Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
SpectralWave C-Node
2M Tributary
Additional External Clock port can be configured on FAN board for redundancy.
69
C-Node supports various synchronization sources a. STM-N Line b. 2M(120 or 75ohm) Tributary c. 2M(only 75ohm) External Clock
Conf-69
SpectralWave C-Node
70
To add a new timing source: Click the Add button on the bottom of the Setup-NE Timing Source Configuration dialog box. The Set Timing Source dialog box (see Figure above ) will be displayed. Timing Source Displays the list of timing source for selection. System/Bypass Displays the system timing source and bypass timing source. System clock is the working clock for phase-lock loop of SDH system, and export clock is the independent output clock system. Receive SSM Set Value Sets the QL (quality level) of this receiving timing source, which is valid when SSM protocol is selected. Transmit SSM Mode Select Force or Auto from the drop-down list. When Force is selected, the selected port will be forced to send QL of the timing source. When Auto is selected, the QL of the timing source sent at the selected port is that of the current operating reference clock. In this case, the current operating reference clock is not the timing source of the selected port. Force Transmit SSM Value Force the selected port to send QL value of the timing source. Priority Set the priority of the timing source manually. The highest priority is 1, and the lowest is 256.
Conf-70
SpectralWave C-Node
71
Conf-71
SpectralWave C-Node
72
Conf-72
SpectralWave C-Node
73
When all the settings required for NE setup (initialization) are completed, the Setup-NE Attributes Configuration dialog box is displayed as shown in Figure above: In this dialog box, perform one of the followings: To download any data to NE, click the check box Download (leaving a tick) and adjust the system time. To modify any settings for NE setup again, click the Back button on the Setup-NE Attributes Configuration dialog box to go back to the Setup-NE Clock Module Configuration dialog box. To complete the setting for NE setup (initialization), click the End button on the Setup-NE Attributes Configuration dialog box. To cancel and quit the NE setup, click the Close button on the SetupNE Attributes Configuration dialog box. Now the setting for NE setup (initialization) is completed.
Conf-73