1 Mode Field diameter of G.652 at 1300nm wavelength 9-10 m 2 Cut-off Wavelength of G.652 Fiber Optic Cable 1100-1280 nm 3 Cladding Diameter of G.652 Fiber Optic Cable 125 m 4 A three-dipole array with negligible spacing between elements gives a gain of _______ 3.3 dB 5 The typical cladding diameter is ______ 125 m 6 The Standard that defines proximity cards used for identifications, and transmissions protocols for communicating with it ISO/IEC 14443 7 GPS update Daily 8 Longer wavelength the greater BW Edge Emitting LED 9 Hard Metal Flouride 10 What is the maximum distance of a segment of the 10BASE-T Ethernet? 100m 11 Doppler Heading Reference 1 degree 12 Distance that provides the viewer with the optimum immersive visual HDTV experience Optimum Viewing Distance 13 Optimum Viewing Distance 14 Which is not true about FUNI It is a faster ATM 15 ___ is a type of inertia navigation system that mounts the instrument platform directly to the vehicle chassis and transforms the inertial measurements to the navigation frame computationally. Strapdown Inertial Navigation 16 ___ is a type of inertia navigation system that drives a set of actuators to maintain the alignment of the platform with the coordinates axes of the platform with the coordinates axes of a desired navigation coordinates system independent of the motion of the vehicle relative to the navigational frame. Mechanized Inertial Navigation 17 The wavelength of laser argon is _______ 510 nm 18 Fiber connection-oriented channel with acknowledgement Class I 19 Fiber connectionless channel with acknowledgement Class II 20 Ephemeris 16 21 The protocol use by the card readers Wiegand Protocol 22 International Telegraph and Telephone Consultative Committee (CCITT) was created in 1956 and was renamed ITU-T in ________ 1993 23 Wireless USB maximum number of host connected 127 24 HomeRF has a range ___ times than the Bluetooth 5 25 longer wavelength Silver Bromide 26 Typical color of jacket in the multimode fiber is _______ Orange 27 MTTF 10^5 28 What ITU recommendation specifies data over cable services interface spec (DOCSIS) functions, and internal and external interfaces for high-speed, bi-directional transfer of digital data between cable TV network and subscribers?
J.112 29 Oxide to form silica Metal Halide, dopant material oxygen 30 Y coupler 31 X.121 32 15kV 33 Telephone control service binary (TCS Bin) is a bit-oriented protocol that defines the call control signaling for establishing speed and data calls between two Bluetooth-compliant devices. TCS Bin is based on ITU-T recommendation ___. Q.931 34 100 IRE is the Reference White 35 Algorithmic used by RIP Bellman-Ford Algorithmic 36 Who coined the term Artificial Intelligence John McCarthy 37 Air traffic control over ocean Aerosat 38 OFDM Attracted to terrestrial propagation Long symbol duration 39 In transmission line with termination in capacitance, the standing wave of voltage is minimum at a distance of exactly ___ lambda from the end. 1/8 lambda 40 lambda 41 Transit system, though the USs oldest family of radio- navigation satellite system, has an exceptional accuracy compared to Navstar GPS and Glonass. What is the accuracy of the transit system? 500m 42 Most used fiber cable is _________ 62.5/125 micron 43 Tree connector 44 Internet protocol (IP) address are usually represented by four decimal numbers ranging from 0 to ___ separated by dots 255 45 Which of the following has the same data rate? V.29 and V.32 46 The nominal data rate for Bluetooth V2.0 + EDR is ______ 3 Mbps 47 The practical data rate for Bluetooth V2.0 + EDR is ______ 2.1 Mbps 48 A type of fiber which is constant Step Index 49 A type of fiber which is varying Graded Index 50 Which of the following is a gigabit Ethernet? 1000BaseT 51 Metal that will increased impact Berillium Oxide Ceramic 52 FM Class B 52 km 53 Orthogonal carriers OFDM 54 The fiber 9.2 About 10000 nodes 55 The center frequency of NAVSTAR GPS are _____ and _____. 1575.42 MHz , 1227.6 MHz 56 The positioning of OMEGA has a global range of ________ 88% - 98% 57 The center frequency of Glonass Positioning System are ______ 1602.5 MHz to 1615.5 MHz 58 What navigation system used for civil and military aircraft is not a passive user? VOR 59 RFID system has three frequency ranges. What is the frequency range of intermediate RFID system? 10-15 MHz 60 What is the maximum range of characteristic impedance of transmission lines used in actual practice with all considerations included? 600 ohms 61 In tropospheric scatter microwave system, the antennas used are horn-driven paraboloids which can have a diameter as large as ___ meters 18 62 What is the desirable vertical angle of radiation is used for rhombic antennas used for long distance sky wave coverage at high frequencies? 