J
R
R
R
R
R
352
353
354
355
356
(A,114,102)
(A,114,112)
(A,114,114)
(A,118,112)
(A,118,114)
RS1/16SS472J
RS1/16SS182J
RS1/16SS272J
RS1/16SS182J
RS1/16SS272J
R
R
R
R
R
357
358
359
360
361
(A,94,109)
(A,113,112)
(A,113,114)
(A,119,112)
(A,119,114)
RS1/16SS472J
RS1/16SS182J
RS1/16SS272J
RS1/16SS182J
RS1/16SS272J
R
R
R
R
R
362
363
364
365
366
(A,100,111)
(A,103,110)
(A,98,111)
(A,97,109)
(A,98,121)
RS1/16SS103J
RS1/16SS103J
RS1/16SS331J
RS1/16SS101J
RS1/16SS103J
R
R
R
R
R
381
382
383
384
401
(A,89,104)
(A,87,101)
(A,89,107)
(A,97,116) (B,C,D,E)
(A,155,64)
RS1/16SS473J
RS1/16SS223J
RS1/16SS104J
RS1/16SS0R0J
RS1/16SS681J
R
R
R
R
R
403
405
406
407
501
(A,155,77)
(A,155,80)
(A,155,82)
(A,155,83)
(A,38,46)
RS1/16SS681J
RS1/16SS681J
RS1/16SS681J
RS1/16SS681J
RS1/10SR471J
R
R
R
R
R
502
503
504
505
506
(A,31,47)
(A,30,50)
(A,30,48)
(A,26,50)
(A,28,52)
RS1/16SS8201F
RS1/16SS3302F
RS1/16SS102J
RS1/16SS0R0J
RS1/16SS303J
DEH-P510UB/XN/UC
5
RESISTORS
Part No.
75
Part No.
Part No.
R
R
R
R
R
507
508
601
602
603
(A,30,55)
(A,28,55)
(A,121,41)
(A,129,41)
(A,127,41)
RS1/16SS8202F
RS1/16SS123J
RS1/16SS104J
RS1/16SS104J
RS1/16SS102J
R
R
R
R
R
775
776
777
778
780
(A,39,42)
(A,39,41)
(A,39,39)
(A,47,34)
(A,41,43)
(A,B)
(A,B)
(A,B)
(A,B)
(A,B)
RS1/16SS3302F
RS1/16SS1302F
RS1/16SS3901F
RS1/16SS102J
RS1/16SS7502F
R
R
R
R
R
604
605
606
607
608
(A,130,44)
(A,115,42)
(A,114,43)
(A,124,41)
(A,122,41)
RS1/16SS681J
RS1/16SS472J
RS1/16SS472J
RS1/16SS102J
RS1/16SS104J
R
R
R
R
R
781
782
783
801
803
(A,41,42) (A,B)
(A,41,41) (A,B)
(A,41,39) (A,B)
(A,82,7)
(A,69,14)
RS1/16SS3302F
RS1/16SS1302F
RS1/16SS3901F
RS1/16S222J
RS1/16S222J
R
R
R
R
R
609
610
611
612
613
(A,106,45)
(A,110,52)
(A,110,56)
(A,133,55)
(A,110,57)
RS1/16SS222J
RS1/16SS473J
RS1/16SS0R0J
RS1/16SS472J
RS1/16SS473J
R
R
R
R
R
805
806
807
809
811
(A,67,14)
(A,65,14)
(A,63,14)
(A,71,14)
(A,70,20)
RS1/16S222J
RS1/16S222J
RS1/16S222J
RS1/16SS104J
RS1/16SS104J
R
R
R
R
R
614
615
616
617
618
(A,110,58)
(A,111,61)
(A,109,61)
(A,134,58)
(A,109,43)
RS1/16SS102J
RS1/16SS102J
RS1/16SS104J
RS1/16SS104J
RS1/16SS102J
R
R
R
R
R
821
822
824
825
842
(A,54,21)
(A,55,23)
(A,49,27)
(A,47,27)
(A,63,32)
RS1/16SS473J
RS1/16S1R0J
RS1/10SR121J
RS1/10SR121J
RS1/16SS102J
R
R
R
R
R
619
620
621
622
623
(A,134,60)
(A,120,68)
(A,123,67)
(A,118,68)
(A,128,67)
RS1/16SS104J
