Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Take Assessment - CCNA Intro Cert Prac Exam #1 - CCNA 2 Router and Routing Basics (Version 3.1)
01:44:51
Time Remaining:
The Source Port field is used only if information needs to return to the sending host.
Refer to the exhibit. How many broadcast domains are present in the topology shown?
2
10
11
3
Refer to the exhibit. A network administrator is troubleshooting a problem with the network. On the
basis of the command output in the exhibit, what are some possible causes? (Choose two.)
A cable is not connected to the router.
Which terms correctly describe the network shown in the exhibit? (Choose two.)
logical bus
logical star
logical ring
physical bus
physical star
physical ring
5 Which addresses are valid host IP addresses given the subnet mask 255.255.255.248? (Choose
three.)
192.168.200.87
194.10.10.104
223.168.210.100
220.100.100.154
200.152.2.160
196.123.142.190
6
Refer to the exhibit. A technician applies the configuration in the exhibit to a clean router. To verify
the configuration, the technician issues the show running-config command in the CLI session with
the router. What lines should the technician expect to see in the router output from the show
running-config command?
enable password class
line console 0
password ccna
enable secret cisco
enable password class
line console 0
password ccna
enable secret 5 $1$v0/3$QyQWmJyT7zCa/yaBRasJm0
enable password class
line console 0
password ccna
enable secret cisco
enable password 7 14141E0A1F17
line console 0
password 7 020507550A
enable secret 5 $1$v0/3$QyQWmJyT7zCa/yaBRasJm0
enable password 7 14141E0A1F17
line console 0
password 7 020507550A
Refer to the exhibit. A network administrator can successfully ping, using IP addresses, between
router Jax and router Atlanta. However, when the command telnet Atlanta is entered from the Jax
router, the Telnet connection fails. Which two reasons could be the cause of the failure? (Choose
two.)
The Jax router is not an entry in the host table of the Atlanta router.
The Jax router does not have an entry for Atlanta in its host table.
The hostname command is not configured correctly on the Atlanta router.
10.15.250.5
205.255.16.250
192.15.301.240
172.11.250.212
How many collision domains exist in the network shown in the graphic?
1
10
What can be determined from the output of the ping command in the exhibit? (Choose two.)
There was a destination unreachable error.
What type of cable is used for connectivity between a model 2620 router and a model 2950 switch
(point A), a model 2950 switch and a model 1900 switch (point B), and a model 2950 switch and a
host (point C)?
A – straight-through; B – rollover; C – straight-through
12
Refer to the exhibit. The router named myhome has received a frame from the host 192.168.254.7.
The contents of this frame are being sent to host 172.16.14.243. What is the Layer 2 destination
address of the frame as it leaves the myhome router?
0008.a3b6.ce05
0009.1281.18a8
000a.8a47.e612
172.16.14.129
172.16.14.243
192.168.254.7
13
Refer to the exhibit. If host A sends an IP packet to host B, what will the destination address be in the
frame when it leaves host A?
DD:DD:DD:DD:DD:DD
172.168.10.99
CC:CC:CC:CC:CC:CC
172.168.10.65
BB:BB:BB:BB:BB:BB
AA:AA:AA:AA:AA:AA
aux
console
enable secret
enable password
UDP works well when an application does not need to guarantee delivery of data.
configuration register
18 ABC company needs to connect its router to an ISP to access the Internet. What device is needed
to connect the router to the ISP if the ISP supplies a T1 leased line for the connection?
CSU/DSU
modem
DSL router
NT1 device
ISDN modem
19 What is the subnetwork number for the IP address 150.3.123.18 with a subnet mask of
255.255.224.0?
150.3.0.0
150.3.123.0
150.3.64.0
150.3.96.0
Refer to the exhibit. Four hosts are being added to the 172.16.112.0 network. Which IP address is
invalid as a host address for this network?
172.16.113.55
172.16.112.255
172.16.127.255
172.16.112.89
172.16.120.96
22 A contractor is installing cable for a new hospital network. The cable specifications require that the
network be protected from EMI and have a supported bandwidth of 1000 Mbps. Which cable type
would meet both specifications?
thinnet coaxial cable
23 Given a host with the IP address 192.168.65.54 and a subnet mask of 255.255.255.240, to which
network does the host belong?
