Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
SERVICE MANUAL
MODEL
PMA-2000IVR
Some illustrations using in this service manual are slightly different from the actual set.
PMA-2000IVR
SAFETY PRECAUTIONS
The following check should be performed for the continued protection of the customer and service technician.
SPECIFICATIONS
POWER AMPLIFIER SECTION
Rated Output Power:
Both channel driven
(8 /ohms Load)
80 W + 80 W
20 Hz to 20kHz, T.H.D. 0.07 %
(4 /ohms Load)
160 W + 160 W
DIN, 1 kHz, T.H.D. 0.7 %
Total Harmonic Distortion:
0.01 %
(3 dB at rated output, 8 /ohms) (1kHz)
Input Sensitivity/Input Impedance:
P. DIRECT:
0.9 V/47 k/kohms
Amplification factor:
29 dB
OVERALL CHARACTERISTICS
SN Ratio (IHF A Network):
(input terminals short-circuited)
(input terminals short-circuited)
SOURCE-DIRECT: ON
Tone Control Adjustable Range:
BASS:
TREBLE:
PHONO
MM: 89 dB (at 5 mV input)
MC: 74 dB (at 0.5 mV input)
CD, TUNER, DVD/AUX-1, AUX-2, TAPE-1/CD-R, TAPE-2/MD: 108 dB
100 Hz 8 dB
10 kHz 8 dB
OTHERS
Power Supply:
AC Outlets:
Switched 2:
Unswitched 1:
Power Consumption:
Dimensions:
Net Mass:
AC 230 V, 50 Hz (Asia)
AC220 V, 50 Hz (China)
100 W (Total)
Except for China model
100 W
310 W (IEC)
434 (W) 180 (H) 478 (D) mm (17-3/32" 7-5/64" 18-13/16")
24.0 kg (52 lbs 14.6 oz)
PMA-2000IVR
DISASSEMBLY
(Do reverse manner when assembling.)
Top Cover
Remove 14 screws 1 , 4 screws 2 and detach the Top Cover
in the arrow direction.
1
1
Top Cover
Front Panel
1. Remove 8 screws 3 .
2. Pull out the knob 4 and remove the nut, then detach the
panel in the arrow direction.
Front Panel
3
4
Nut
PMA-2000IVR
Bottom Plate
Remove 24 screws 5 and detach it in the arrow direction.
Bottom Plate
Rear Panel
1. Remove 5 screws 6 , 6 screws 7 and 2 screws 8 .
2. Detach the Rear Panel in the arrow direction.
Rear Panel
Heat Sink
Ass'y
PMA-2000IVR
METHOD OF ADJUSTMENTS
DC Voltmeter
Power
Trans
VR502
VR501
Power
Trans
1U-3432-2
Power Amp P.W.B. (R)
1U-3432-1
Power Amp P.W.B. (L)
Main Volume
IDLING CURRENT
Setup
1. Lay the unit at an ordinary position away from a direct current from an air condition or fan. Do the adjustment at a
temperature between 15C (59F) and 30C (86F).
2. Set control as follows.
POWER SWITCH
VOLUME CONTROL
SPEAKER Terminals
OFF (
).
Fully counterclockwise in the minimum position (
).
(Main Volume and Semifixed resistors [VR501, 502])
Open: do not connect the speakers, dummy load etc.
Adjustment
1. Remove top cover. And then connect DC Voltmeter to test points of 1U-3432-1 (Lch) and 1U-3432-2 (Rch) Power Amp
Printing Wiring Board.
2. Connect power cord to AC wall outlet, and turn POWER switch "ON" (
VR502 (Rch) clockwise so that the DC Voltmeter reads 12 0.5mV.
