Sei sulla pagina 1di 10

(A) Objectives:

1. To verify Kirchhoff’s Voltage Law in RLC series circuit.

2. To verify Kirchhoff’s Current Law in RLC parallel circuit.

(B) Equipments and Components:

1. Resistor : 1kΩ , 10Ω

2. Capacitor : 0.01µF

3. Inductor : 10mH

4. Breadboard

5. Signal Generator

6. Multimeter

7. Oscilloscope
(C) Procedures:

A. To verify Kirchhoff’s Voltage Law in RLC series circuit.

Figure 1

1. Circuit as diagram on breadboard was assembled.

2. R was measured using a multimeter.

3. Voltage of every components (VR, VL and Vc) with E=8 Vp-p was measured using an
oscilloscope.

4. Ip-p was calculated using the equation Ip-p = V Rp-p / Rmeasured

5. ZT was calculated using equation ZT = Ep-p / Ip-p

6. Using L and C values used and Rmeasured, ZT was calculated and the result was
compared with the result in step 4.

7. I, VR, VL and VC were calculated using peak-to-peak values and E=8V 0°.
8. Phasor diagram was drawn including I and all voltages.

9. Kirchhoff’s Law was vrified by showing E = (VR 2 + (VL – VC)2) using peak-to-peak
voltage values.

10. Voltage divider method was used to calculate Vab(p-p)

11. The observation from the experiment were discussed.

B. To verify Kirchhoff’s Current Law in RLC parallel circuit.

1. Circuit was assemble as diagram on breadboard

2. current was measured through of every components (IR1, IL and Ic) with E=8 Vp-p using
the multimeter.

3. Verify the Kirchhoff’s Law by calculating IS using the equation IS = IR1 + IL + IC

4. Discuss the observation from the experiment.


Result :

Series Circuit

1. Rmeasured = 980 Ω

2.

Components Voltage
R1 (VRp-p) 8V
L1 (VLp-p) 8V
C1 (Vcp-p) 0.8 V

Voltage measure using oscilloscope.

3. Calculate Ip-p using this equation;


Ip-p = VRp-p / Rmeasured

= 8 V / 980 Ω

= 8.163 mA

4. Calculate the ZT
ZT = Ep-p / Ip-p

= 8 V / 8.163 mA
= 980 Ω

5. Using L and C values used and Rmeasured, calculate ZT


.

ω = 2πf

= 2π(1000Hz)

= 6283.19

Xc = 1/ωc = 1 / 6283.19 (0.01 x 10-6) = 15915.48Ω

Zc = 1 / jωc = 15915.48Ω = 15915.48 ∠ - 90°

XL = ωL

= 6283.19 (10 x 10-3)

= 62.8319Ω

ZL = jωL

= 62.8319 ∠ - 90°

ZT = R + j XL - j Xc

= 1000 + j62.8319 - j15915.48

= 1000Ω
6. Using E = 8 V ∠ 0° , calculate I, VR, VL and VC using peak-to-peak values.

I = V / ZT

= 8 ∠ - 0° / 15884.16 ∠ - 86.39°

= 5.0366 x 10-4∠ 86.39°A

V = IR

= 5.0366 x 10-4∠ 86.39° x 1000 ∠ 0°

= 0.50366 ∠ 86.39°V

VL = Ij XL

= 5.0366 x 10-4 (j62.8319)

= 0.03165 ∠ 90°V

VC = Ij XC

= 5.0366 x 10-4 (-j 15915.48)

= 8.01599 ∠ -90°V

7. Draw phasor diagram including I and all voltages.


8. E = √(VR2 + (VL - VC)2)
= √(82 + (8 - 8)2)

= 8V

9. Vab(p-p) = E ∠ 0° x (ZLC / ZT) ∠ 0°

ZLC = ZL + ZC = j ZL – j ZC

= (62.8319 ∠ 90°) + (15915.48 ∠ -90°)

= 15852.96 ∠ -90°

Vab(p-p) = (8 ∠ 0°) x (15852.96 ∠ -90°) / 15884.16 ∠ - 86.39°

= 7.9841 ∠ -90°

10. Vab = 8V
Parallel Circuit

1.

Components Current
IR1 8.00 mA
IL 128.00 mA
IC 5.00 mA

IS = IR1 + IL + IC

= 8.00 mA + 128.00 mA + 5.00 mA

= 141 mA

2. Verify Kirchhoff’s Law by calculation

IR = 8 ∠ 0° / 970Ω = 8.247 x 10-3 ∠ 0°


IL = 8 ∠ 0° / 62.8319 ∠ 90° = 0.12732 ∠ -90°

IC = 8 ∠ 0° / 15915.48 ∠ -90° = 5.0266 ∠ 90°

IS = IR + IL + IC = 0.12707 ∠ 86.39°

Discussion:

1. RLC circuit contains resistance, inductance, and capacitance.

2. Inductive reactance and capacitive reactance have opposite effect on the circuit phase
angle.

3. Each of the three ideal circuit elements may be represented by one such impedance
element

Suggestions for further work in the future:

1. Prepare the electrical and electronic components which in good condition.

2. Do not use red maker while writing on the whiteboard because it is unclear.
3. Use LCD projector to show how to do the experiment.

4. Use microphone to give the explanation.

Conclusions:

1. Kirchhoff’s Voltage Law in RLC series circuit is verified

2. Kirchhoff’s Current Law in RLC parallel circuit is verified

References:

1. J. David Irwin, Basic Engineering Circuit Analysis, (7th Edition), John Wiley and Sons
Inc,2002

2. David E. Johnson, John L. Hilburn, Johnny R. Johnson, Peter D. Scott, Basic Electric
Circuit Analysis, (5th Edition), Prentice Hall, 1995

3. Robert J. Herrick, DC/AC Circuits and Electronics: Principles & Applications, Theorem
Delwan Learning, New York, 2003

4. Thomas L. Floyd, Principles Of Electric Circuits: Electron Flow Version, (3rd Edition),
Macmillan Publishing Company, New York, 1993

5. Thomas L. Floyd, Principles Of Electric Circuits: Conventional Current Versions, (8th


Edition), Pearson Prentice Hall, New Jersey, 2007

Potrebbero piacerti anche