0 valutazioniIl 0% ha trovato utile questo documento (0 voti)
564 visualizzazioni3 pagine
This document contains 41 multiple choice questions about electronics topics. The questions cover oscillators, transformers, feedback, logic gates, diodes, sensors, registers, filters, transistors, and other circuit components. The answers provided are short terms that identify the key concept or component being asked about in each question.
This document contains 41 multiple choice questions about electronics topics. The questions cover oscillators, transformers, feedback, logic gates, diodes, sensors, registers, filters, transistors, and other circuit components. The answers provided are short terms that identify the key concept or component being asked about in each question.
This document contains 41 multiple choice questions about electronics topics. The questions cover oscillators, transformers, feedback, logic gates, diodes, sensors, registers, filters, transistors, and other circuit components. The answers provided are short terms that identify the key concept or component being asked about in each question.
1. A type of oscillator which uses an amplifier circuit
that introduces 1800 phase shift Ans. RC Phase Shift Oscillator 2. AC generator output is delivered via Ans. Slip ring and brushes 3. In a series resistive circuit , the applied circuit voltage is equal to the: Ans. Sum of all the individual voltage drop around the circuit 4. A typical relay has : Ans. one set of contacts and one or more coils 5. The measure of how pure or real an inductor is. The higher its value in an inductor, the fewer losses there are.
Ans. Q-factor
6. It is a diagnostic application or device that a network administrator can purchase and install on a network workstations or attach to the network media to monitor and capture dat packets for subsequent analysis
Ans. Sniffer
7. Refers to the process of shrinking the size and power dissipation of electronic circuits. It also involves surface mount technology
Ans. Microminiaturization
8. If the feedback signal (voltage or current) is applied in such a way that it is in phase with the input signal and thus increases. It is also known as regenerative feedback or direct feedback
Ans. Positive Feedback
9. This can be defined as the ratio of output d.c. power available at the load to the power rating (Volt Ampere) of the transformer used in the rectifier circuit
Ans. Transformer Utilization Factor 10. The gate source of an n-channel depletion- mode JFET are connected together. What value of Vds will ensure that this two terminal device is biased in the saturation region. What is the drain current for the bias condition?
Ans. Idss 11. The performance specifications of a normally include a description of the voltage transfer characteristics, noise margins, fan-out, fan-in, propagation delay, power dissipation, and delay power product. Ans. Logic-gate 12. It is used in a range of applications, in rectification, demodulation and signal clamping. Ans. Diode 13. When the current in the coil changes, an electromotive force (EMF) is induced in that coil which tends to oppose the change in the current. This is ____ Ans. Self-inductance 14. It is the slope of transfer characteristic (Id versus Vgs ) and is defined as the change in the drain current corresponding to a change in the gate-to-source voltage.
Ans. Transconductance
15. Used solely for storing and shifting data which is in the form of 1s and or 0s. Ans. Register 16. A starting switch that is used to de-energize the start winding of a leruetic compressor just like the current relay. Ans. Hot wire relay 17. It is a non-zero level of the output voltage when all inputs are zero? Ans. Offset error 18. What frequency that can cause the movement of air molecules above audio frequency but below radio frequency. Ans. Ultrasonic frequency 19. A mutual induction device used to measure the absolute angular position of a shaft. Ans. Resolver 20. A memory that can be read by the processor, but the processor cannot write into it such devices are non-volatile and so are suitable for storing programs or any noncharging data
Ans. ROM 21. The most commonly used for fieldwork to measure the viscosity of oils, syrups, varnish, paints and vv Ans. Efflux Cup viscometer 22. It is used for measuring very low pressures down to one hundred-thousandth of an inch of mercury. Ans. Mcleod Gauge 23. What type of Liquid cooling in which the heat sink assembly is immersed in oil tank? Ans. Oil-immersed natural cooling 24. Used to reduce the amount of AC negative feedback while maintaining DC feedback. Ans. Decoupling capacitor 25. A microphone which are one of the oldest and simplest forms of sound detector Ans. Carbon microphones 26. A device that produce a measurable response to a change in a physical condition, such as temperature or thermal conductivity or to a change in a chemical concentration. Ans. Sensor 27. It is used to store the results of certain condition when certain operations are perform during execution of the program. Ans. Status register & Flag register 28. This is a measure of smallest incremented unit of the input signal that can be measured by the transducer. Ans. Resolution 29. A thyristor has the ability to provide a pulse that is used to trigger SCRs and other thyristors. Ans. PUT 30. The various op-amp circuits used for generating such signals of required frequency and waveform. Ans. Waveform generator & signal generator 31. The outputs of a full adder are S = 0, Co = 1. Its inputs might be____. Ans. A = 1, B = 0, Ci = 1. 32. A snubber network is used to reduce___. Ans. False triggering. 33. An active bandpass filter is built from a lowpass filter cascaded with a highpass filter. It has a lower cutoff frequency of 200 Hz, and a bandwidth of 800 Hz. The cutoff points of its two filters are: Ans. Lowpass = 200 Hz, highpass = 1 khz 34. At the cut-off point of a lowpass filter the phase change is: Ans. 45 degree 35. The open-loop gain of an op amp falls to 1 at___. Ans. Transition frequency 36. What theory states that "any resistance R in a branch of a network in which a current I is flowing can be replaced by a voltage equal to IR"? Ans. Compensation Theorem 37. This diode provides fast voltage transitions by the very sudden disappearance of the charge carriers. After a forward current has been passing in the diode and the current is interrupted, the reverse conduction will cease very abruptly. Ans. Step-recovery diode 38. It is the time taken by a diode to operate in the reverse condition from forward conduction. Ans. Reverse recovery time 39. In a self-biased JFET, the gate is at Ans. 0 V 40. In a push-pull amplifier, the distortion in the output cause by the transition of state of transistors from cut-off state to the on state is called ____. Ans. Crossover distortion 41. A type of circuit that consists of two matching transistors with the collector of one connected to the bases of both, thus producing the same collector current in each transistor. Ans. Current mirror