3. Then after 2 minutes warmup adjust VR501 and VR502 so that the DC Voltmeter reads 12 0.5mV.
4. And after 10 minutes warmup adjust VR501 and VR502 so that the DC Voltmeter reads 12 0.5mV.
PMA-2000IVR
BLOCK/LEVEL DIAGRAM
1
BASS TREBLE
47k 100
PHONO
MM
+
-
MC
RIAA
TONE
OFF
BUFFER
BALANCE
CD
SOURCE DIRECT
ON
MAIN VOLUME
INPUT
TUNER
DVD
/AUX-1
SPEAKER A
(MAIN)
SPEAKER B
(BI WIRING)
FLAT AMP
POWER AMP
HEAD PHONE
ON
AUX-2
PROTECTOR
TAPE-1
/CD-R
EQUALIZER
TAPE-2
/MD
TONE AMP
TAPE-1
/CD-R
POWER AMP
FLAT AMP
REC OUT
+16V
GND
-16V
+16V
GND
-16V
+16V
GND
-16V
+30V
GND
-30V
B
POWER AMP
VOLTAGE
POWER GND
REGULATOR
+
+
POWER AMP
TAPE-2
/MD
REC OUT SELECTOR
PRE OUT
MAIN IN
+12V
PROTECTOR
&
RELAY
AC PLUG
GND
(dBV)
40dB
80W/8ohm 25.3V(28dB)
30dB
20dB
10dB
0dB
-10dB
-20dB
-30dB
-40dB
-50dB
PHONO MM 2.2mV(-53dB)
-60dB
-70dB
PHONO MC 0.18mV(-75dB)
-80dB
6
PMA2000_BlockLevel.p65
Page 6
02/03/12, 18:49
PMA-2000IVR
SEMICONDUCTORS
ICs
TMP87CC46N-4C08 (IC901)
(HSO)P77
(HSCK)P76
(SO)P75
(SI)P74
(SCK)P73
(PDO/PWM)P72
(INT4)P71
(INT3/TC3)P70
P07
P06
P05
P04
P03
P02
P01
P00
TEST
RESET
XIN
XOUT
(VASS)VSS
Power Supply
Terminal
42 VDD
41 P22(XOUT)
40 P21(XIN)
39 P20(INTS/STOP)
38 P17
37 P16
36 P15(TC2)
35 P14(PPG)
34 P13(DVO)
10
33 P12(INT2/TC1)
11
32 P11(INT1)
12
31 P10(INT0)
13
30 P67(AIN7)
14
29 P66(AIN6)
15
28 P65(AIN5)
16
27 P64(AIN4)
17
26 P63(AIN3)
18
25 P62(AIN2)
19
24 P61(AIN1)
20
23 P60(AIN0)
21
22 VAREF
VDD
VSS
PSW
Flag
ALU
Stack Pointer
Program Counter
Data memory
(RAM)
RBS
Program Memory
(ROM)
TEST
Interrupt Control Circuit
Standby Control Circuit
High Freq.
Oscillator
Connection
Terminal
Time Base
Timer
Timing Generator
XIN
XOUT
High Freq.
Use
Clock
Low Freq. Generator
Use
16 bit
Timer/Counter
TC1
TC2
8 bit
Timer/Counter
TC3
TC4
Watch Dog
Timer
8 bit Serial
Interface
SIO
HSO
Command
register
Command
decoder
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
NOTE:
P2
P22
8 bit
A/D Converter
VAREF
(Analog Input)
P7
P07
P17
P77
Analog
Vref
P1
P0
I/O Port
~
P20
P6
P00
P10
P70
Port Name
P77
P76
P75
P74
P73
P72
P71
P70
P07
P06
P05
P04
P03
P02
P01
P00
TEST
RESET
XIN
XOUT
Vss
VAREF
P60
P61
P62
P63
P64
P65
P66
P67
P10
P11
P12
P13
P14
P15
P16
P17
P20
P21
P22
VDD
(SO)
(SI)
(SCK)
(INT4)
(INT3)
I/O
Type
O
O
O
O
O
O
O
I
O
O
O
O
O
O
O
O
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
I
I
I
I
I
O
O
O
I
I
O
O
O
O
O
O
O
O
O
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
(VAss)
(INT0)
(INT1)
(INT2)
STOP
Function
AC POWER RELAY DRIVE
PROTECTOR INPUT
POWER OFF
MOTOR VOLUME DOWN
+5V
Pin No.
: Terminal number of microcomputer.
Port Name : The name entered on the data sheet of microcomputer.
I/O
: Input or output of port.
"I" = Input port
"O" = Output port
Type
: Composition of port in case of output port.
"C" = CMOS output
Function : Function and logical level explanation of signals to be interface.
I/O Port
PMA-2000IVR
LB1639 (IC902)
BA4558 (IC701)
NJM2082D (IC201)
VOUT1 VOUT2
8 5
7 VCC
TOP VIEW
VIN1 1
8 VOUT1
7 VCC
A INPUT 2
VCONT 3
6 N.C.
A+INPUT 3
VIN2 4
8 V
A OUTPUT 1
GND 2
5 VOUT2
3 VCONT
7 B OUTPUT
2
6 B INPUT
5 B +INPUT
VREF
2 GND
VIN1 1
4 VIN2
6 N.C.
OTHERS
GP1U27X (Remote Control Sensor)
(IC103)
TOP VIEW
Limiter
Amp
BPF
Detector &
Hysteresis
Integrator
Comparator
Comparator
Vout
Vcc
GND
Head
Amp
TRANSISTORS
2SA933S (S)
2SA988 (E/F)
2SA1145 (O/Y)
2SA1546 (M/L)
2SB1328 (P)
2SC1740S (S)
2SC1841 (E/F)
2SC2705 (Y)
2SC3421 (O/Y)
2SC4001 (M/L)
2SD2004 (P)
2SA1837 (Y)
2SC4793 (Y)
DTA114ES
DTC114ES
DTC143ES
DTC143ZS
DTC144WS
FRONT
VIEW
FRONT
VIEW
FRONT
VIEW
E C B
B C E
E C B
DTA114ES
DTC114ES
DTC143ES
DTC143ZS
DTC144WS
NPN Type
PNP Type
R1
R2
DTA114ES
R1
R2
10kohm
10kohm
R1
R2
10kohm
10kohm
DTC143ES 4.7kohm
4.7kohm
4.7kohm
47kohm
DTC144WS 47kohm
22kohm
DTC114ES
DTC143ZS
PMA-2000IVR
2SJ78
2SK215
2SK373 (Y)
2SK184C (GR/BL)
2SK369 (BL/GR)-C
2SK2967
FRONT
VIEW
FRONT
VIEW
FRONT
VIEW
FRONT
VIEW
G S D
S G D
D G S
G D S
HZS2B-1
HZS3B-2
HZS5C-1
HZS9B-1
HZS11A-1
HZS12A-1
HZS30-1
MTZJ3.3A
MTZJ7.5A
MTZJ7.5C
MTZJ18A
FCH20A15
FRH20A15
SLR-56VC (Red)
TOP VIEW
SEL2E10C (Blue)
SLR-342MG (Green)
TOP VIEW
FRONT
VIEW
FRONT
VIEW
A K A
K A K
SIDE VIEW
THYRISTOR
THERMISTOR
SF0R3G42
PTH9M04BD222TS2F333
FRONT
VIEW
G A K
PMA-2000IVR
10
D
1
10
E
1
10
COMPONENT SIDE
10
PMA-2000IVR
16
10
10
11
C
1
3
11
10
3
5
21
22
42
1
1
COMPONENT SIDE
11
PMA-2000IVR
1
1
B
3
10
COMPONENT SIDE
12
PMA-2000IVR
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacturer.
