Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Juan C Marchesini
www.amt.com
1 GHz BT Amplifier
1 GHz MB Amplifier
Juan C Marchesini
www.amt.com
TX/RX PLATFORM
Juan C Marchesini
www.amt.com
Leading 1310nm and 1550nm Performance Motorolas traditional strength in 1310nm and 1550nm
technology
Juan C Marchesini
Physical Overview
TYPICAL TX
OMNISTAR GX2
Juan C Marchesini
www.amt.com
Select Modules
1310nm Broadcast Tx 47MHz to 1 GHz 2-15dBM 2 RF Test Points Automatic Gain Control AGC Anti-clipping circuitry
GX2-LM1000E
GX2-OA100B
3 Operating Modes Flat gain in red band DWDM Narrowcast Tx 40 ITU wavelengths available High output power: +10 dBm
Dual Return Receiver 2 independent receivers RF output is 34-52 dBmV Integrated Gain Control
GX2-DM1000 GX2-RX200BX2
GX2-EM1000
GX2-RX200X4
Juan C Marchesini
www.amt.com
Juan C Marchesini
www.amt.com
Test Load 79 analog 79 analog + 320 MHz Digital 79 analog + 450 MHz Digital
Juan C Marchesini www.amt.com
Composite Second Order -66 dBc Max. -66 dBc Max. -66 dBc Max.
9
Composite Triple Beat -66 dBc Max. -66 dBc Max. -66 dBc Max.
FOR INTERNAL USE ONLY
E-CWDM Solution
Narrowcast RF Signals 1 2 3 4 5
NOW!
Available
Broadcast RF Signal
Conditioning Unit
20km to 25km
Increases downstream services by up to 5x over a single fiber and enables 1GHz operating bandwidth Mitigates Raman crosstalk and enable links up to 25km though an innovative, exclusive RF conditioning technique (Magic Box) Utilizes standard ITU CWDM wavelengths in 1.3um window Offers simplicity and ease of use through Motorolas GX2 platform Is Operationally friendly minimal set-up, equipment is interchangeable and interoperable with existing nodes
Juan C Marchesini
www.amt.com
E-CWDM Products
GX2-LC1000E Transmitters
Juan C Marchesini
www.amt.com
Node segmentation Node to hub migration Amplifier to node conversion Multi-wavelength solutions
All-Fiber
CablePON
Fiber Deep
Minimizes network disruption More cost effective than N+0 Incremental fiber expansion
prepares HFC networks for transition to PON
Service Evolution
HFC
Do not cut out Rebirth of the Amplifier As fiber is pushed deeper, reutilize
existing installations Where is the sweet spot for operators Greenfield and Brownfield with GaN technology
Juan C Marchesini
www.amt.com
Allows fiber deep migration with New fiber is need only need from
be used for powering. existing node to new satellite node
Existing coax and power supplies can Allows seamless migration to 1 GHz.
Juan C Marchesini
www.amt.com
Juan C Marchesini
www.amt.com
Key Features
CNR CSO/CTB/XMOD Optical Powers NC input port Laser Drive Mon Port RoHS Compliant Pricing
GX2-LM1000S
51dB 63dBc 2, 4, 6, 8, 10, 11, 12 dBm No No Yes ~ 0.75X
(relative to LM1000E)
LM1000S
Juan C Marchesini
www.amt.com
GX2-EA1000:DWDM Multi-wavelength TX
Benefit
content lineups over a single fiber to segment fiber deep networks With Optical Amplification, satisfy link distances up to 40km.
Operating Bandwidth: 52-1003 MHz Output Power: +6 dBm 8 DWDM ITU Wavelengths for Fiber
Deep Main and Secondary RF Input Ports Gain modes: Preset (AGC), Set (AGC), Manual
Juan C Marchesini
www.amt.com
NODE
SG4-R-100/SC-R SG4-R-100/SC-R M U X GX2OA5XX D E M U X SG4-R-100/SC-R SG4-R-100/SC-R SG4-R-100/SC-R SG4-R-100/SC-R SG4-R-100/SC-R SG4-R-100/SC-R
NODE
D E M U X
Juan C Marchesini
www.amt.com
GaN Benefits
Digital Seamless Bandwidth upgrades Ideal for N+0, N+1 Better ESD Silicon like 22% CAPEX reductions 18% OPEX reductions Based on N+2 estimates
SG4000
Silicon
55 dBmV @ 870 MHz
GaAs
55 dBmV @ 1 GHz
www.amt.com
E-GaAs
58 dBmV @ 1 GHz
Copyright AMT 2010
GaN
60 dBmV
@ 1 GHz
FOR INTERNAL USE ONLY
Juan C Marchesini
Business Services
HUB
1550 Overlay
RFoG
CablePON
Juan C Marchesini
www.amt.com
higher RF BW than Aurora digital return NODE-CWDM-* enables single fiber operation ITU 40 ITU wavelengths Digital 2X TDM 8 dBm ITU 40 ITU wavelengths 5-65 MHz Lower cost CWDM & 1310 versions Analog DWDM 8 dBm 5-200 MHz Split NODE-DWDM-* enables single fiber solution
NEW!
