Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
This checklist was developed with a 1976 Cessna 150M Commuter in mind. Use at your own risk. Please DO NOT alter or obscure FAATest.com identification fromhis
Master Switch On rotation
Fuel Quantity Gauges Check Anti-Collision Lights On Cruise Landing Site Select Fuel Shutoff Valve On (down)
Alternator OFF Verify Hi Voltage Lt
Yoke Full Forward
Nav Lights As Required Mixture Cut-Off Master Switch On
Exterior Lights Check Throttle _____ RPM Rudder and Yoke Neutral
Electrical Equipment Off Fuel Shutoff Valve On (down) Battery/Alternator Off Throttle Set
Mixture Leaned when rotation stops.
Flaps Down Engine Start Magnetos Off Primer In + Locked
Landing Light _____ Pitch Level
Master Switch Off Fuel Shutoff Valve Off (up) Magnetos Check
Pilot In Command Establish
please monitor our website www.faatest.com for modifications and updates to this checklist as well as for other neat aviation stuff.
Fuel Shutoff Valve On (down) Pre-Maneuver Check Engine Restarted? Yes
Acft Documents (AROW) On Board Brakes Set / Held
Mixture Full Rich
Left Wing Carb Heat Cold Loss of Fuel Pressure No Leave fuel selector on
Min Safe Altitude Verify
Fuel Sump Sample - no H20 or debris Mixture Full Rich Mixture Full Rich present tank. Land as soon
Check
Area Clear Mayday Transmit as possible.
Landing Gear / Tire / Brake Throttle 1/4" Open Fuel Shutoff Valve On (down)
FUEL QUANTITY CHECK VISUALLY Carb Heat Hot Mixture Cut-Off
Prop Area
Magnetos Engage
Clear!
Fuel Cap Secure
1000 RPM Post-Maneuver Check Flooded Engine Start Battery/Alternator Off Loss of Oil Pressure /
Secure Throttle
Antennas
Carb Heat Cold Throttle Full Forward Magnetos Off High Oil Temperature
Leading Edge Clean Engine Instruments Check
Mixture Lean as Required Battery/Alternator On Fuel Shutoff Valve Off (up) Land as soon as practical.
Pitot Tube Check, 2 holes After Start Engine Instruments Check
Fuel Vent Check Clear Carburetor Heat Cold Prepare for imminent
Avionics On Approach Engine Fire During Start engine failure.
Stall Warning Opening Check Clear Mixture Cut-Off
Tie Down Remove Radios Set
Seat Belts Fastened Starter Engage Starter Engage Electrical Failure
Wingtip and Lights Inspect Transponder Standby Mixture (when
Flight Instruments Ckd & Set Mixture Cut-Off
Aileron Hinges, Rod, Movement Circuit Breakers In engine fires) Full Rich Load Meter Verify Inop
Flap Security, Rod,Track Radios Set Throttle Open If load meter indicates zero
Fuel Shutoff Valve On (down) Throttle 1000 RPM Fuel Shutoff Valve Off (up)
Fuselage and Empenage Landing Light On Alternator Off
Headsets On Oil Pressure Check Reduce electrical load to min
Overall Condition Check
Before Taxi Carb Heat Hot Evacuate if fire continues
Secure
Antennas
Brakes Slow Speed Check Mixture Full Rich Hot Engine Start Alternator Fld Check
Tie-Down Remove Engine Fire During Taxi Circuit Breaker & Reset
Elevators / Trim Tab Hinges, etc Run Up Fuel Shutoff Valve On (down) Throttle 1/2" Open
Go-Around Prepared For Airplane Stop Alternator On
Rudder Check Brakes Set / Held Battery/Alternator On
Cut-Off If power is not restored
Beacon and Position Lights Check Approach Briefing Complete Carburetor Heat Cold Mixture
Mixture Full Rich Alternator Off
Right Wing
Mixture Full Rich Fuel Shutoff Valve Off (up)
Same as Left Wing (in reverse). No Throttle 1700 RPM After Each Landing Reduce electrical loads to a
Starter Engage Battery/Alternator Off minimum, land as soon as practical.
pitot tube / stall warning horn. Engine Instruments In Limits Transponder Standby
Nose Magnetos Check Throttle 1000 RPM Evacuate Aircraft Electrical Overload
Carb Heat Cold
OIL QUANTITY 4-6 QUARTS
Carb Heat Check Landing Light Off (day) Oil Pressure Check Off
Engine Fire In Flight Alternator
Engine Sump 2 Second Purge / Sample
Gyro Suction In Limits Flaps Up Engine Roughness Battery On
Oil Inspection Door Secure 2 Screws Mixture Cut-Off
Nose Gear / Tire Check (4" min strut) Throttle Idle Shut-Down Fuel Shutoff Valve On (down) Fuel Shutoff Valve Off (up) If alternator loads are reduced, reduce
electrical loads to a minimum, land as
Carburetor Inlet Check / No Debris Carb Heat Check Again Avionics Off Carb Heat Hot Glide Establish soon as pracical. Otherwise:
Carburetor Check Engine Instruments In Limits Mixture Cut-Off If roughness continues after two Landing Site Select Alternator Off
Engine Air Inlets Check Throttle 1000 RPM minutes:
Electrical Equipment Off Mayday Transmit Battery As Required
Prop and Spinner Check / Secure
Before Each Takeoff Master Switch Off Carb Heat Cold Leave battery on only if needed to
Exhaust Stack Secure Magnetos Off
Flight Controls Check Magnetos Off, Key Out Mixture Adjust power essential electrical equipment.
Static Port Unobstructed Battery/Alternator Off Land as soon as practical.
Flight Instruments Set Engine Instruments Check
Securing the Aircraft
V-Speeds (in KIAS) Radios Set Magnetos Check Cabin Fire In Flight Carburetor Icing
Master Switch Verify OFF
Vr 50-55 Va 88-97 Flaps Up for normal takeoff Hobbs / Tach Record If operation on either magneto is Battery/Alternator Off Carb Heat On
t document.