Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Pre-Start Checklist
Parking Brakes Throttle Battery Switch Avionics Master Switch Flaps Propeller Fuel Condition Lever Landing Gear Battery Switch Panel Lights Fuel Quantity Flight controls Avionics Master Switch Check Weather Anti-ice Switch Anti-ice Annunciators Transponder Beacon Throttle Fuel Flow / Fuel Cond. Lever Right Ignition and Engine Start Switch Right ITT and N1 Turbine RPM Right FUEL PRESS LO Annunciator Right OIL PRESS LO Annunciator Right Oil Pressure Right Generator Repeat for left engine Engine Instruments Nav Lights Taxi Lights Heading Indicator / Altimeter Radios and Avionics Autopilot Flight Director (F/D) Yaw Damper Autofeather Anti-ice Request Parking Brake Taxi to assigned runway Brakes Flight & Engine Instruments SET IDLE OFF OFF UP HIGH RPM FUEL CUTOFF CHECK DOWN ON ON if required CHECK CHECK ON ATIS, Flight Services TEST/CHECK ILLUMINATED STANDBY ON
Start-up Checklist
IDLE ON ON (hold until engine starts) MONITOR EXTINGUISHED EXTINGUISHED CHECK ON CHECK ON ON SET CHECKED and SET SET and OFF ON ON AS REQUIRED ARM AS REQUIRED Taxi Clearance
Taxi Checklist
RELEASE Maximum Speed 20 knots CHECK during taxi CHECK
Take-off Checklist
RELEASE 105 KIAS (descision) 110 KIAS (rotate) 115 KIAS 10-15 degrees RETRACT Maintain 140 KIAS - Torque 65 CHECK CHECK
Climb-out Checklist
ON CHECK and SET OFF 160-170 KIAS - Torque 80 1600 RPM MONITOR Altimeter to 29,92 (1013mb)
Cruise Checklist
220-240 KIAS - Torque 85 1600 RPM OFF 35000 ft CHECK CHECK AS REQUIRED CHECK TUNED and SET CHECK and SET As required CHECK
Descent Checklist
ATIS/Airport Information Altimeter Autofeather Descent Speed Propeller Flaps and Landing Gear Fuel Balance Check Weather At Transition Altitude (FL180) Landing Lights Autofeather Propeller Fuel Condition Lever Anti-ice Speed Flaps Speed Landing Gear Final approach to runway Speed Parking Brake Landing Gear Autopilot Landing Speed After touchdown apply Reverse Thrust At 50 knots cancel Reverse Thrust Strobe Light Flaps Taxi Lights Landing Lights Anti-ice Maximum Speed Elevator Trim Avionics/Radios Parking Brake Throttle Autofeather Flight Director (F/D) Avionics Switch Taxi Lights Nav Lights Pitot Heat Fuel Condition Lever Propeller Beacon Panel Light Battery Switch Generator Switches CHECK SET ARM 180 KIAS - Torque 15 1600 RPM CHECK UP CHECK ATIS, Flight Services Reset Altimeter to local
Approach Checklist
ON VERIFY ARMED HIGH RPM FULL AS REQUIRED Establish 150 KIAS - Torque 25 SET APPR Establish 130 KIAS - Torque 35 DOWN Set flaps FULL DOWN Establish 105 KIAS - Torque 20 VERIFY OFF
Landing Checklist
CHECK DOWN, 3 GREEN VERIFY OFF 100 KIAS
Taxi To Ramp
OFF RETRACT ON OFF OFF 20 knots TAKEOFF SETTING SET
Shutdown Checklist
SET IDLE OFF OFF OFF OFF OFF OFF CUTOFF FEATHER OFF OFF OFF when N1<15% OFF