Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Email: _________________________________________________
The QC Group, Inc. All rights reserved 5950 Clearwater Drive Suite 300, Minnetonka, MN 55343 (952) 895-1150 ph (952) 895-1152 fax
Rev. 3 Page 1 of 4
6. The MMC concept does not apply to A. Perpendicularity B. Flatness C. Parallelism D. All of the above 7. How many points of contact are required to establish a secondary datum on a rectangularshaped part? A. 1 B. 2 C. 3 D. 4 8. Rule #1 states that. . . A. perfect form at MMC is required B. perfect form at MMC not required C. RFS is the default condition D. RFS is optional Questions 9 - 11 refer to the drawing at the right. 9. Datum A is. . . A. The right edge (plane) of the part B. a planar datum C. the centerplane of the 62 - 60 width D. the centerplane of a 62 wide boundary 10. The amount of datum shift permissible for the Position control is. . . A. 1.0 B. 2.0 C. 3.4 D. 4.0 11. The amount of bonus tolerance permissible for the Position control is. . . A. 1.4 B. 2.0 C. 0.3 D. 1.0
The QC Group, Inc. All rights reserved 5950 Clearwater Drive Suite 300, Minnetonka, MN 55343 (952) 895-1150 ph (952) 895-1152 fax
Rev. 3 Page 2 of 4
12. Whenever a Position control is used without a modifier, A. The tolerance is subject to accumulation B. No bonus tolerance is available C. Tolerance zone is projected to the stated depth D. All of the above 13. The _______________ contains the tolerances for geometric controls. A. Title Block B. Revision Block C. Feature Control Frame D. None of the above
Questions 14-16 refer to the drawing to the right. 14. The maximum amount of datum shift permissible with the TOP control is. . . A. 0.1 B. 0.2 C. 0 D. 0.6 15. The tolerance value in the perpendicularity control is. . . A. illegal this is impossible to manufacture B. applied at RFS C. effective in reducing scrap D. applied at LMC 16. The parallelism control. . . A. limits the flatness of the surface to 0.1 B. overrides Rule #1 C. does not control the flatness of the surface D. is illegal
The QC Group, Inc. All rights reserved 5950 Clearwater Drive Suite 300, Minnetonka, MN 55343 (952) 895-1150 ph (952) 895-1152 fax
Rev. 3 Page 3 of 4
Questions 17 - 25 are true or false. Circle the correct answer. 17. The tolerance zone for a Circularity is always two coaxial cylinders T F
18. Coordinate tolerancing should be used to locate critical holes. 19. 12.2 12.3 is a plus-minus tolerance.
20. The tangent plane modifier is not used with the flatness control.
21. The tolerance zone for a Straightness control is two parallel lines.
24. Tolerances for basic dimensions are located in the title block.
25. A feature control frame must contain at least one datum reference and no more than three.
The QC Group, Inc. All rights reserved 5950 Clearwater Drive Suite 300, Minnetonka, MN 55343 (952) 895-1150 ph (952) 895-1152 fax
Rev. 3 Page 4 of 4