Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Wireless 300
Car Stereo FM Transmitter
User Guide & Warranty Information
*Depending on variable environmental factors
iCarPlay
or iPhone
battery
Bright LED Display
Easy to read day or night
Portable Design
For use in the car, home and ofce
USB Charging Port
Lets you charge iPod or iPhone while listening
Includes USB Cable
For convenient iPod and iPhone charging
and synching with iTunes
INSTRUCTIONS
Connecting to iPod
or iPhone
+
P
1
Manual Tuning
1. Press and hold button until the LCD
display blinks.
2. Press and release the or button to adjust
the channel up or down.
3. Once the display stops ashing, the iCarPlay Wireless
300 will broadcast on the station displayed.
ImPortaNt: For best results, before programming and using the iCarPlay Wireless
300, nd FM channels that have the weakest signals in your area. Channels with
only static are most ideal (try lower channels, like 88.1). Traveling to different
areas may require using alternative channels.
P
2
P
3
M
+
P
1
+
P1
M
P3 P2
+
P1
M
P3 P2
+
P1
M
P3 P2
Setting Presets
1. First, manually tune to the channel you want to store
to memory as described in the Manual Tuning section.
2. While the LCD display is still ashing the current
frequency, press and hold down (P1, P2, or P3) for
several seconds until the display stops ashing.
3. The preset station is now stored at that location.
P
2
P
3
M
+
P
1
Recalling Presets
1. Simply press any of the three preset buttons (P1, P2,
or P3) to select the pre-programmed frequency.
2. The iCarPlay Wireless 300 will automatically tune
to the channel that you have stored in memory.
Playing your iPod or iPhone with
iCarPlay Wireless 300
1. Press play on your iPod or iPhone as you normally
would.
2. Choose and push one of the pre-set buttons on the
iCarPlay Wireless 300.
3. Turn on your radio and tune it to the same FM
channel that is displayed on the iCarPlay Wireless
300s LCD display.
4 . Your music selection should begin to play through
your audio systems speakers.
Charging or syncing your iPod
or iPhone to iTunes while using
iCarPlay Wireless 300
You can charge your iPod or iPhone through the iCarPlay
Wireless 300 with the included USB cable. You can also
use the cable to sync to iTunes on your computer.
1. Make sure the iCarPlay Wireless 300 is plugged in
and operating. Plug the smaller mini USB end of the
cable into the side of the iCarPlay Wireless 300.
2. Plug the USB end of the wire into the available USB
2.0 port. Your iPod or iPhone should show that it is
charging. If you are plugging into a computer with
iTunes, you will also be synced.
P
2
P
3
M
+
P
1
NotE: While syncing
with iTunes, the LED
display will turn off.
iCarPlay Wireless Display Settings
Please note that in order to preserve the battery life
of your iPod and iPhone the display of the iCarPlay
Wireless 300 will automatically shut off after a period
of time when no buttons have been pushed. To wake
up the display, simply press any button.
Performance Tip
NotE: In some areas where clear reception is a challenge,
connect the included USB cable to the iCarPlay wireless
300. The cable will act as an antenna and may improve
the performance of the iCarPlay Wireless 300.
The USB cable does not need to be connected to another
device to act as an antenna.
Performance & Safety Tips:
Connecting and/or setting iCarPlay