Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Objective;
The aim of this experiment is to familisrize students with topologies of basic output stages such as class A and B amplifiers .
Equipment:
a)2N2222(npn) and 2N2907 (pnp) transistors b)Two 1N914 discreate diodes. c)RL=10 and different value of resistors
Prelab: Part1
a)RL=10k Vcc=5 =0.52mA VD=0.5V | |
R=(5-0.7)/0.5mA=8.6k
b)Vomax=4.8v Vo min=-4.8v
C) There is a gain =1 because its a voltage follower circuit also we can see on the graph ;
gain=1/1=1
b)Vo min =-5+0.2=-4.8v Vo max= 5-0.2=4.8v c)gain is 1 when v=between *0.5 Vcc-Vce+Vbe1]
INTRODUCTION:
Class A Output Stages
The circuit illustrated in Figure and discussed in the previous section is an example of a Class A amplifier stage. Class A amplifiers have the general property that the output device(s) always carry a significant current level, and hence have a large Quiescent Current. The Quiescent Current is defined as the current level in the amplifier when it is producing an output of zero. Class A amplifiers vary the large Quiescent Current in order to generate a varying current in the load, hence they are always inefficient in power terms. In fact, the example shown in Figure is particularly inefficient as it is Single Ended. If you look at Figure again you will see that the amplifier only has direct control over the current between one of the two power rails and the load. The other rail is connected to the output load through a plain resistor, so its current isnt really under control.
We can make a more efficient amplifier by employing a Double Ended or Push-Pull arrangement. Figure is an example of one type of output stage that works like this. You can see that this new arrangement employs a pair of transistors. One is an NPN bipolar transistor, the other is a PNP bipolar transistor. Ideally, these two transistors have equivalent properties e.g. the same current gains, etc except for the difference in the signs of their voltages and currents. (In effect, a PNP transistor is a sort of electronic mirror image of an NPN one.)
we observe these values ; volt1=41.6mV volt2=359mV =0.4mA Vopeak =RL*I Vopeak=0.4mA*10k Vopeak=4volt
efficency; n=(4^2/20k)/2*5*0.4mA 20% efficeny here. gain =there is a 10v/v gain in prelab this was 1 because of low signal but there is high signal operation
POSTLAB:
analog analysis of DC
These graps are so different from other graps which we find at lab because of operation. At the lab we find graphs for high signal operation but there is low signal operation.
Conclusion:
At this lab I learnt ClassA and Class B working principles. Also diffrences between high signal and low signal operations on A class and B class. Seeing these differences was so useful for me .