RS1/16SS103J
RS1/16SS473J
RS1/16SS223J
RS1/16SS104J
R
R
R
R
R
843
852
854
855
856
(A,63,37)
(A,43,24)
(A,43,26)
(A,37,27)
(A,39,28)
RS1/16SS473J
RS1/16SS1502F
RS1/16SS1301F
RS1/10SR102J
RS1/16SS1R0J
R
R
R
R
R
624
625
626
627
628
(A,127,67)
(A,125,67)
(A,129,67)
(A,124,67)
(A,126,41)
RS1/16SS104J
RS1/16SS0R0J
RS1/16SS104J
RS1/16SS0R0J
RS1/16SS104J
R
R
R
R
R
858
901
902
903
911
(A,14,30)
(A,13,105)
(A,13,104)
(A,13,102)
(A,12,111)
RS1/4SA181J
RS1/16SS223J
RS1/16SS681J
RS1/16SS681J
RS1/16SS473J
R
R
R
R
R
629
630
631
641
651
(A,136,47)
(A,121,68)
(A,106,48)
(A,134,64)
(A,108,67)
RS1/16SS104J
RS1/16SS104J
RS1/16SS104J
RS1/16SS104J
RS1/16SS183J
R
R
R
R
R
921
922
923
924
925
(A,54,90)
(A,62,90)
(A,56,90)
(A,60,90)
(A,58,90)
RS1/16SS104J
RS1/16SS103J
RS1/16SS473J
RS1/16SS223J
RS1/16SS472J
R
R
R
R
R
652
701
702
703
704
(A,106,63)
(A,72,47)
(A,71,42)
(A,74,47)
(A,80,47)
RS1/16SS102J
RS1/16SS473J
RAB4C472J
RS1/16SS104J
RS1/16SS221J
R
R
R
R
R
931
961
962
964
983
(A,96,121)
(A,66,93)
(A,70,95)
(A,71,95)
(A,58,93)
RS1/16SS103J
RS1/16SS102J
RS1/16SS472J
RS1/16SS153J
RS1/4SA102J
R
R
R
R
R
705
706
707
708
709
(A,78,47)
(A,81,47)
(A,77,47)
(A,83,47)
(A,75,47)
RS1/16SS221J
RS1/16SS221J
RS1/16SS221J
RS1/16SS221J
RS1/16SS102J
R 984
(A,93,124)
RS1/4SA102J
R
R
R
R
R
751
761
762
763
764
(A,17,76)
(A,54,35)
(A,54,36)
(A,54,37)
(A,54,39)
(A,B)
(A,B)
(A,B)
(A,B)
RS1/4SA561J
RS1/16SS7502F
RS1/16SS3302F
RS1/16SS1302F
RS1/16SS3901F
R
R
R
R
R
765
766
767
768
769
(A,57,35)
(A,51,43)
(A,52,35) (A,B)
(A,52,36) (A,B)
(A,52,37) (A,B)
RS1/16SS5R6J
RS1/16SS5R6J
RS1/16SS7502F
RS1/16SS3302F
RS1/16SS1302F
R
R
R
R
R
770
771
772
773
774
(A,52,39)
(A,57,33)
(A,51,42)
(A,44,35)
(A,39,43)
RS1/16SS3901F
RS1/16SS5R6J
RS1/16SS5R6J
RS1/16SS0R0J
RS1/16SS7502F
(C,D,E)
(A,B)
(B)
(A,C,D,E)
76
(A,B)
(C,D,E)
(C,D,E)
(A,B)
(A,B)
CAPACITORS
C
C
C
C
C
101
102
103
181
182
(A,25,125)
(A,79,97)
(A,81,96)
(A,86,16)
(A,106,11)
CKSSYB104K16
CKSSYB102K50
CKSSYB102K50
CKSSYB104K16
CKSSYB472K50
C
C
C
C
C
183
184
185
186
187
(A,102,11)
(A,107,13)
(A,105,13)
(A,103,13)
(A,102,13)
CKSSYB472K50
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
C
C
C
C
C
188
189
201
202
203
(A,104,24)
(A,110,19)
(A,119,80)
(A,117,84)
(A,127,70)
CKSSYB102K50
CEJQ220M16
CEJQ470M16
CKSSYB104K16
CCSSCH470J50
DEH-P510UB/XN/UC
1
Part No.
Part No.
