The literature survey was done with the intention of developing formulations of Zidovudine and Lamivudine from bulk and pharmaceutical dosages forms. As by Literature survey it was found that many research works are available for the preparation of these drugs. 2.1.1 REVIEW OF LITERATURE VNL. Sirisha et.al. 37 formuled and evaluated Lamivudine and Zidovudine extended release tablets. In her research, Microcrystalline cellulose was used as a diluent, PVPK 90 was used as a Binder, Sodium starch glycolate was used as a disintegrant, Isopropyl Alcohol was used as a Solvent, Megnesium stea rate was used as a Lubricant, Talc was used as a glidant, HPMC was used as a counting saluting. Lamivudine and Zidovudine tablets were prepared by wet granulation method and coating with HPMC. After evaluation of physical properties of tablets, the in-vitro release study was performed in 7.8 p H Phosphate buffer, in phosphate buffer p H 6.8. Based on the observations, it can be concluded that the attempt of formulation and evaluation of the Lamivudine and Zidovudine coated tablets was found to be successful in extend the release by effectively coated with a Hydrophilic Polymer up to a extend period. Krishna Vamshi Allam et.al. 38 stated his research, Lamivudine as a Nucleoside Reverse Transcriptase Inhibitor (NRTI), licensed for the treatment of HIV, and chronic Hepatitis B. In his research, the pharmacokinetic data of Lamivudine shows that, frequent administration for a prolonged period of time (lifelong in AIDS and for one year in hepatitis patients) is necessary to maintain constant therapeutic drug levels in the body, in case of AIDS, the dose is 150 mg twice daily (i.e. multiple times a day) in the form of conventional oral tablets. But the long-term AIDS therapy with the conventional tablets of Lamivudine found to have some drawbacks, such as adverse side effects (sometimes severe) resulting from accumulation of drug in multi-dose long- term therapy; poor patient compliance; and high cost. Designing of controlled and sustained release once-daily formulations of Lamivudine can overcome these problems, and maintaining of systemic drug levels consistently above its target antiretroviral concentration throughout the course of the treatment (which is crucial for the success of AIDS therapy) is also possible with these approaches. This review briefly discusses about the novel dosage forms like controlled release matrix tablets, floating tablets, nanoparti4cles, microparticles, liposomes, and niosomes; which may possibly suitable for the controlled and/or sustained release of Lamivudine and thus, useful in developing the more effective AIDS therapy with very less or no adverse side effects. Vikramjit Singh et.al 39 prepared tablets containing Zidovudine and Lamivudine (ZILA) by direct compression method. Optimization studies were done for the selection of glidant, lubricant and coating materials. Evaluation of granules was done on the basis of preformulation studies. The prepared tablets were evaluated for physicochemical properties. The in-vitro release studies were performed as per USP and compared with marketed product. The release of Zidovudine and Lamivudine were analyzed by high performance liquid chromatography (HPLC). The ZILA tablets exhibited better release characteristics than the marketed product. Stabilities studies were performed in both blister as well as cold form blister packings. Stabilities studies revealed the suitability of blister package in comparison to the cold form blister packing. From the study it was concluded that the selected composition can be used for the preparation of tablets that can be used for the treatment of HIV-1 and Hepatitis-B after performing studies on animals for its suitability and efficacy. B. Rajkumar, T. et.al. 40 developed a reverse phase HPLC isocratic method that has been validated as per ICH guidelines in terms of specificity, accuracy, precision, linearity, robustness, limit of detection and limit of quantitiation, for the simultaneous quantitative estimation of Efavirenz, Lamivudine Zidovudine. A good linear relationship was observed for both the drugs between concentration ranges of 50 and 150 g/ml. The correlation coefficients were greater than 0.999 for both the drugs. The inter day and intraday precision results were good enough to say that the method developed is precise and reproducible. Accuracy studies revealed that mean recoveries after spiking