Sei sulla pagina 1di 2

PADEYE DESIGN CALCULATION

Static empty mass weight uncertainty CG uncertainty DAF (Dynamic amplification factor) Total dymanic mass Min Number of slings used Included angle between slings Maximum sling tension DESIGN TO AS4100 Working load limit Load factor Sling angle from horizontal Offset loading angle from x-z Plane LUG GEOMETRY WLL = LF = = = 43 KG 1.5 60 degrees 5 degrees 50 kg 1 1 1.5 75 kg 2 60 degrees 43 kg

Cheek plate thickness (each)


Lug thickness OD of contact area Hole diameter Pin diameter Lug Base length Yield Stress Tensile Stress Capacity factor Correction factor (symetrical lifting) Weld metal Ultimate Strength Design Shear force Gross Area Net Area Net area required Base cross section area

t=
tp = d1= Pd= df = B= fy= fu= f= k t= Fuw= Table 9.7.3.10(1) N*= WLL * LF * 9.81 Ag = tp x d1 An = 0.25 * PI * (d1^2 - Pd^2) Anr = N*/(0.9fy) = Aw = B x tp =

0 6 50 19 16 75 125 410 0.9 1 170 637 300 1680 6 450

mm mm mm mm mm mm Mpa MPa AS4100 table 3.4 AS4100 table 7.3.2 MPa N mm^2 mm^2 mm^2 mm^2

Bearing Stress on pin hole (AS4100 9.5.1) Nominal Bearing capacity Vb =

Utilisation coefficient

3.2 df tp fu = ae tp fu = ae = (d1-Pd+df)/2 ae tp fu = fVb = Lower of N* <= fVb N*/fVb = UC = and where Vb =

125952 N 23.5 mm 57810 N 52029 N OK 0.01

Members with pin connections (AS4100 7.5) Tickness ratio <1? Net area beyond hole ratio <1? Area in way of hole ratio <1?

0.25(d1-Pd)/2/tp = Anr/(tp(d1-Pd)/2) = 1.33Anr/(tp(d1-Pd)/2) =

0.65 0.06 0.08

OK OK OK

Gross section yield under tension (AS 4100 Section 7) fNt = Ag fy = Nominal section capacity and fNt = 0.85 kt An fu = fNt = Lesser of values Nominal section capacity Utilisation coefficient UC2= N*/fNt= Horizontal shear capacity (AS 4100 Section 5.11.4) Horizontal shear load on x-y plane V*w = N* x cosB = Shear capacity Vw = 0.6*fy Aw = V*w /f Vw = Shear capacity ratio Bending about base (AS 4100 Section 5) Since shear load is less than 60% of member shear capacity, effects on tensile and bending capacity can be ignored. Weld Strength Calculation for full penetration fillet weld (AS4100 9.7) Capacity factor of a weld = Table 3.4 Effective length of weld = Reduction factor = Design throat thickness = Design force per unit length = = Nominal Weld Capacity per U/L = = 0.6 Weld strength ratio

33750 N 1776 N 1776 N 0.36

OK

319 N 33750 N 0.01

OK

0.8 150 1 8 4.2 816 0.01

mm mm Nmm Nmm OK

Potrebbero piacerti anche