C
C
C
C
C
205
206
207
208
209
(A,106,83)
(A,126,82)
(A,105,88)
(A,125,88)
(A,104,88)
CKSRYB474K10
CEJQ100M16
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
C
C
C
C
C
551
552
571
572
601
(A,51,50)
(A,51,53)
(A,47,59) (A,B)
(A,47,56) (A,B)
(A,132,44)
CKSSYB105K6R3
CKSSYB105K6R3
CKSSYB105K6R3
CKSSYB105K6R3
CCSSCH470J50
C
C
C
C
C
210
211
212
213
214
(A,127,88)
(A,102,88)
(A,128,88)
(A,100,89)
(A,128,92)
CKSRYB105K10
CKSRYB224K16
CKSRYB224K16
CKSRYB105K10
CKSRYB105K10
C
C
C
C
C
603
604
606
607
651
(A,109,53)
(A,109,55)
(A,99,61)
(A,103,61)
(A,104,63)
CCSSCH200J50
CCSSCH200J50
CEJQ100M16
CKSSYB103K25
CKSRYB105K10
C
C
C
C
C
215
216
217
218
219
(A,104,94)
(A,128,94)
(A,106,94)
(A,124,94)
(A,106,97)
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
C
C
C
C
C
701
731
732
733
751
(A,78,54)
(A,70,61)
(A,74,61)
(A,65,73)
(A,66,54)
CKSSYB104K16
CEJQ220M6R3
CKSRYB103K50
CKSRYB474K10
CEJQ101M16
C
C
C
C
C
220
221
222
223
224
(A,124,97)
(A,108,100)
(A,123,100)
(A,93,91)
(A,110,105)
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
CCSSCH101J50
CEJQ100M16
C
C
C
C
C
752
753
761
821
841
(A,71,51)
(A,13,79)
(A,38,35) (A,B)
(A,52,22)
(A,62,24)
CKSSYB102K50
CKSSYB473K16
CEJQ100M16
CKSRYB473K50
CKSSYB473K16
C
C
C
C
C
241
242
243
255
301
(A,100,97)
(A,104,98)
(A,97,94)
(A,121,85)
(A,142,108)
CEJQ470M16
CKSSYB104K16
CKSRYB224K16
CKSRYB104K16
CEJQ100M16
C
C
C
C
C
852
853
854
855
856
(A,38,14)
(A,43,23)
(A,43,19)
(A,41,28)
(A,32,31)
CEJQ470M25
CKSSYB103K25
CCSRCH331J50
CKSSYB104K16
CEJQ101M16
C
C
C
C
C
302
303
304
305
306
(A,135,108)
(A,149,119)
(A,138,119)
(A,143,119)
(A,132,119)
CEJQ100M16
CEJQ100M16
CEJQ100M16
CEJQ100M16
CEJQ100M16
C
C
C
C
C
858
901
902
903
904
(A,21,29)
(A,35,81)
(A,14,85)
(A,12,108)
(A,27,86) 1 500 uF/16 V
CKSSYB104K16
CEJQ220M16
CKSSYB104K16
CKSSYB103K25
CCH1201
C
C
C
C
C
307
352
353
354
355
(A,125,114)
(A,115,120)
(A,118,120)
(A,120,120)
(A,113,120)
CEJQ220M16
CKSRYB474K10
CKSRYB474K10
CKSRYB474K10
CKSRYB474K10
C
C
C
C
C
911
912
913
921
931
(A,22,93)
(A,12,113)
(A,16,118) 100 uF/25 V
(A,60,95)
(A,92,119)
CEJQ101M10
CKSSYB103K25
CCH1316
CKSSYB104K16
CKSRYB105K16
C
C
C
C
C
356
357
358
359
360
(A,98,105)
(A,115,124)
(A,118,124)
(A,120,124)
(A,113,124)
CEJQ330M10
CKSQYB474K16
CKSQYB474K16
CKSQYB474K16
CKSQYB474K16
C 941
C 961
C 981