experiments were between 98 and 102%, an indicative of accurate method. Accordingly it can be concluded that the developed reverse phase HPLC method is accurate, precise, linear and robust and therefore the method can be used for the routine analysis of Efavirenz, Lamivudine and Zidovudine in tablets. D.Ramakanth Reddy et.al. 41 developed a simple, accurate, precise and economical procedure for simultaneous estimation of Zidovudine and Lamivudine in combined tablet dosage form that utilizes concept of Dual Wavelength method. This method involves selection of two wavelengths at which the drug has same absorbance. The method is based upon determination of Zidovudine at 272 nm and 287.2 nm and Lamivudine at 256 nm and 275.2 nm in 0.1N HCl. Different analytical performance parameters such as linearity, precision, accuracy, LOD, LOQ and assay were determined according to ICH guidelines. The method was found linear between the range of 50-425 g/ml for Zidovudine and 50-275g/ml for Lamivudine. The results of formulation given as percentage of label claim were found to be 100.730.56 and 101.860.68 for Zidovudine and Lamivudine respectively. Therefore, the proposed methods can be used for the routine analysis of both drugs in quality control laboratories. Srikanth Thota et.al. 42 formulated and evaluated immediate release Tablets of Lamivudine and Zidovudine, Nevirapine - HAART triple therapy. The objective of this regimen is, to delay disease progression, to increase the duration of survival by achieving maximal and prolonged suppression of HIV replication, to restorate and preserve immunological function. Combination therapy is more effective and has less chances of developing resistance than monotherapy. To achieve this goal various prototype formulation trials were taken and evaluated with respect to the various quality control tests such as Thickness, hardness, weight variation, dissolution, disintegration, hardness and assay. The formula was finalized by comparing the in-vitro dissolution profile with that of the Marketed Tablets. The in-vitro release study was performed in 0.1N HCl up to 60 min. Among all the formulations, formulation F7 release profile was good as compared to the marketed products. Stability studies (402C/755%RH) for 2 months indicated that no characteristics changes in formulation. There was no chemical interaction between drug and excipients. Joseph J. Eron et.al. 43 prepared a randomized, open-label, multicenter study to establish clinical equivalence (non-inferiority) of a regimen employing a Lamivudine 150 mg/Zidovudine 300 mg combination tablet, administered twice daily, plus a marketed protease inhibitor, compared with a conventional regimen of 150 mg Lamivudine twice daily, 600 mg Zidovudine daily, and a protease inhibitor, in antiretroviral-experienced patients infected with HIV-1. Adults who were seropositive for HIV-1 infection with plasma HIV-1 RNA levels < 10,000 copies/ml (Roche Amplicor polymerase chain reaction assay, lower limit of quantitation (LLOQ) 400 copies/ml) and CD4+ cell counts 300X10 6 /l). All patients had been receiving the conventional Lamivudine/Zidovudine/protease inhibitor regimen for 10 weeks immediately prior to the study. The result of the combination tablet regimen was associated with a 3.5% greater success rate than the conventional regimen (96.4 versus 92.9%), with four and eight patients failing treatment due to increases in HIV-1 RNA levels, respectively. The lower limit of the associated confidence interval for the difference was -2.4%, which was well within the -10% margin predefined as clinically unimportant. This establishes the clinical equivalence (non-inferiority) of the combination tablet regimen to the conventional regimens regarding virologic response. The combination tablet and conventional regimens were similar with respect to percentage of patients maintaining HIV-1 RNA levels, LLOQ at the end of study or improving from baseline to undetectability (94 versus 91%), overall incidence of drug-related adverse events (21 versus 19%), and mean area under the curve for CD4. cell counts [treatment difference, 5.9 cells (95% confidence interval, -15.8 to 27.6 3 106 cells). A self-reported adherence questionnaire indicated that patients in the combination tablet group were less likely to miss doses of nucleoside analogue medication at weeks 8 and 16. Sreenivasulu Y et.al. 44 developed a simple, accurate, precise and economical procedure