4.7 Connecting the units Gonnect the Antenna cable, powercable andvariousconnecting cablestospecified connectors at the Processorunit, according ta the diagramshown below. Makesure thatthe bowside antenna cable is connectedtaANT1andthesternsideantennacabletaANT2, respectively. GPS Antenna GA-11 Processor unit KGC-1 Bowside Stern side Antenna cable Fuse (3A) '-- } Nav data output (NMEA183) 1 . PS-003A 1 . _. -o' - _.1 0 Bearing data output } '----------. (NMEA183I1EC61162) DC Power Cable CW-255-2M J (.H--ll--, Antennacable 1 To ship'smainssupply Ta ship'sAG supply 100/115VAG 01", 10.8- 31.2 VDC 200/230VAG Fig.4.10 Interconnection diagram of KGC-1 93121652-00 4-9 Chapter4 KGC-1 Installation Operation Manual 4.7.1 Connectorspinoutsofon theProcessorunit POWER ALARM DATA ON 0 D 0 0 0 0 0 0 OFF POWER DATA1 DATA3 ANTl 0 0 0 0 0 MODE GND DATA2 DATA4 ANT2 LocatioriSofconnectorsontheProcessorunit ocXtJ (10.8- 31.2VOC) NMEA1IEC61162IN/OUT CD Ground(GND) Seriai output+(TX+) CD DC+ @) Seriaioutput-(TX-) DC- @ Seriaiinput+(RX+) @ NC @ Seriaiinput-(RX-) NC POWER DATA1- 3 NMEA1IEC61162INIOUT CD Ground(GND) SeriaIoutput+ (TX+) (3) SeriaIoutput- (TX-) , @ Seriaiinput+(RX+) 3) Seriaiinputa-(RX-) +12V(+12V) DATA4 Fig.4.11 ConnectorpinoutsattheProcessorunit 4.7.2 ConnectingtheOC cableCW-255-2MtoOC mainssupply White To Processorunit 1 OC+ DC- 4-10 93121652-00 KGC-1 Chapter4 Operation Manual Installation 4.7.3 ConnectingtheDataConnectingcableCW-376-5M The standard cable CW-376-5M has flying leadson oneendforvarious connection needs. Prepare a suited connector for specifie device ta be connected. The CW-376-5M cable has 6 active leads and shielding braid thatsheathesthese leads.Thewhite (TX+)andred (TX-)leads are usedforsignalline. Referto thefollowingfigureforconnectingan external device. White 0' ~ r ~ "" ' , ~ '. } . Red Non active leads inc'ud'og 'h'e'd'ng,heath muJ be insulated. * Thecableswith connectorsare available on optional basis. Selecta suitable cable listed in Para. 2.5 "Optional items lis!"and Fig. 1.2"KGC-1 Systemconnecting diagram"in Chapter1. 1Appendix 1 ConnectingtheDatacableCW-376-5MtoPC O-SUB 9pin o Blue& Black ~ ~ ~ } Green & . . Red Noconnection o Solderside *TheO-sub connectoris acustomer-supplied item. 4.8Checkupafterinstallation Before turning the uniton, check the following points ta makesure the equipmentfunctions in normal manner. (1) Isthe mainssupplyproperlyrated forvoltage range and currentdrain? (2) Are the Processorunitand the GPSantenna securelyconnected? (3) Isthe Processorunit and radarsetornavigatorunitproperlyconnected? (4) Isthecable layoutweil arrangedand properlydone? RadarorNavigationdevice Rx+(Signal input+/Hot) Rx- (Signal input-/Cold) CAUTION: Thislinemustnot be grounded GND. 93121652-00 4-11