(A,57,131)
(A,70,97)
(A,60,131)
CKSRYB473K50
CKSSYB104K16
CKSRYB104K16
C
C
C
C
C
361
362
364
365
366
(A,109,131)
(A,113,131)
(A,103,104)
(A,122,136)
(A,50,120) 3 300 uF/16 V
CKSQYB225K10
CKSQYB225K10
CEJQ100M16
CKSSYB104K16
CCH1486
C
C
C
C
C
402
403
404
405
406
(A,154,60)
(A,155,66)
(A,155,94)
(A,151,59)
(A,152,90)
CKSSYB103K25
CKSSYB103K25
CKSSYB103K25
CEJQ470M6R3
CEJQ101M16
C
C
C
C
C
451
452
453
501
502
(A,150,39)
(A,151,43)
(A,149,35)
(A,28,49)
(A,31,43) 150 uF/6.3 V
CEJQ220M6R3
CKSSYB103K25
CKSYB475K16
CKSSYB471K50
CCH1804
C
C
C
C
C
503
504
505
506
507
(A,30,52)
(A,30,51)
(A,32,59)
(A,39,66)
(A,30,54)
CKSSYB103K16
CKSSYB221K50
CKSRYB105K16
CEJQ221M16
CKSSYB104K16
B
Unit Number : (A)
Unit Number : (B,C,D,E)
Unit Name : Keyboard Unit
MISCELLANEOUS
IC 1901
IC 1931
IC 1951
IC 1981
Q 1831
(B,80,20) IC
(A,155,11) Remote IC
(B,43,31) IC
(A,123,20) IC(A)
(A,123,20) IC(B,C,D,E)
(B,23,8) Transistor
PEG511A8
GP1UXC14RK
S-1200B33-M5
PD8184A
PD8185A
UMD3N
Q
D
D
D
D
(B,10,13) Transistor
(A,144,39) LED
(A,6,34) LED
(A,19,31) LED
(A,157,39) LED
LTC123JUB
SMLE12BC7T(NP)
SMLE12BC7T(NP)
SMLE12BC7T(NP)
SMLE12BC7T(NP)
(A,6,7) LED
(A,29,28) LED
(A,46,10) LED
SMLE12BC7T(NP)
SMLE12BC7T(NP)
SMLE12BC7T(NP)
1833
1831
1832
1833
1834
D 1835
D 1836
D 1837
DEH-P510UB/XN/UC
5
77
Part No.
D 1838
D 1839
(A,18,7) LED
(A,29,9) LED
SMLE12BC7T(NP)
SMLE12BC7T(NP)
D
D
D
D
L
1840
1851
1852
1901
1851
(A,46,28) LED
(B,136,20) Varistor
(B,137,20) Varistor
(A,68,22) Diode
(B,136,24) Inductor
SMLE12BC7T(NP)
EZJZ1V800AM
EZJZ1V800AM
1SS355
CTF1713
L
L
X
S
S
1951
1961
1901
1811
1831
(B,50,31) Inductor
CTF1617
(A,108,16) Inductor
CTF1617
(B,69,21) Ceramic Resonator 16.000 MHz CSS1616
(A,37,19) Switch(ROTARY COMMANDER) CSX1120
(A,145,37) Push Switch
CSG1155
S
S
S
S
S
1832
1833
1834
1835
1836
CSG1155
CSG1155
CSG1155
CSG1155
CSG1155
S
S
S
S
1837
1838
1839
1840
CSG1155
CSG1155
CSG1155
CSG1155
Part No.
R
R
R
R
1918
1919
1920
1921
(A,112,27)
(B,115,26)
(A,109,23)
(A,96,15)
RAB4C101J
RAB4C101J
RAB4C101J
RS1/16S103J
R
R
R
R
R
1922
1923
1926
1927
1931
(A,121,30)
(A,72,25)
(B,65,20)
(A,74,28)
(B,156,18)
RS1/16S103J
RAB4C103J
RS1/16S102J
RS1/16S103J
RS1/16S101J
R
R
R
R
R
1932
1933
1951
1965
1966
(B,155,18)
(B,152,18)
(B,40,32)
(A,92,16)
(A,78,28)
RS1/16S103J
RS1/16S2R2J
RS1/16S222J
RAB4C101J
