Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
dl
en
gth
2) Balcony(Cantilever)
tension fixation
spacer
spacer
vertical/horizontal D10-@220
spacer
spacer
The most important part in cantilever is the bar at the top above distribution bars. It is common to anchor the top bars into a beam, however, they can be anchored in a slab so long as there is no difference between their levels. To obtain adequate fixed length is most important. Bars at the bottom should be anchored securely to provide for earthquake and tornado. When the level of cantilever and slab plate are different, bars in the slab should be anchored onto the beam. If the bars at the top are bent to be anchored onto the opposite slab, there might be a crack due to tensile strength. The bars at the top should be maintained with bar support.
Parapet might occur vertical crack mainly because the length is long. It is effective to avoid crack by arranging to outside of horizontal rebar.
m in .1 20
In case open part is over 300mm, 4 edges should reinforce 1-HD16 Use 90 standard hook rebar Explanation : 1) In case the length of open part is over 1,000mm , you should arrange after receipt of permission of structure supervisor if there are no rebar arrangement detailed drawing. 2) *mark :arrange to single arrangement if established rebar arrangement is single arrangement arrange to double arrangement if established rebar arrangement is double arrangement 3) ----- is established slab rebar 4) Rebar to not specified of rebar size must use same size rebar as established arrangement
Reinforce each rebar to both open part as rebar distance 75mm for +1 unit of rebar Qty to be cut existing rebar from open part.
Explanation : 1) In case the size of open part is D<150mm, omit vertical & horizontal rebar 2) mark : arrange to single arrangement if established rebar arrangement as siugle(double arrangement as double) Square type open part
min. 600 min. 600(TYP)
open part