Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
:
:
Use
Company
Emergency telephone:
Health:
866.442.9628 (North America)
1.832.813.4984 (International)
Transport:
North America: CHEMTREC 800.424.9300 or 703.527.3887
Asia: +800 CHEMCALL (+800 2436 2255)
EUROPE: BIG +32.14.584545 (phone) or +32.14583516 (telefax)
South America SOS-Cotec Inside Brazil: 0800.111.767 Outside Brazil: +55.19.3467.1600
Responsible Department
E-mail address
Website
:
:
:
Color: Opaque
Odor: Hydrocarbon
: Combustible Liquid
:
Signal Word
Warning
Hazard Statements
Precautionary Statements
Prevention:
GHS-Labeling
MSDS Number:100000013691
1/11
Carcinogenicity:
IARC
NTP
ACGIH
Molecular formula
Mixture
Component
C12-C14 Isoalkanes
Distillates (petroleum), hydrotreated
light
CAS-No.
68551-19-9
64742-47-8
Weight %
0 - 60
0 - 60
General advice
If inhaled
If swallowed
MSDS Number:100000013691
2/11
85 C (185 F)
Suitable extinguishing
media
Unsuitable extinguishing
media
Special protective
equipment for fire-fighters
Further information
Personal precautions
Environmental precautions
Advice on protection
against fire and explosion
Storage
Requirements for storage
MSDS Number:100000013691
3/11
Basis
Value
Control parameters
TWA
1,200 mg/m3
Value
Control parameters
Note
Note
Engineering measures
Adequate ventilation to control airborned concentrations below the exposure guidelines/limits.
Consider the potential hazards of this material (see Section 2), applicable exposure limits, job
activities, and other substances in the work place when designing engineering controls and selecting
personal protective equipment. If engineering controls or work practices are not adequate to prevent
exposure to harmful levels of this material, the personal protective equipment listed below is
recommended. The user should read and understand all instructions and limitations supplied with
the equipment since protection is usually provided for a limited time or under certain circumstances.
Personal protective equipment
Respiratory protection
Hand protection
Eye protection
Eye wash bottle with pure water. Tightly fitting safety goggles.
Hygiene measures
MSDS Number:100000013691
4/11
: Liquid
: Opaque
: Hydrocarbon
Safety data
Flash point
Lower explosion limit
: 85 C (185 F)
: No data available
: No data available
Molecular formula
: Mixture
Molecular Weight
: Not applicable
pH
: Not applicable
Pour point
: No data available
Vapor pressure
: No data available
Relative density
Water solubility
: No data available
: No data available
: No data available
Evaporation rate
: No data available
: 91,937 cSt
Chemical stability
Other data
MSDS Number:100000013691
5/11
Distillates (petroleum),
hydrotreated light
No data available
Distillates (petroleum),
hydrotreated light
No data available
Distillates (petroleum),
hydrotreated light
HEC Liquid Polymer
Skin irritation
No data available
: Species: Monkey
Dose: 0, 654 ppm
Exposure time: 4 wk
Number of exposures: 6 h/d, 3 d/wk
NOEL: > 654 ppm
Toxicity to fish
MSDS Number:100000013691
6/11
Distillates (petroleum),
hydrotreated light
Toxicity to algae
C12-C14 Isoalkanes
Additional ecological
information
MSDS Number:100000013691
Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code
MSDS Number:100000013691
8/11
: Fire Hazard
CERCLA Reportable
Quantity
This product does not contain any hazardous air pollutants (HAP), as defined by the U.S. Clean Air
Act Section 12 (40 CFR 61).
This product does not contain any chemicals listed under the U.S. Clean Air Act Section 112(r) for
Accidental Release Prevention (40 CFR 68.130, Subpart F).
This product does not contain any chemicals listed under the U.S. Clean Air Act Section 111 SOCMI
Intermediate or Final VOC's (40 CFR 60.489).
US State Regulations
9/11
: This product does not contain any chemicals known to the State
of California to cause cancer, birth, or any other reproductive
defects.
Notification status
Europe REACH
:
:
Australia AICS
New Zealand NZIoC
Japan ENCS
Korea KECI
Philippines PICCS
China IECSC
:
:
:
:
:
:
NFPA Classification
: Health Hazard: 1
Fire Hazard: 1
Reactivity Hazard: 0
1
1
Further information
Legacy MSDS Number
297870
Significant changes since the last version are highlighted in the margin. This version replaces all
previous versions.
The information in this MSDS pertains only to the product as shipped.
The information provided in this Material Safety Data Sheet is correct to the best of our
knowledge, information and belief at the date of its publication. The information given is designed
only as a guidance for safe handling, use, processing, storage, transportation, disposal and
release and is not to be considered a warranty or quality specification. The information relates
only to the specific material designated and may not be valid for such material used in
combination with any other materials or in any process, unless specified in the text.
Key or legend to abbreviations and acronyms used in the safety data sheet
MSDS Number:100000013691
10/11
LOAEL
CNS
CAS
American Conference of
Government Industrial Hygienists
Australia, Inventory of Chemical
Substances
Canada, Domestic Substances
List
Canada, Non-Domestic
Substances List
Central Nervous System
Chemical Abstract Service
EC50
Effective Concentration
NOAEL
EC50
EGEST
NOEC
OSHA
GHS
>=
IC50
STEL
SARA
IARC
TLV
TWA
TSCA
UVCB
<=
WHMIS
LC50
AICS
DSL
NDSL
EOSCA
EINECS
MAK
IECSC
ENCS
KECI
MSDS Number:100000013691
NFPA
NIOSH
NTP
NZloC
PEL
PICCS
Philippines Inventory of
Commercial Chemical Substances
Presumed Not Toxic
PRNT
RCRA
11/11