RS1/16S101J
(A,94,16)
RS1/16S101J
R 1967
CAPACITORS
C
C
C
C
C
1851
1901
1902
1903
1931
(A,155,30)
(A,64,26)
(A,66,19)
(B,92,22)
(B,155,15)
CKSRYB104K16
CKSRYB103K50
CKSRYF104Z25
CKSRYB103K50
CKSYB106K6R3
C
C
C
C
C
1951
1952
1953
1963
1964
(B,44,27)
(B,39,32)
(B,46,31)
(A,99,26)
(A,99,23)
CKSRYB104K16
CKSRYB104K16
CKSRYB104K16
CKSRYB105K16
CKSQYB105K25
(B,99,22)
(A,88,17)
(A,124,28)
CKSRYB105K16
CKSRYB104K16
CKSRYB103K50
RESISTORS
C
R
R
R
R
R
1801
1802
1803
1811
1812
(B,53,18)
(B,51,26)
(B,74,4)
(B,20,28)
(B,21,20)
RS1/16S222J
RS1/16S222J
RS1/16S333J
RS1/16S103J
RS1/16S333J
R
R
R
R
R
1813
1814
1815
1816
1818
(B,21,21)
(B,24,27)
(B,21,23)
(B,24,26)
(A,76,12)
RS1/16S103J
RS1/16S102J
RS1/16S332J
RS1/16S102J
RS1/16S103J
R
R
R
R
R
1819
1834
1835
1840
1841
(B,21,24)
(B,22,15)
(B,19,15)
(B,8,9)
(B,8,16)
RS1/16S222J
RS1/16S152J
RS1/16S152J
RS1/16S271J
RS1/16S332J
R
R
R
R
R
1842
1843
1844
1845
1901
(B,9,16)
(B,11,16)
(B,12,16)
(B,14,16)
(B,46,27)
RS1/16S681J
RS1/16S152J
RS1/16S681J
RS1/16S152J
RS1/16S103J
R
R
R
R
R
1902
1903
1904
1905
1906
(A,67,24)
(A,70,21)
(B,69,25)
(B,64,27)
(A,75,30)
RS1/16S473J
RS1/16S154J
RAB4C102J
RS1/16S104J
RS1/16S473J
R
R
R
R
R
1907
1908
1909
1910
1911
(A,63,16)
(A,81,12)
(A,81,29)
(B,85,6)
(B,89,10)
RAB4C102J
RS1/16S221J
RAB4C473J
RAB4C101J
RAB4C101J
R
R
R
R
R
1912
1913
1914
1915
1916
(B,118,15)
(A,114,30)
(B,114,29)
(B,114,15)
(B,93,18)
RAB4C101J
RS1/16S101J
RS1/16S101J
RAB4C101J
RAB4C101J
R 1917
(A,112,11)
RAB4C101J
78
C 1965
C 1966
C 1981
C
Unit Number : CWX3678
Unit Name
: CD Core Unit(S10.5iPod-Code3)
MISCELLANEOUS
IC 201
IC 205
IC 301
Q 101
Q 102
(A,35,46)
(B,24,49)
(A,28,15)
(B,58,69)
(B,48,58)
IC
IC
IC
Transistor
Chip Transistor
Q
X
X
S
S
(B,27,54)
(A,22,37)
(B,33,63)
(A,55,37)
(B,19,58)
Transistor
2SA1577
Ceramic Resonator 16.934 MHz CSS1603
Oscillator 48.000 MHz CSS1753
Switch(HOME)
CSN1067
Switch(DSCSNS) CSN1067
201
201
205
901
903
S 904
S 905
(B,40,68) Switch(12EJ)
(B,25,69) Switch(8EJ)
PE5661A
341S2162
BA5839FP
2SA1577
2SB1689
CSN1068
CSN1068
RESISTORS
R
R
R
R
R
101
102
103
104
105
(B,61,74)
(B,61,72)
(B,61,71)
(B,53,66)
(B,44,57)
RS1/10SR2R4J
RS1/10SR2R4J
RS1/10SR2R7J
RS1/16SS222J
RS1/16SS102J
R 107
R 202
R 203
(B,52,60)
(A,27,32)
(A,51,44)
RS1/16SS105J
RS1/16SS473J
RS1/16S473J
DEH-P510UB/XN/UC
1
Part No.
