Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Level controls for Multimedia (Line) Sources Teacher and Student Volumes are remotely controlled from the Teacher Microphone and not from the front panel of the amplifier. See page 3 for detailed remote volume control information. Front panel line level output for Assistive Listening Device (ALD) such as a student FM transmitter Front panel line input for a portable device
Step 1. Position the Micro Teardrop Teacher Microphone with the black back of the microphone facing towards you. Step 2. Align the charger connector so that the small triangle shaped arrow on the charging connector is facing you. Step 3. Insert the connector into the microphone.
A momentary press of PWR button See page 3 for detailed will Mute/Unmute microphone SAFE System audio. If muted for more than information 5 minutes, the microphone will automatically turn off.
- Line Input 3
CAT5 Cable
- Line Input 2
- Line Input 1 Line Output paralleled with front panel for use with ALD Line Input TRS 3.5 mm front panel connector. Disconnects rear panel Line Input1connector For use with ALD TRS 3.5 mm unbalanced stereo. Paralleled with rear panel line out ALD/Line Output When using 4 speakers, wire ceiling speakers in parallel in the ceiling - bringing one speaker wire per pair to the CA-50 Amplifier channel.
Power ON/OFF
Ceiling Speakers Use set of tin leads and connect to the speaker. Then cut the speaker wires to appropriate length. Strip the newly cut ends to bare copper before inserting into the scew compression terminals.
Bad
DC Power Supply
Good
If your classroom is equipped with the SAFE System you can send an alert by pressing and holding the Function button on your microphone. The Red CHG light will illuminate on the face of the microphone and three Red LEDs will illuminate on the ceiling mounted IR-Satellite dome sensor indicating that the ALERT signal has been sent.
Press either the UP or DOWN arrow button to increase or decrease the level of the Teacher microphone. A blue LED over the OWN (for own microphone) will flash with each press. The appropriate LED (#1) on the dome sensor will blink with each button press of UP or DOWN.