Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
T A
I LI EB S!
R
UT T R TE
L N A
CA CIE HE FINALLY,
LO FFI GE
O
UR Y E RA A CURE FOR
Y RG GA
K E R
AS EN NO
THE “COMMON COLD”
O
UT RE
Z
GARAGE
AB ON
Model UDAS
Disconnect Switch*
Safety Door Interlocking Switch*
Model UDAP
Model Model
Features Benefits UDAP UDAS
Compact design improves overhead clearance, allowing for more headroom than
Low Profile Y Y
conventional unit heaters
Titanium Stabilized, Corrosion Heating elements in the units are designed to provide long life. Heat exchangers
Resistant Aluminized Steel Heat are backed by a 10 year warranty (parts only, see limited warranty form for complete Y Y
Exchangers details). Stainless steel heat exchangers also available.
Patented Tcore2® developed by Reznor provides you the highest efficiency of any
Single, One-Piece Burner
unit heater in this class. Higher efficiency (up to 83% efficiency) means less natural Y Y
Assembly
gas/propane is needed. Saves you money. (U.S. Patent No. 6,889,686)
Separated Combustion Air for combustion is drawn through a flue pipe from the outside* Y
An electronic pilot replaces the old standing pilot which could be blown out when a
Spark Ignitor - No Standing Pilot Y Y
garage door is open on windy days.
A small blower is used to force exhaust gases through the flue. This makes the
Power Vented heater more efficient. A smaller flue pipe is required which also saves you money on Y Y
installation costs.
The flue pipe can run vertically through the ceiling/roof in the traditional method. Or,
Horizontal or Vertical Flue
it can run horizontally through a side wall when vertical venting is not practical (for Y Y
Venting
example: when there is living space over the garage).
The garage heater can be operated independently from the home furnace by a
Separate Wall Thermostat Y Y
separate thermostat mounted in the garage.
Multiple Fuels Heater can use natural gas or propane (Conversion kit may be required). Y Y
Integrated Circuit Board with
Designed to assure safe reliable operation and easy maintenance Y Y
LED Diagnostic Indicator Light
CSA International Requirement
Be sure to get only units, “Approved for Installation in Residential Garages.” Y Y
10-96
* Model UDAS uses outdoor air/oxygen for combustion inside the heater. Keeping the flame separate from air in the garage is very important if you
plan on auto repair or restoration, woodworking, stripping paint, refinishing furniture, or storing certain chemicals in the garage.
©2008 Thomas & Betts Corp. All rights reserved. Printed in U.S.A.
OG 10M 1208 Form RGM-F-GH (Version G)
1-800-695-1901 www.RezSpc.com