Sei sulla pagina 1di 2

Fosroc Cebex DS P1

constructive solutions

Soil conditioning polymer liquid Agent for


Tunnel Boring Machines (TBM)

Uses

Consumption

EPB shield machines

Typically, Cebex DS P1 is used at 2 to 3%/ m3 by undescribed soil (range 2 6%) by volume of water.

Poorly graded and water saturated ground

Foam Equipment

Advantages

Cebex DS P1 can be used with the standard TBM dosing


and foaming equipment.
Tackling water problems in ground containing fine sand
or silt.

Properties

Reducing soil permeability.

Form

: Liquid

Creation of plastic deformation properties in the soil


which provides an even and controlled support pressure
and increased face stability.

Colour

: Transparent

Density kg / m3 20 C
pH

: 980 - 1000

Increasing cohesion of coarser sand sandy gravels.

Solubility

Strong viscosity modifying effect, turning wet soil into a


more manageable consistency.

Packaging:

When injected directly into the screw conveyor, it helps


the formation of the plug.

Cebex DS P1

Ready to use no mixing equipment required.

: 6.5 - 7.5
: Totally soluble in
water

: 200 litre drum or bulk supply

Storage

Description

Cebex DS P1 must be stored between 5C and 35C. If


stored in original closed containers, it will have a shelf life
of 12 months. Do not allow the product to freeze.

Fosroc Cebex DS P1 is a polymer reinforced agent


especially designed for soil conditioning in shielded tunnel
boring machines.

Precautions
Health and safety

Soft ground tunnelling.

Designed for silt to sand soils which may contain a high


amount of water.

Application
Cebex DS P1 can be used independently, in which case it
is injected into the working chamber or screw conveyor.
The quantity of Cebex DS P1 polymer needed depends on
the soil conditions. If a transfer of dosing pump is being
used for more than one product, it is recommended to clean
the pump with water before switching to Cebex DS P1.
Application Instruction

Cebex DS P1 is non-hazardous, should not be swallowed


or allowed to come into contact with skin and eyes.
Suitable protective gloves and goggles should be worn.
Splashes on skin should be removed with water. In case of
contact with eyes rinse immediately with plenty of water
and seek medical advice. If swallowed seek medical
attention immediately - do not induce vomiting. For further
information, refer to the Material Safety Data Sheet .

Cleaning
Spillage of Cebex DS P1 should be absorbed onto sand,
earth or vermiculite and transferred to suitable containers.
Remnants should be hosed down with large quantities of
water.

Adjust the properties of the excavated soil. A trial evaluation


should be conducted to determine the proper dosage for a
given soil condition or dust suppression application.

Page 1

Fosroc Cebex DS P1
Disposal
The disposal of excess of waste material should be carried
out in accordance with local legislation under guidance of
the local waste regulatory authority.

Fire
Cebex DS P1 is non-flammable.

Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.

Fosam Company Limited


Head Office
Post Box 11081
Jeddah 21453
Saudi Arabia

www.fosroc.com

Telephone: +966 12 637 5345

Fax: +966 12 637 5891

email: fosam@fosroc.com

Regional Offices
Jeddah Sales Office
Jeddah Showroom
Riyadh
Dammam
Khamis Mushayt

Tel: (012) 608 0999


Tel: (012) 665 0187
Tel: (011) 482 9303
Tel: (013) 814 1282
Tel: (017) 250 0469

Fax: (012) 638 0693


Fax: (012) 667 4844
Fax: (011) 482 7562
Fax: (013) 814 1581
Fax: (017) 250 0469

Yanbu
Makkah
Medinah
Jubail
CSD

Tel: (014) 322 4280


Tel: (012) 542 0869
Tel: (014) 855 0091
Tel: (013) 362 3904
Tel: (012) 608 0999

Fax: (014) 391 2980


Fax: (012) 542 0869
Fax: (014) 855 0047
Fax: (013) 362 3875
Fax: (012) 638 0693

Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2

FO SA/FOSROC CEBEX DS P1/11/14

Potrebbero piacerti anche