Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
SECTION: A Q1) Attempt all questions (10*2=20 M) a) Write relation between branch voltage matrix, twig voltage matrix and node voltage matrix in graph theory. b) What are Isomorphic graphs? Give examples. c) State Millmans Theorem with example. d) Explain limitations of Superposition theorem. e) How poles can be used to determine the stability of a system? f) What are the conditions to be satisfied for a polynomial P(s) to be Hurwitz? g) Explain T parameters in terms of Y parameters. h) Derive the condition of symmetry for h- parameters. i) Differentiate between Foster form and Cauer form . j) Define low pass and band pass filter.
SECTION:B Note: Attempt any three questions Q2) (a) Write the fundamental loop matrix of the network:
2 ohm 2 ohm
(3*10=30 M) (5 M)
10V
2 ohm
(b) Determine current in capacitor branch by superposition theorem for the following circuit:
(5 M)
j 4 ohm
3 ohm
3 ohm 2 90 A - j 4 ohm
4 0V
Q3) (a) Verify Reciprocity theorem for the circuit shown below:
(5 M)
10 ohm
-j 20 ohm
A I AB
j 25 ohm
j 25 ohm
.
1 ohm I1 1A 5 ohm
B
(5 M)
(b) Find Nortons equivalent of the circuit at the left of the terminals A-B (given = 2).
. .
I1
Q4) (a) Determine the stability of the system whose characteristic equation is given by
(5 M)
s + s + 2s + 2s + 3 = 0
(b) In the network shown, find VC(s) / V (s) (5M)
4s
I
V(s) 8 ohm
Ic
2/s
IR
(5 M)
F(s) =
s +s+6 s2+s+1
(5 M)
(b) A series LCR type band pass filter has R = 1.5 k, L = 140 mH and C = 300 pF. Find the (i) Resonant frequency (ii) Bandwidth and cut off frequencies.
SECTION:C
Note: Attempt all questions (5*10= 50 M) Q6) Draw the oriented graph of the network shown. Obtain the tie set matrix and write the network equations on loop analysis.
.
1V
2H
M= 0.5 H
1H
1 ohm
Q7) For the network shown , find the value of Z that will receive maximum power. Also determine the power.
Q8) Obtain the time domain response for the given system function: H(s) = (s + 1)(s + 5) s (s2 +2s +2) (s+7)
OR
Write necessary conditions for driving point function and transfer function. Q9) Determine transmission parameters of network given below. Considering section as shown are connected in cascade manner.
1 ohm 1 ohm 5 H
1 F
2 ohm
Q10) Realize the following RC driving point function in (i)First Foster form (ii) Second Cauer form Z(s) = s ( s2 + 4 ) (s2 +1)(s2+9)