192.168.65.16
192.168.65.32
192.168.65.48
192.168.65.64
24 In what order must the configuration tasks be completed to configure an Ethernet interface on a
router when starting from privileged EXEC?
4-1-3-2
2-4-1-3
4-2-1-3
25 If a router is booting with a configuration register setting of 0x2102 and its NVRAM lacks boot
system commands, where will the router try to load the IOS from first?
ROM
RAM
NVRAM
Flash
TFTP server
26
10.192.0.0
10.197.184.0
10.197.187.0
10.197.187.168
27
The devices in the graphic have been configured with static IP addresses from network 192.168.102.0. All
hosts can communicate with each other but cannot communicate with the server. What is causing this
problem?
The IP address assigned to the server is outside of the subnet.
The switch that the server is connected to has not been assigned an IP address.
The router connected to the 192.168.102.96 network is configured for the 192.168.102.64 network.
to allow the receiving host to assemble the packet in the proper order
29 A network administrator is consoled into a router and can connect to www.cisco.com, but cannot
connect to the company web server located in a remote city. Which tool or command would help
identify the specific Layer 3 device causing the connectivity problem?
ping
telnet
ipconfig
traceroute
show tech-support
30 Which two items are required for initial configuration of Cisco routers? (Choose two.)
crossover cable
rollover cable
31 From what location can a router load the Cisco IOS during the boot process? (Choose two.)
RAM
TFTP server
NVRAM
setup routine
Flash memory
terminal
32 Which statements describe the functions or characteristics of ROM in a router? (Choose two.)
stores routing tables
33
Refer to the exhibit. From router R1, the command telnet 192.168.11.2 is entered from privileged
mode and this message displays:
If the R2 interfaces are in the status shown in the exhibit, what is the most likely problem?
The enable secret command is missing from R2.
The login command is missing from the line configuration mode on R2.
The password command is missing from the line configuration mode on R2.
The no shutdown command is missing from the Serial 0/0 interface mode on R1.
34
Which interfaces in the exhibit could be used for a leased line WAN connection? (Choose two.)
1
35
Refer to the exhibit. A network administrator is requesting a file from the Widgets.com server. As the
data is sent from the server, each packet contains four addresses: source IP address, destination IP
address, source MAC address, and destination MAC address. Which addresses change as the data
travels from the Widgets.com server to the network administrator?
Layer 4
Layer 3
Layer 2
Layer 1
36
What can be determined about the network from the exhibited output? (Choose two.)
The MontegoBay router does not have any LAN interfaces configured.
The Negril router is connected to the S0/1 interface of the MontegoBay router.
37
Host A in the exhibit is assigned the IP address 10.118.197.55/20. How many more network
devices can be added to this same subnetwork?
253
509
1021
2045
4093
38
The hosts are connected to the switch as shown. The switches are in their default configuration.
Host A needs to communicate with host D, but host A does not have the MAC address for its default
gateway. Which network hosts will receive the ARP request sent by host A?
only host D
only router R1
39
A small business has asked you for advice about what type of cable will be needed to connect their
modular routers. You are required to identify the type of connectors used by the devices in this
diagram.
WIC-2T is a DB60 connector, WIC1T is a Smart Serial connector, and WIC-1ENET is an
RJ45 connector.
WIC-2T is an RJ45 connector, WIC1T is a DB60 connector, and WIC-1ENET is a Smart
Serial connector.
WIC-2T is a DB60 connector, WIC1T is a Smart Serial connector, and WIC-1ENET is an
RJ45 connector.
WIC-2T is a Token Ring connector, WIC1T is a DB25 connector, and WIC-1ENET is an RJ11
connector.
WIC-2T is a Smart Serial connector, WIC1T is a DB60 connector, and WIC-1ENET is an
RJ45 connector.
40 Which statements are true about TCP operation? (Choose three.)
uses the destination port field to identify remote host