Juan C Marchesini
www.amt.com
Advanced modules to enable advanced network architecture migration SG4-OA* Optical Amplifier
Extends the reach of optical signals High-power 13, 16 and 19 dBm EDFAs Gain-flattened for optimum DWDM performance
SG4-OSW Optical Switch
Juan C Marchesini
www.amt.com
Enables RF regeneration in
the node for RFoG and fiber deep architectures. High sensitivity input to achieve higher return link budgets Enables greater fiber and wavelength aggregation Status monitoring through the LL-SG4-DOCSIS transponder
Juan C Marchesini
www.amt.com
served (versus 32 subs for direct feed) Optical amplification in the node allows 1X64 splitters Multiple return path signals are RF combined or optically combined
Juan C Marchesini
www.amt.com
Included
Key Improvements
Wider E-CWDM 1310 band Reduce Insertion loses Increased link budgets Standard, smaller cassettes to fit inside new nodes Common fiber bulkhead connector Standard 2 mm jacketing
Juan C Marchesini
www.amt.com
BTN100 Node
amplifier location to a node 55 dBmV output @ 1 GHz with - 3 dBm input MBN transmitters DOCSIS Status Monitoring 2x RTN Segmentation FWD / RTN Redundancy
Juan C Marchesini
www.amt.com
BTN2000 Node
GHz 55 dBmV output @ 1 GHz with - 3 dBm input MBN DRT transmitters DOCSIS Status Monitoring 2x RTN Segmentation FWD / RTN Redundancy N split (85 MHz) solution for SG2000
Juan C Marchesini www.amt.com Copyright AMT 2010 FOR INTERNAL USE ONLY
DOCSIS transponder
MBN100
amplifier location to a node Full EPACK and Lid swap utilizing existing MB base 55 dBmV output @ 1 GHz with -3 dBm input CWDM / DWDM return path transmitters DOCSIS Status Monitoring Modular Power Supply
Juan C Marchesini www.amt.com Copyright AMT 2010 FOR INTERNAL USE ONLY
Forward Injection
DOCSIS transponder
Juan C Marchesini
www.amt.com
Forward Segmentation
MBN200
location to a node Full EPACK and Lid swap utilizing existing MB base 55 dBmV output @ 1 GHz with -3 dBm input CWDM / DWDM return path transmitters DOCSIS Status Monitoring Modular Power Supply
Juan C Marchesini
www.amt.com
Uses existing GX2-DRR-2X DWDM 40 ITU wavelengths CWDM 16 wavelengths 1310 nm Double wide module Fits into BTN and MBN nodes Lower pricing than the SG4 SG4 will be readjusted Limited Availability June 2010
Juan C Marchesini
www.amt.com
performance
Termination
Juan C Marchesini
www.amt.com
Juan C Marchesini
www.amt.com
Two high-gain E-GaAs RF outputs Straight-forward design simplifies installation & maintenance
Juan C Marchesini
www.amt.com
Various Ports and Power Levels: Dual DC power supplies or Dual AC power supplies Option with Integrated WDM ports for RFoG or PON
1 WDM for every output port Save rack space Dont need separate WDM modules Reduce insertion losses compared to discrete WDMs 16 ports @ +21dBm 8 ports @ +18dBm 16 ports @ +10.5dBm
41
Juan C Marchesini www.amt.com Copyright AMT 2010 FOR INTERNAL USE ONLY
distances Allows 1:128 split for RFoG in Return-Path Allows more RF combining into CMTS port which saves customers $$ on CMTS blades High-Density: 64 Return Rx in 4RU
Features
Very low EINC allows Input
Headend Aggregation
Business Ethernet
SG4-ENET-SW
Data Voice
CMTS
HFC DS HFC US
OmniStar GX2 WDM
Analog
Fiber
Video
Analog Modulators
Ethernet
Business Ethernet
Digital Video
QAM Modulators
Coax
Hub Site
Coax
Coax
Mobile Backhaul
Key features
Aggregates customer Ethernet traffic
Saves Headend to node wavelengths up to 5x savings Combines multiple customers onto wavelength pair to Headend
Operational simplicity
Simplifies Wavelength management for CPE Less expensive CPE optics needed (no CWDM SFPs)
SG4-ENET-SW
(2) LAN RJ-45 Ports (2) WAN SFP Ports
Up to 1 Gbps for each port Supports LAN, redundancy, or link aggregation 10/100/1000 Mbps copper ports (RJ-45) Enables co-located IP devices
Power
11 watts per module Comparable to SG4-R Fully loaded with max. bandwidth
Copyright AMT 2010 FOR INTERNAL USE ONLY
Juan C Marchesini
www.amt.com
SG4-ENET-SW Mounting
SG4-ENET-SW
Juan C Marchesini
www.amt.com
SG4-ENET-SW
Juan C Marchesini
www.amt.com
Juan C Marchesini
www.amt.com
NODE-ENET-SW
HFC DS HFC US
Customer device
Voice
Analog Video
CMT S
Analog Modulator s QAM Modulators
OmniStar GX2
WDM
Ethernet
Customer device
Digital Video
Up to 80 km
Customer device
Hub Site
Deliver MEF certified services to business customer EPL, ELAN, EVPL services The CPE device is managed by the operator An Ethernet service can be provided to multiple customers
1 to many
Customer device
Customer device
Customer device
Juan C Marchesini
www.amt.com
All existing upstream traffic muxed together with Ethernet. Downstream HFC remains on separate fiber.
Juan C Marchesini www.amt.com Copyright AMT 2010 FOR INTERNAL USE ONLY
Network Management
RJ-45 Ports
Provides local craft access Web, SNMP, and Telnet access
Console Port
Provides CLI access Provides mechanism to recover from lost passwords and IP addresses Not intended for normal unit installation and operation
Questions
Juan C Marchesini
www.amt.com