Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
:
Notes Specified value Type 4/DOHC cc 1749 :1 10,8 Yes Measured value
Vehicle identification
No. of cylinders Capacity (Fiscal) Compression ratio Suitable for unleaded petrol Minimum octane rating Ignition system Ignition system Ignition system Trigger location Fuel system Fuel System Fuel System Air metering Combined ignition and fuel ECM Diagnostic socket
Make Sagem
RON 95
Description Map-DI Make Sagem Description MFI-s Type MAP Yes Yes Make Sagem + with ballast V 12,0
Ignition system
Ignition coil Ignition coil
Firing order
Vol. % CO 0,5 Max Not adjustable Vol. % CO2 0,9 Min Vol. % O2 0,1-0,5 Vol. % 0,3 rpm 2200-2300 0,97-1,03 ppm 100
Spark plugs
Spark plugs Spark plug Electrode gap Spark plugs Spark plug Electrode gap
Type RFN52HZ
Type FR8ME
Fuel system
Injector
mm Hydraulic
SAE 0W/40 Synthetic SAE 5W/40 Synthetic API/ACEA SJ/A3-98 API/ACEA SJ/A1-98 litres 4,25 SAE 15W/50 Synthetic SAE 10W/40 Semi-synthetic
litres 1,85-2,0 Type DOT 4 litres 8,8 litres 0,5 litres 1,3
Type Dexron II
Tightening torques
Cylinder head
Stage 1 Stage 2 Other tightening torques Main bearings Main bearings Main bearings Big end bearings Big end bearings Big end bearings Oil pump to cylinder block Sump bolts Sump drain bolt Flywheel/driveplate Clutch to flywheel 86 Crankshaft pulley/damper centre bolt Camshaft sprocket/gear Camshaft carrier/cap Camshaft/rocker cover Inlet manifold to cylinder head Exhaust manifold to cylinder head Spark plugs Fuel rail Lambda sensor (Oxygen) Knock sensor (KS) Engine oil pressure switch Front hub Rear hub Steering wheel Steering rack/box mounting Steering track rod end Brake disc to hub Brake caliper to carrier Brake caliper carrier to hub Brake disc to hub Stage 3
Renew bolts/nuts No
Stage 1 20 Nm Stage 2 60
Renew bolts/nuts No
Front 102-138 Nm
Front 10 Nm Rear 10 Nm 90 Nm
Air conditioning
Air conditioning refrigerant Air conditioning refrigerant quantity Air conditioning oil Air conditioning oil quantity Air conditioning oil viscosity
grams 600
cm 13515
Autodata Note 86 Crankshaft pulley If fitted with steel washer: 1) 40 Nm 2) 534 If fitted with sintered washer: 1) 40 Nm 2) 404. Cylinder layout Tightening sequence