Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Opening Jump Rings Form a Loop Crimp Tubes *Bead pattern - Strand 1: (13) ecru beads, spacer, blue/green cylinder, bead cap, amethyst, bead cap, saucer, bead cap, saucer, bead cap, amethyst, spacer, flat green, spacer, amethyst, double spacers, amethyst, spacer, blue/green cylinder, spacer, bead cap, green large oval. Reverse the pattern starting with the bead cap. Strand 2: (15) ecru beads, spacer, saucer, spacer, saucer, spacer, cylinder, spacer, amethyst, spacer, saucer, spacer, saucer, spacer, saucer, spacer, amethyst, spacer, amethyst, spacer, cylinder, spacer, triple spacers, cylinder, spacer, amethyst spacer. Reverse pattern. Strand 3:(12) ecru beads, cylinder, spacer, saucer, spacer, saucer, spacer, saucer, spacer, cylinder, spacer, amethyst, double spacers, amethyst, spacer, saucer, spacer, bead cap, green oval, bead cap, spacer, cylinder, spacer, saucer, spacer, amethyst, spacer, amethyst, spacer, flat green. Reverse the pattern after the flat green bead.
Necklace Instructions: 1. Thread a head pin through each of the end loops of a three strand spacer. Form a loop. Thread an eye pin through the center hole of the spacer. Form a loop. Repeat this step for a second 3-strand spacer. 2. Cut (3) 25 lengths of beading wire. 3. Using crimp tubes, attach a 4mm jump ring to the end of each wire. Connect the jump rings to the loops of a 3-strand spacer. 4. Using a 6mm jump ring attach a lobster claw clasp to the loop on other side of the 3-strand spacer. 5. Thread the bead pattern onto each beading wire length. 6. Using crimp tubes, attach a 4mm jump ring to each length of beading wire. Trim the excess wire. 7. Connect the jump rings to the loops of a 3-strand spacer. 8. Connect a length of extender chain to the single loop of the 3-strand spacer using a 6mm jump ring.
Earring Instructions: 1. Make the following bead links and drops: (1) flat green round link, (3) amethyst/bead cap/ clear saucer links and (3) blue/ green bicone drops. 2. Thread a head pin through each of the end holes of a 3-strand spacer and form a loop. Thread an eye pin through the center hole of the 3-strand spacer and form a loop. 3. Attach an amethyst/ beadcap/saucer link to the loops of the head pins and eye pins. 4. Attach a blue/green bicone drop to the bottom loops of the amethyst links. 5. Attach the green bead link to the other end of the center eye pin. Connect an earring wire to the loop of the green link. 6. Repeat steps 1-5 for the matching earring.
Skill Level: 3 Approximate Crafting Time: 1 Hour