R 204
R 206
(A,23,58)
(B,10,26)
RS1/16SS221J
RS1/16SS104J
R
R
R
R
R
209
210
214
216
221
(B,18,52)
(B,10,23)
(B,49,50)
(B,48,49)
(A,51,48)
RS1/16SS103J
RS1/16SS102J
RS1/16SS472J
RS1/16SS472J
RS1/16SS103J
R
R
R
R
R
222
223
225
226
227
(A,51,46)
(B,13,43)
(A,50,50)
(A,50,51)
(B,47,51)
RS1/16SS103J
RS1/16SS473J
RS1/16SS103J
RS1/16SS393J
RS1/16SS562J
R
R
R
R
R
228
229
230
232
233
(B,44,51)
(B,46,53)
(B,21,25)
(B,45,51)
(B,26,59)
RS1/16SS122J
RS1/16SS472J
RS1/16SS0R0J
RS1/16SS122J
RS1/16SS103J
R
R
R
R
R
234
235
237
240
241
(B,22,26)
(A,26,59)
(A,24,35)
(B,14,26)
(B,13,25)
RS1/16SS473J
RS1/16SS473J
RS1/16SS151J
RS1/16S473J
RS1/16SS103J
R
R
R
R
R
244
249
250
252
254
(B,22,55)
(B,14,50)
(B,19,50)
(B,18,47)
(A,25,64)
RS1/16SS473J
RS1/16SS103J
RS1/16SS101J
RS1/16SS101J
RS1/16SS104J
R
R
R
R
R
255
256
259
261
262
(A,26,63)
(A,25,62)
(A,27,66)
(A,26,65)
(A,29,59)
RS1/16SS104J
RS1/16SS104J
RS1/16SS0R0J
RS1/16SS104J
RS1/16SS0R0J
R
R
R
R
R
263
273
277
282
283
(A,27,63)
(B,18,48)
(B,18,50)
(A,30,61)
(A,29,61)
RS1/16SS0R0J
RS1/16SS103J
RS1/16SS103J
RS1/16SS120J
RS1/16SS120J
R
R
R
R
R
284
285
291
292
293
(B,29,63)
(B,28,63)
(B,42,62)
(B,24,43)
(B,27,52)
RS1/16SS153J
RS1/16SS153J
RS1/16SS272J
RS1/16SS272J
RS1/16SS472J
R
R
R
R
R
294
307
308
309
310
(A,31,62)
(A,35,19)
(A,37,19)
(A,35,21)
(A,37,22)
RS1/16SS471J
RS1/16SS183J
RS1/16SS183J
RS1/16SS183J
RS1/16SS183J
R
R
R
R
R
601
602
606
701
702
(B,30,31)
(B,27,31)
(B,28,23)
(B,11,37)
(A,23,56)
RS1/16SS0R0J
RS1/16SS0R0J
RS1/16S0R0J
RS1/16SS221J
RS1/16SS221J
R 708
R 712
R 713
(B,15,37)
(B,14,54)
(B,14,53)
RS1/16S0R0J
RS1/16SS0R0J
RS1/16SS0R0J
Part No.
C 204
C 205
C 206
(A,23,59)
(B,27,41)
(A,23,40)
CKSSYB103K16
CKSQYB475K10
CKSSYB104K10
C
C
C
C
C
207
209
210
211
212
(A,24,37)
(B,35,34)
(B,29,37)
(A,28,35)
(A,28,30)
CKSRYB104K16
CEVW220M6R3
CKSSYB104K10
CKSSYB104K10
CKSRYB104K16
C
C
C
C
C
213
214
216
217
218
(A,46,39)
(A,29,33)
(A,51,52)
(A,48,51)
(A,50,52)
CKSSYB104K10
CKSSYB104K10
CKSSYB332K50
CKSSYB104K10
CKSSYB473K10
C
C
C
C
C
219
220
221
222
223
(A,47,53)
(A,48,53)
(A,46,54)
(B,45,53)
(B,47,53)
CKSSYB104K10
CKSSYB182K50
CKSSYB104K10
CCSSCH560J50
CCSSCH4R0C50
C
C
C
C
C
224
226
227
228
229
(A,44,55)
(A,42,59)
(A,42,61)
(B,41,61)
(B,48,60)
CKSSYB104K10
CCSSCH680J50
CCSSCH470J50
CKSSYB103K16
CKSSYB104K10
C
C
C
C
C
236
239
240
243
250
(A,49,58)
(B,46,51)
(A,38,61)
(B,22,41)
(A,52,48)
CKSSYB104K10
CCSSCH220J50
CKSSYB104K10
CKSQYB475K10
CKSSYB102K50
C
C
C
C
C
251
260
261
262
290
(A,52,46)
(A,28,61)
(B,33,66)
(B,31,66)
(B,26,45)
CKSSYB102K50
CKSSYB104K10
CCSSCH8R0D50
CCSSCH8R0D50
CKSSYB104K10
C
C
C
C
C
293
294
303
304
307
(B,43,61)
(B,24,41)
(A,36,19)
(A,36,21)
(A,22,11)
CKSSYB102K50
CKSSYB104K10
CKSSYB472K25
CKSSYB223K16
CKSRYB104K16
C
C
C
C
308
703
704
711
(B,11,18)
(B,14,35)
(B,11,36)
(A,31,25)
CKSRYB105K10
CCSSCH101J50
CKSSYB102K50
CKSSYB104K10
CAPACITORS
C 106
C 202
(B,56,67)
(A,28,57)
CKSQYB475K10
CKSSYB104K10
DEH-P510UB/XN/UC
5
79