Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Cola®Mulse DL-120
Page 1 of 4
Colonial Chemical, Inc. Emergency Telephone #
225 Colonial Drive 423/837-8800
S.Pittsburg, TN 37380 Chemtrec 800/424-9300
SECTION I – PRODUCT INFORMATION
Product Name: Cola®Mulse DL-120
Product Class: Surfactant mixture
Health Hazard Ratings: Health – 1 Flammability – 1 Reactivity – 0 PPI – B
PROPRIETARY BLEND
Chronic Information: Repeated skin contact may cause persistent irritation or dermatitis.
FIRST AID:
Eye Contact: Immediately flush with copious amounts of water for at least 15 minutes.
Consult physician.
Skin Contact: Immediately flush with copious amounts of water then soap and water for at least
5 minutes. If irritation persists, contact physician. Launder contaminated
clothing before re-use.
Ingestion: Drink several glasses of water. Do not induce vomiting. Call physician
immediately.
Inhalation: Remove to fresh air. If necessary, give oxygen, artificial respiration. Contact
physician.
Cola®Mulse DL-120 Page 3 of 4
SECTION VI – HEALTH HAZARD DATA (CONTINUED)
Notes to physician: There is no specific antidote. Treatment of overexposure should be directed
at the control symptoms and the clinical condition of the patient. Due to the irritant and
surfactant action of the material, if it is aspirated during swallowing or vomiting, there may be
lung injury. Therefore, emesis should not be induced by mechanical or pharmacological means.
If it is considered that evacuation of the stomach contents is necessary, this should be done by
means least likely to result in aspiration (e.g. the use of gastric lavage in the presence of
endotracheal intubation).
SECTION VII – SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION: Not required.
VENTILATION: General (mechanical) room ventilation.
EYE PROTECTION: Chemical goggles.
PROTECTIVE GLOVES: Impervious.
OTHER PROTECTION: Wear protective clothing to prevent skin contact.
Eye bath and safety shower should be available.
SECTION VIII – SPECIAL PRECAUTIONS
HANDLING: Spilled material is slippery on wet or hard surfaces. Foams profusely when hit
with a stream of water. Wash thoroughly after handling. Do not get in eyes. Avoid skin and
clothing contact.
STORAGE: Store away from incompatible substances (SEE SECTION V). Store above 40° F in
lined steel, Liquipak, or P/E drums. Stainless steel, lined steel, or Fiberglass reinforced plastic
tanks should be used for bulk storage. Contact tank manufacturers for recommendations.
The above data is for information purposes only and is accurate to the best of Colonial Chemical,
Inc.’s knowledge. No guarantees or liabilities are expressed or implied.
HEALTH 1
FLAMMABILITY 1
REACTIVITY 0
PERSONAL PROTECTION B
REVISED: 7-20-2006/J.STAFFORD