Step 2 Start a new sketch Note the axle is on the top and the solder terminals are on the bottom.
Step 3 Draw a circle at the origin and dimension it to 27.7 mm in diameter.
Step 4 Extrude join the circle to 32.6 mm.
Step 5 Create a new sketch on top of the last extrusion. Draw two circles with a diameter of 2.6 mm that are both 8.0 mm from the center.
Step 6 Extrude cut the two circles to 5.0 mm downward (into the part).
Step 7 Create a new sketch on top of the part and draw a circle in the center with a diameter of 10.0 mm.
Step 8 Extrude join the circle to 3.5 mm. Step 9 Create a new sketch at the center and draw a circle at the center with a diameter of 2.3 mm.
Step 10 Extrude join to 10.0 mm
Step 11 Fillet the end of the last extrusion to 1.0 mm.
Step 12 Rotate the motor to the bottom and draw a new sketch at the center with a radius of 10.0 mm.
Step 13 Extrude join the circle to 2.0 mm. Step 14 Create a new sketch on the top of the last extrusion. Draw a circle with a diameter of 2.3 mm
Step 15 Extrude join to 0.8 mm upward.
Step 16 In the browser window open the origin folder and click on the XZ plane to make it visable.In the Sketch panel click on the plane command to create a work plane. Click on the XY plane and pull the work plane outwared when the dimension box pops open enter 12 mm. Repeat this by creating a work plane in the opposite direction or -12 mm.
Step 17 Creating the motor solder terminals Draw a new sketch on the 12 mm work plane. Draw a rectangle that is 3.0 mm by 5.0 mm that touches the part as shown. Extrude join the part to 2.0 mm.
Step 18 Use the fillet command to fillet the solder terminal to 1.0 mm as shown. Step 19 - Draw the solder terminal hole. Draw a rectangle that is 1.0 mm by 2.0 mm. Add the half circles to the ends of the rectangle.
Extrude the sketch a distance of 2.0 mm.
Step 20 -Repeat creating a solder terminal to the other side of the motor ( the -12.0 mm workplane).
Step 21 - Turn the motor over so that you can see the axle. Use the fillet tool to fillet the edge of the motor to 1.0 mm.
Step 22 - Creating the front air vents On the front of the motor in the same plane as the screw holes create a new 2D sketch. Draw two circles centered at the origin one with a diameter of 14.0 mm and the other 20.0 mm. Draw a radius from the center outward to the left and then another radius also to the left dimension the angle between them to be 52.37 degrees. Draw horizontal and vertical lines so you can place the radius up 16.19 degrees off the horizontal. Use the trim command to remove the parts of the circles that are not need. Use the three point arc command to put half circles and the ends of the vent holes. Extrude cut the air vent holes downward to 10.0 mm