Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Measurements are taken using NEMO drivetest tool. Equipments used were: Round 1 UE1 - Short call lock U900 UE2 - HSUPA 50MB Mobility UE3 - Idle UE4 - Scanner (10762, 10737, 10712,3012) Round 2 UE1 - Long Call dual Mode UE2 - Idle UE3 - HSDPA 50MB Mobility UE4 Scanner
Idle - Handset will remain idle during the test Short Calls - 60s, 15s delay Long Calls - Unlimited (call will be stop if handover to 2G and force to 3G then unlock back before continue the test) KPI Sources RSCP Scanner EcNo - Idle Mode Inter-RAT handover success rate - Long Call Soft Handover success rate - Short Call Call Setup Time - Short Call Call Setup Success Rate Short Call Call Drop Rate Short Call BLER - Short Call Average Data Throughput (HSDPA/HSUPA) FTP Drivetest (moving) - 50MB File
Cluster INFORMATION
Temp Project Cell ID(3G) Project Site ID (3G) CA20159_4_1 CA20159 CA20159_4_2 CA20159 CA20159_4_3 CA20159 Temp Project Cell ID(3G) Project Site ID (3G) CA50400_4_1 CA50400 CA50400_4_2 CA50400 CA50400_4_3 CA50400 Temp Project Cell ID(3G) Project Site ID (3G) CA20393_4_1 CA20393 CA20393_4_2 CA20393 CA20393_4_3 CA20393 Temp Project Cell ID(3G) Project Site ID (3G) CA20381_4_1 CA20381 CA20381_4_2 CA20381 CA20381_4_3 CA20381 Temp Project Cell ID(3G) Project Site ID (3G) CA20380_4_1 CA20380 CA20380_4_2 CA20380 CA20380_4_3 CA20380 Temp Project Cell ID(3G) Project Site ID (3G) CA20157_4_1 CA20157 CA20157_4_2 CA20157 CA20157_4_3 CA20157 Temp Project Cell ID(3G) Project Site ID (3G) CA20155_4_1 CA20155 CA20155_4_2 CA20155 CA20155_4_3 CA20155 Temp Project Cell ID(3G) Project Site ID (3G) CA20151_4_1 CA20151 CA20151_4_2 CA20151 CA20151_4_3 CA20151
E. Tilt 4 3 0
RAC 1 1 1
Primary Scrambli UARFCN ng Code 3012 159 3012 167 3012 175
LOC ID
B01211
B01211 B01211
E. Tilt 2 2 2
Cluster 0 0 0
RAC 1 1 1
Primary Scrambli UARFCN ng Code 3012 265 3012 110 3012 337
LOC ID
B00570
B00570 B00570
E. Tilt 2 2 2
Cluster 0 0 0
RAC 1 1 1
LOC ID
B00787
B00787 B00787
E. Tilt 2 2 2
Cluster 0 0 0
RAC 1 1 1
Primary Scrambli UARFCN ng Code 3012 375 3012 383 3012 391
LOC ID
B00106
B00106 B00106
E. Tilt 2 2 2
RAC 1 1 1
Primary Scrambli UARFCN ng Code 3012 255 3012 263 3012 271
LOC ID
B00105
B00105 B00105
E. Tilt 2 2 2
RAC 1 1 1
Primary Scrambli UARFCN ng Code 3012 231 3012 239 3012 247
LOC ID
B00750
B00750 B00750
E. Tilt 2 2 2
RAC 1 1 1
Primary Scrambli UARFCN ng Code 3012 201 3012 377 3012 301
LOC ID
B00738
B00738 B00738
E. Tilt 2 2 2
RAC 1 1 1
Primary Scrambli UARFCN ng Code 3012 207 3012 215 3012 223
LOC ID
B00102
B00102 B00102
Temp Project Cell ID(3G) Project Site ID (3G) CA20150_4_1 CA20150 CA20150_4_2 CA20150 CA20150_4_3 CA20150
E. Tilt 2 2 2
RAC 1 1 1
Primary Scrambli UARFCN ng Code 3012 135 3012 143 3012 151
LOC ID
B00544
B00544 B00544
Short Call 0 0 0 0 2 0 0 0 0 0 0
Long Call 0 0 0 0 0 0 0 0 0 0 0
Short Call 0 0 0 0 0 0 0 0 0 0 0
Long Call 0 0 0 0 0 0 0 0 0 0 0
FUNCTIONALITY TEST
Site Name Voice Call Video Call Sector 1 Sector 2 Sector 3 Sector 1 Sector 2 Sector 3 OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK Sector 1 HSDPA Static Sector 2 Sector 3 4.01Mbps OK 4.91Mbps OK HO Test Feeder Swap No No No No No Lock due to RTWP 4.71Mbps 4.65Mbps 5.05Mbps OK No Average simultaneous user during test is 22 user Remarks Sec2 lock due to RTWp Sec2 lock due to RTWp
3.47Mbps 4.14Mbps
OK
OK
OK
OK
OK
OK
No
C_BDRSUNWAY_U9 C_SS5PJ_U9
OK
OK
OK
OK
OK
OK
No
**Night time DT
Scanner SC (3012)
**Daytime DT
Scanner SC (3012)
Scanner SC (10762)
Scanner SC (10762)
**Night time DT
Scanner Pilot Pollution Plot (3012) After Downtilt Pilot Pollution Plot (3012)
**Daytime DT
UE EcNo
**Night time DT
Active SC