for UV Spectroscopic estimation of Lamivudine in pure state and in its pharmaceutical formulation. The developed method is based upon complex formation of the drug with methyl red reagent. Linearity was observed in the concentration range of 0.5-5 g/ml. Calibration curve was constructed by plotting absorbance values against concentrations, which gave good regression values. The method was validated statistically and recovery study was performed to confirm the accuracy of the method. Mohite P.B et.al. 45 stated that Lamivudine is cytosine and Zidovudine is cytidine and are used as antiretroviral agents. Both drugs are available in tablet dosage forms with a dose of 150 mg for LAM and 300 mg ZID respectively. In his research, the method employed is based on first order derivative spectroscopy. Wavelengths 279 nm and 300 nm were selected for the estimation of the Lamivudine and Zidovudine respectively by taking the first order derivative spectra. The concentration of both drugs was determined by proposed method. The results of analysis have been validated statistically and by recovery studies as per ICH guidelines. Both the drugs obey Beers law in the concentration range 10-50 g/ml, for LAM and ZID; with regression 0.9998 and 0.9999, intercept 0.0677 and 0.0043 and slope 0.0457 and 0.0391 for LAM and ZID, respectively. The accuracy and reproducibility results are close to 100% with 2% RSD. Finally the work concludes that simple, accurate, precise, sensitive and economical procedures for simultaneous estimation of Lamivudine and Zidovudine in tablet dosage form have been developed. Manikanta Kumar A. et.al. 46 developed a simple, specific, accurate and precise UV spectrophotometric method has been for simultaneous estimation of Lamivudine and Efavirenz in pharmaceutical dosage form. The absorption maxima of the drugs were found to be at 271 and 247 nm for Lamivudine and Efavirenz respectively. Lamivudine and Efavirenz obeyed Beers law in the concentration range of 10-100 g/ml and 10-70 g/ml respectively. Different analytical parameters such as linearity, precision, and accuracy, limit of detection (LOD) and limit of quantification (LOQ) were determined as per ICH guidelines. Limit of detection and quantification values for Lamivudine 10 and 3.5 g/ml and for Efavirenz 10 and 3.0 g/ml respectively. The recovery values between prescribed limit of 98-102% shows that method is free from interference of excipients present in formulation. The developed method was free from interferences due to excipients present in formulation and it can be used for routine quality control analysis. Emmanuel M. Uronnachi et.al. 47 published a research article on Pharmacokinetics and biodistribution of zidovudine loaded in a solidified reverse micellar delivery system. The aim of the research was to study the stability, release profile, pharmacokinetic and biodistribution properties of Zidovudine (AZT)-solidified reverse micellar microparticulate. Lipid matrices formulated with Phospholipon 90H and goat fat at ratios of 1:1, 2:1, 3:1 and 2:3 were used to prepare AZT-loaded SLM by melt dispersion followed by lyophilization. In-vitro release studies of the drug were carried out using a sequential drug release method in both SGF (p H 1.2) and SIF (p H 7.2) while the in-vivo drug release studies were carried out using Wistar albino rats. The result of our findings showed that the drug is compatibility with the lipid matrix with the 1:1 showing the most stable microparticle preparation which was then optimized. The formulations showed a concentration dependent increase in their concentration maximum (C max ) with values of 116.05 g/ml, 124.21 g/ml, 128.95 g/ml, 138.95 g/ml and time to reach maximum concentration (T max ) values of 5h, 8 h, 8 h, and 5 h for batches B1, B2, B3 and B4 containing 1 %, 2 %, 3 % and 5 % of AZT respectively. The area under curves (AUCs) of the microparticles formulated showed that the bioavailabilities of the microparticles were comparable to that of the conventional release tablet. The biodistribution studies of the microparticles in rats showed highest concentration of the drug in the liver with the least in the brain and higher biodistribution in various organs than pure AZT. The data suggested that SLM could be a promising drug delivery system to improve on the shortcomings of pharmacokinetics and bio-distribution properties of conventional AZT tablets like fluctuation in blood levels of the drug.