20 63 Adaptive delta pulse code modulation (ADPCM) converts sound into digital signal. What happens to the T1 lines sampling rate when using ADPCM? Reduced by one-half of its original rate 64 DOCSIS (data over cable service interface spec) compliant cable modem and cable TV infrastructure supports data rate of ____ downstream 27-36 Mbps 65 DOCSIS ( data over cable service interface spec) compliant cable modem and cable TV infrastructure supports a maximum data rate of ___ upstream 10 Mbps 66 A firewire socket can connect a maximum of 63 devices and each device is allotted a 6-bit identification number and the total cable length can be ___ meters 72 67 Gigabit Ethernet, 1000 Base-LX uses both single-mode and multi-mode fiber cable. Multi-mode fiber uses shorter wavelength and provides a distance of approximately ___ m 550 68 PPS (precision position service) has a maximum deviation in horizontal position accuracy of up to ___ meters 22.3 69 SPS (standard position service) has a maximum deviation in horizontal position accuracy of up to ___ meters 106.7 70 Hybrid fiber optic and coaxial cable (HFC) systems are broadband communications access networks that provide a wide range of CATV video channels and other modulated high frequency carrier service in the range of ____ 50-860 MHz 71 Coarse wavelength division multiplexing, employed in broadband fiber-optic transmission systems uses a ___ wavelength gap between any two channels 20nm 72 What ITU recommendation defines the coarse wavelength division multiplexing (CWDM) G.694.2 73 The rule of thumb in using erbium doped fiber amplifiers (EDFAs) is to maintain ___ input light power +4 to +6 dBm 74 The Packets over SONET (PoS) is a non-TDM-oriented technology that utilizes speed and management capabilities of SONET/SDH to optimize data transports. PoS supports a minimum speed of ___ Mbps 155 75 One of the sources of optical fiber signal loss is the air gap. Normally, each glass to air interface can result to a ___ loss 4% 76 One of the sources of optical fiber signal loss is the axial misalignment. In order to maintain a loss below 0.3 dB, the displacement of the fibers must be less than ___ 5% 77 To avoid scattering losses due to the ends of the connecting fiber, the ends must be highly polished to produce a grit of less than ___ micrometer 0.5 78 One of the performance parameters for fiber optic couplers is the polarization stability. What polarity stability value is achieved with the fused biconical taper technology? +/- 0.1dB 79 And EDFA (Erbium-doped fiber amplifier) used for long distance land based fiber installation consists of a ___ laser pump 980nm 80 Silicon PIN diode exhibits a maximum quantum efficiency of ___ 95% 81 The Bluetooth RF operating range characteristic states that the asynchronous channel can support an asymmetric link of maximally ___ kbps in either direction 721 82 The average power requirements for HDTV transmissions are ___ dB less than those for NTSC 12-18 83 The wireless technology 802.11b has a range ___ times that of the Bluetooth 10 84 An advantage of HomeRF over the Bluetooth is higher data rate. While the Bluetooth has a data rate less than 1 Mbps, HomeRF has a data rate of ___ Mbps 1.6 85 RF systems recently are using microelectromechanical systems (MEMS). What is the insertion loss of MEMS? 0.1 dB 86 Regarding health concern of human bodys exposure to radio frequency, it is noted that the human body can absorb peak RF energy somewhere between ___ MHz 80-100 87 What is the maximum allowable power density (mW/sq.cm) for a frequency range 30 300 MHz? 0.2 88 In navigation, one disadvantage of the positioning system over INS and dead-reckoning system is that it cannot provide measurements at frequency higher than ___ 100 Hz 89 1000 mm 90 STS-1 51.84 Mbps 91 Class A and Class B Proximity Cards 13.56 MHz 92 Fiber optics theoretical bandwidth 10 years ago. 100 THz 93 DVB-T accurate______ of time 99.99% 94 IEEE 802.14 95 Passport ID-3 96 ATM ID-1 97 SSB-C 98 SSB+SC 99 Numerical Aperture Mismatch 100 Long Symbol 101 Hue, Saturation and Brightness HSV 102 Bronze waveguide 44.2% 103 Ultra-Wideband (UWB) may be used to refer to any radio technology having bandwidth >500 MHz 104 UWB is in the range of __________ 3.1 to 10.6 GHz 105 The FCC power spectral density emission limit for UWB emitters operating in the UWB band is _______ -41.3 dBm/MHz 106 The modulation index of NTSC when fiber is used. 0.25 0.33 107 DSM-CC ISO/IEC 13818-6 108 Which is not true about IRDa? Interfere with other device 109 Which is not true about fiber? Security 110 In communication, it is the altering of message intentionally or unintentionally so that it will be difficult to understand. Garble 111 100 to 200 kHz Low Frequency Loran 112 Tactical frequencies Military units 113 What is an action that occurs when a transmitting or receiving work station has not received data or a response in a specified period of time? Timeout 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165 166 167 168 169 170
ADDITIONAL INFO:
FOR G.652
Bend loss @ 1550nm must be less than 1 dB for travel through 100 turns of fiber wound on a spool of 7.5 cm diameter Dispersion @ 1300nm band (1285-1330nm) must be less than 3.5 ps/nm/km Dispersion @ 1550nm should be less than 20 ps/nm/km
FIBER CHANNEL
Connection Oriented Services Class I with acknowledgement, full bandwidth Class IV virtual connection, QoS, fractional bandwidth Class VI uni-directional Connectionless Services Class II with acknowledgement Class III without acknowledgement Node Levels FC-4 - Translation between fiber channel and command sets that use it FC-3 Common services across multiple ports Port Levels (FC-PH standards) FC-2 Framing and flow Control FC-1 8B/10B encoding, error detection FC-0 Electrical and optical Characteristics