UE EcNo
**Daytime DT
Active SC
UE EcNo
**Night time DT
Active SC
UE EcNo
**Daytime DT
Active SC
IFHO
114
98.26% 0 0
14
100%
21 21 1951
1308
CAF
Call Attempt 13Nov01 004023_CLUSTER_DRIVE_N26_01.1 Failure Call Attempt 13Nov01 015051_CLUSTER_DRIVE_N26_04.1 Failure
900 Adjacencies
CAF
900 Adjacencies
Observation: CAF due to missing neighbor between TMN_UNIV_PJ_6712 SC357 and C_SS5PJ_U9_6483 SC151 Suggestion: define neighbor between TMN_UNIV_PJ_6712 SC357 and C_SS5PJ_U9_6483 SC151
Observation: During VDT, UE camp at C_SS5PJ_U9_6483 SC151 since C_SS5PJ_U9_6483 is the dominant serving cell at that area. No more call attempt failure. Cell reselection is successful.
Observation: CAF due to missing neighbor between C_SS15SBJ_U9_6521 SC177 with SS12_SBJ_U9_6862 SC24, C_SUMMITUSJ_U9_6383 SC221 and PJS11_SNWY_U9_6783 SC271 Suggestion: define neighbor between C_SS15SBJ_U9_6521 SC177 with SS12_SBJ_U9_6862 SC24, C_SUMMITUSJ_U9_6383 SC221 and PJS11_SNWY_U9_6783 SC271
Area A
Area C
Area B
Area D
Area F
Area E
Best SC 3012
EcNo CPICH
Pilot Pollution
Observation: EcNo is bad along Glenmarie exit. No dominant serving cell at problem area. Nearest site is MASTRAINING and JLN_KEMAJUAN. Suggestion: Downtilt overshooting site -- C_SUMMITUSJ_U9_6383 -- C_SS15SBJ_U9_6521 -- SS13_SBJ_U9_7423
Area B
EcNo CPICH
Pilot Pollution
Observation: EcNo is bad along federal highway. No dominant serving cell at that area and there is a bit pilot pollution Suggestion: 1. Downtilt overshooting site -- TMN_UNIV_PJ_U9_6712 -- SS9_PJ_U9_6762 2. Swing antenna C_SS5PJ_U9_6482 from 200deg to 230deg to be dominant along Federal highway. 3. Propose new U900 site to cover along federal highway
Area C
EcNo CPICH
Pilot Pollution
Observation: EcNo is bad due to no dominant serving cell at that area and there is a bit pilot pollution. Nearest site, SS5_PJ sector 2 is block by building Suggestion: 1. Downtilt overshooting site -- TMN_UNIV_PJ_U9_6712 -- SS9_PJ_U9_6762 --
Area D
EcNo CPICH
Pilot Pollution
Observation: EcNo is bad along Glenmarie federal highway. No dominant serving cell at that area and there is a bit pilot pollution Suggestion: 1. Downtilt overshooting site -- SS9_PJ_U9_6762 -- TMN_UNIV_PJ_U9_6712 2. Swing antenna C_PJS7 SUNWAY U2100 to follow U900 coverage
Area E
EcNo CPICH
Observation: EcNo is bad due to no dominant serving cell. Nearest site, SUBANG_PERMAI is locked due to RTWP Suggestion: 1. Downtilt overshooting site -- JLN_TEMPUAPCHG_U9_6883 -- USJ_10_U9_6841 2. Swing antenna C_PJS7 SUNWAY U2100 to follow U900 coverage 3. VDT after SUBANG_PERMAI is on air
Area F
EcNo CPICH
Observation: EcNo is bad due to no dominant serving cell. Nearest site, C_SUMMITUSJ sector 1 is locked due to RTWP. All serving cell is 1st tier neighbor, within 1.5 km radius Suggestion: 1. Downtilt overshooting site -- SS19SBJ_U9_7501 2. VDT after C_SUMMITUSJ sector is on air
F E
F E
This area experiencing blocking at Glenmarie exit as discuss above. To improve pilot pollution, propose to downtilt further C_SUMMITUSJ sec 3 and uptilt MASTRAININGCT_U9_6502 to make it dominant at problem area
Propose to colocate U900 at LDPFEDERAL_ITC to cover along federal highway. This site is the dominant serving cell for U2100 coverage at problem area
All serving cell is 1st tier neighbor. Dominant cell is TMN_UNIV_PJ_6712. Propose to downtilt overshooting sites and reduce CPICH for 1st tier neighbor Downtilt -- C_JBASS2PJ_7232 -- SGWAY_64513 -- SS3PJ_6102 Reduce CPICH --KM12GLENMARIE_7291 (Etilt already max, antenna
No dominant cell is due to C_SUMMITUSJ_U9_6381I is locked due to RTWP. Serving cell is all 1st tier neighbor and some area is served by side lobes.
