Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
pdf
Page 1
Contents
Step for the realization of a screen from a
iMac G5 17 "/ 20
2
Opening the iMac
2
Adaptation of food
2
Device is switched on the screen:
4
Power to the inverter (which illuminates the screen)
5
Connecting the signal cable of the slab (DVI)
6
Placing cables
8
Test voltages and power supply startup
9
Laying the slab
9
Diagram of the screen.
Page 2
Page 3
Adaptation of food
We will use the power from the iMac to power the panel and inverter.
The power supply has voltage 12V, 5V, 3.3V Standing (All) used to start
iMac and the 12V, 5V, 3.3 V (Run) power available once the power supply started.
I'll explain how to start the PSU.
2
Page 4
10 GRD
5 GRD
11 5V run
6 3.3 V all
12 3.3 V run
the power connector
Page 5
To start the power supply must connect the 3.3 V All on No. 7 and the GRD wire on
No. 1.
To stop the power supply must be connected to the No. 1 wire at the 3.3 V All --. 7
remains.
I j uses an inverter, but you can connect the button to stop a bistable relay.
Page 6
Page 7
Page 8
Page 9
This connector located at the rear of the slab, must be disassembled to identify son
Strip the other end, there is attention from very fine wire and the wire
tanks, stripping son with nails for example does not pull the strands of
copper.
Allow the heat slug 2mm, the wire noted the tape, a soldering iron.
4 - connect together the two brothers son cable, except that another mass GRD
fils19-20-21 which is the mass of the diet.
although the polarity rx + / -, I didn t connect the shield (ground)!
Do not connect 5V + and hotplug nor the son is (the single)
isolated welds with heat slug
5 - 3.3 V will be connected to 3.3 V power supply All of the GRD and the GRD alim
6 - isolated at the ribbon
Page 10
Page 11
Last
in
instead of cables
Colson cables neatly and locate the position of the connector when the slab
it is in place and mark on the iMac.
Me d I spent the DVI cable into the hole in the ethernet! bof, if not to drill
center ;-))
Page 12
I test on a slab
separate power supply,
with the DVI cable
connected to the slab and
PWM
The slab is tested
The brightness is
good, I can
mounted in the iMac
Page 13
good luck
Alanus
9
Page 14
10
Ouverture de l iMac
Contribute a better translation