Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Tension Test:
One tension test shall be made from each heat.
Tensile Requirements (ASTM A216):
Tensile Requirements:
One tension test shall be made from each heat.
Tensile Requirements (ASTM A182):
Note: A-Determined by the 0.2 % offset method. For ferritic steels only, the 0.5 % extensionunder-load method may also be used.
Additional requirement for H2S service (NACE MR0175):
Carbon and low alloy steels are acceptable at 22 HRC maximum hardness provided
they contain less than 1 % nickel, are not free-machining steels and are used in one of
the following heat-treatment conditions:
a) hot-rolled (carbon steels only);
b) annealed;
c) normalized;
d) normalized and tempered;
e) normalized, austenitized, quenched, and tempered;
f) austenitized, quenched, and tempered.
In addition to the restrictions of above, some carbon steels are acceptable subject to the
revised or additional restrictions as follows.
a) Forgings produced in accordance with ASTM A105 are acceptable if the hardness does not
exceed 187 HBW.
b) Wrought pipe fittings to ASTM A234 grades WPB and WPC are acceptable if the hardness
does not exceed 197 HBW.
Reference for unit conversion: ASTM E140 - Standard Hardness Conversion
Supplementary Requirements
3. Hydrostatic test certificate:
Depending on which standard the valve complied with: ASME B16.34/API
598/Applicable standard.
ASME B16.34:
Shell test pressure: no less than 1.5 times the 100oF pressure rating(**), rounded off to the
next higher 1 bar (25 psi), test duration shall be not less than the following:
Closure test pressure: no less than 1.1 times 100oF pressure rating, rounded off to the next
higher 1 bar (25 psi). Pneumatic test at gage pressure not less than 5.5 bar (80 psi) can be
carried out to substitute for hydrostatic test for valve sizes and pressure class as follows:
(**): Determine pressure rating of valve: look up table 2 Rating for Groups Material
API 598:
ANSI Class
Working Temperature/ Pressure ; service limitations.
NPS or DN
Applicable Standard
4. Tag name (if any)
5. Dimension + Quantity
Instruction ny c th dng :
Kim tra Steel Gate, Glove, Butterfly, Check, Ball, Knife Valve; Bronze
gate, globe, check valves.
a ra hng dn t hydro-test.