No dominant cell is due to SUBANGPERMAI is locked due to RTWP. Downtilt overshooting sites can reduce pilot pollution Downtilt -- USJ_10_U9_6841 -- PST_BDR_PCHG2_U9_6893 -- IOI_PUCHONG_U9_6933 -- JLN_TEMPUAPCHG_U9_6883
Action List :
No. 1 2 3 4 5 6 7 8 9 10 Source C_SUMMITUSJ_U9 C_SS15SBJ_U9 SS13_SBJ_U9 SS1_PJ_U9 TMN_UNIV_PJ_U9 SS9_PJ_U9 KM12GLENMARIE_U9 JLN_TEMPUAPCHG_U9 USJ_10_U9 SS19SBJ_U9 Problem Area USJ USJ USJ USJ Sg Way PJ Glenmarie Sunway USJ USJ PJ 11 C_SS5 PJ_U9 Sunway 12 C_PJS7 SUNWAY Subang Jaya 13 14 BACK C_SS15SBJ_U9 TMN_UNIV_PJ_U9 PJ 46521 46712 Call Attempt Failure PJ 10491 , 10492 , 10493 46481 , 46482 , 46483 Region Creator Dept Event Cell ID 46383 46521 47423 46282 46712 46762 47291 46883 46841 47501 Category Bad EcNo Bad EcNo Bad EcNo Bad EcNo Bad EcNo Bad EcNo Bad EcNo Bad EcNo Bad EcNo Bad EcNo Antenna misalignment Antenna misalignment Call Attempt Failure Location USJ USJ USJ USJ Sg Way PJ Glenmarie Sunway USJ USJ PJ Problem Overshooting Overshooting Overshooting Overshooting Overshooting Overshooting Overshooting Overshooting Overshooting Overshooting Antenna misalignment Antenna misalignment Action Reduce CPICH power from 330 to 300 Downtilt sec1 from M0 to M2 Downtilt sec3 from E0 to E2 Downtilt sec2 from E2 to E4 Downtilt sec2 from E2 to E4 Downtilt sec2 from E2 to E4 Downtilt sec1 from E7 to E8 Downtilt sec3 from E0 to E2 Downtilt sec1 from E0 to E4 Downtilt sec1 from E2 to E4 Swing sec1 from 80deg to 120deg Swing sec2 from 200deg to 230deg Swing sec3 from 300deg to 330deg Swing sec1 from 0deg to 80deg Swing sec2 from 120deg to 180deg Swing sec3 from 240deg to 330deg Define neighbor between C_SS15SBJ_U9_6521 SC177 with SS12_SBJ_U9_6862 SC24, C_SUMMITUSJ_U9_6383 SC221 and PJS11_SNWY_U9_6783 SC271 Define neighbor between TMN_UNIV_PJ_U9_6712 SC357 and C_SS5PJ_U9_6483 SC151 Open By Yati Yati Yati Yati Yati Yati Yati Yati Yati Yati Yati 29-Nov-13 Closed Open Date 4-Dec-13 4-Dec-13 4-Dec-13 4-Dec-13 4-Dec-13 4-Dec-13 4-Dec-13 4-Dec-13 4-Dec-13 4-Dec-13 Status BSC owner/Responsibility Closed Closed Closed Closed Closed Closed Closed Closed Closed Closed Remarks Issue
Sunway
Yati
29-Nov-13 Closed
Yati Yati
222644400.xlsx.ms_office
N26
C_SS15SBJ_U9
CAF
N26
TMN_UNIV_PJ_U9
CAF
CAF due to missing neighbor between C_SS15SBJ_U9_6521 SC177 with SS12_SBJ_U9_6862 SC24, C_SUMMITUSJ_U9_6383 SC221 and PJS11_SNWY_U9_6783 SC271 CAF due to missing neighbor between TMN_UNIV_PJ_6712 SC357 and C_SS5PJ_U9_6483 SC151
Adjacencies
Adjacencies
Define neighbor between C_SS15SBJ_U9_6521 SC177 with SS12_SBJ_U9_6862 SC24, 13Nov01 C_SUMMITUSJ_U9_6383 SC221 and 015051_CLUSTER_DRIVE_N26_04.1 PJS11_SNWY_U9_6783 SC271 Define neighbor between 13Nov01 TMN_UNIV_PJ_6712 SC357 and 004023_CLUSTER_DRIVE_N26_01.1 C_SS5PJ_U9_6483 SC151
Yati
Closed
Yati
Closed