Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
2. What are the functionalities in the MSC/MSC-S node? Explain the clearly the call
setup procedure for a call between:
a) Tigo to Tigo.
b) Tigo to any other local operator.
4. What are the functionalities available in HLR? Giving the command HGSDP(see
ALEX) briefly explain the function of each:
a) PERMANENT SUBSCRIBER DATA
b) SUPPLEMENTARY SERVICE DATA
c) LOCATION DATA
d) PACKET DATA PROTOCOL CONTEXT DATA
5. Which board enables the C7ST2C (Signaling Terminals)? Issuing the command
C7STP(see ALEX) briefly state the meaning and functions of ST, ITYPE, RP,
EM, LS, SPID, SLC, NP
6. What are the boards that can be used both in MSC and BSCs?
7. What is the capacity of STM-1 in terms of E1s? What does the term 2Mb/s
means? Prepare one full DT to add 20 E1s from DAMSC02 route towards
International link via Zantel (Use CIC and E1 numbers as a continuation from the
existing ones.)
9. What is the functionality of OMS? Referring our current Tigo setup, where do we
have OMS nodes and for what purpose are they being used?
10. In MSC/MSC-S Differentiate between the functionalities of CP and APG?
12. What are the different types of CPUs used in our network? What are different
types of APGs used in our network?
13. Which board does the Transcoder function at BSC? Prepare one DT to add a new
site ‘Tangani’ with the following details:
• Cell name is TNG052 (3 sectors, GSM900)
• CGI=640-02-27-1202,
• BSIC=51,
• BCCHNO=11,
• AGBLK=1,
• MFRMS=8,
• BCCHTYPE=NCOMB,
• FNOFFSET=0
• MEASUREMENT FREQUENCIES 8&&19
• No neighboring sites and uses all other data from existing TNG002A.
15. Describe the design of MGW (suggested to pay a visit with a book on hand and
see the node physically to fully get the picture). What are the different
functionalities supported by MGW?