Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
ST-1401A AT Interface
NOTE: This figure and the following description of each jumper position
is only valid on drives that have J6 with 4 pins (2x2).-->�
�
J5 Drive ID Select and � � J6 (located on side
Configuration Select Header� � near rear)
���������������������������� ���������������������
� o o1
40-pin I/O Cable Connector � +5v ---o o
�������������������� o o o o o1 ������
J4�::::::::::�::::::::1� /���������\ o o o o o � �
����������������������� 0 0 0 0 ��E�D�C�B�A� Remote LED�� 3Reserved
(pin 20 missing for ��5�G�G�12� (see below) Connection� �Jumper
keying purposes) DC Power �Position
J5
JUMPER | FUNCTION:
A REFSIG: This location provides a port for external connection
of the synchronized spindle reference signal (pin-1) and ground
(pin-2). The reference signal is bi-directional, single-ended, and
terminated without an external resistor. It is also available on J4
pin-28 if the factory jumper is installed. The drive will
self-determine if it is a master of slave for spindle synchronization.
======================================
NOTE: This figure and the following description of each jumper position
is only valid on drives that have J6 with 6 pins (2x3).-->�
�
J5 Drive ID Select and � � J6 (located on side
Configuration Select Header� � near rear)
���������������������������� ���������������������
� o o o1
� +5v ---o o o
40-pin I/O Cable Connector � ��������
�������������������� o o o o o1 1 2 3
J4�::::::::::�::::::::1� /���������\ o o o o o Remote LED�� � 4Reserved
����������������������� 0 0 0 0 ������������ Connection� � �Jumper
(pin 20 missing for ��5�G�G�12� (see below)Ŀ � �Position
keying purposes) DC Power ���������� ATA mode ���
�
��J5�����������������������������Ŀ
� �Ŀ �Ŀ �Ŀ 1 �
� �o� o-C�o�E�o�G-o �
� �o�B-o �o� �o� o �
� �A� �D� �F� �
� �������������������������� �
���Defaults shown in solid lines���
ST - 1401A