l Resistors
l Capacitors
Ex.:
Ex.:
RN 14K
2E
182
G
FR
Type Shape Power Resist- Allowable Others
and perance error
formance
t
RD : Carbon
RC : Composition
RS : Metal oxide film
RW : Winding
RN : Metal film
RK : Metal mixture
Resistance
1 8 2
2B
2E
2H
3A
3D
3F
3H
: 1/8W
: 1/4W
: 1/2W
: 1W
: 2W
: 3W
: 5W
F
G
J
K
M
: 1%
: 2%
: 5%
: 10%
: 20%
CE
04W
1H
2R2
M
BP
Type Shape Dielectric Capacity Allowable Others
and per- strength
error
formance
P : Pulse-resistant type
NL : Low noise type
NB : Non-burning type
FR : Fuse-resistor
F : Lead wire forming
CE : Aluminum foil
electrolytic
CA : Aluminum solid
electrolytic
CS : Tantalum electrolytic
CQ : Film
CK : Ceramic
CC : Ceramic
CP : Oil
CM : Mica
CF : Metallized
CH : Metallized
Units: ohm
1
Units: ohm
1.2 ohm
1-digit effective number.
2-digit effective number, decimal point indicated by R.
0J : 6.3V
F : 1%
1A : 10V
G : 2%
BP : Non-polar type
1C : 16V
1E : 25V
1V : 35V
J : 5%
K : 10%
M : 20%
1H
2A
2B
2C
2D
2E
2H
2J
Z : +80%
20%
P : +100%
0%
C : 0.25pF
D : 0.5pF
= : Others
HR : Ripple-resistant type
DL : For change and discharge
HF : For assuring high
requency
U : UL part
C : CSA part
W : UL-CSA type
F : Lead wire forming
: 50V
: 100V
: 125V
: 160V
: 200V
: 250V
: 500V
: 630V
2200F
s
s
Indicates number of zeros after effective number.
2-digit effective number.
Units: F.
2
2
s
2.2F
1-digit effective number.
2-digit effective number, decimal point indicated by R.
Units: F.
Capacity (except electrolyte)
2 2 2
2200pF=0.0022F
s
s
(More than 2) Indicates number of zeros after effective number.
2-digit effective number.
Units: pF.
2
220pF
(0 or 1)
Indicates number of zeros after effective number.
2-digit effective number.
Units: pF.
When the dielectric strength is indicated in AC, "AC" is included after the dieelectric
strength value.
13
PMA-2000IVR
Part No.
Part Name
Remarks
SEMICONDUCTORS GROUP
IC103
TR453
Ref. No.
R517,518
IC201
Note: The symbol in the column "Remarks" indicate the following destinations.
G1C: China model
G1H: Hong Kong model
G2A: Singapore model
KEU: U.S.A. model
Part No.
Part Name
Remarks
RD05A2H822J(RMG)
R519-522
R523-526
R529,530
RD14B2E101JNBST
R531,532
R533,534
RD14B2E562JT(PSNB)
R535,536
RD14B2E102JT(PSNB)
R537-540
R541,542
RD14B2E105JT(PSNB)
R543,544
RD14B2E332JT(PSNB)
R545,546
244 2068 035 Metal oxide 390 ohm 1W(NB) RS14B3A391JNBS RSFSV
R547,548
244 2068 019 Metal oxide 200 ohm 1W(NB) RS14B3A201JNBS RSFSV
R549,550
244 2068 035 Metal oxide 390 ohm 1W(NB) RS14B3A391JNBS RSFSV
R553-556
244 2068 006 Metal oxide 100 ohm 1W(NB) RS14B3A101JNBS RSFSV
R557,558
244 2067 010 Metal oxide 0.1 ohm 2W(NB) RS14B3D0R1JNBF RSFKL
R559,560
D101
D453
R565,566
RS14B3A220JNBS RSFSV
R567,568
RD14B2E153JT(PSNB)
R571,572
RD05A2H513JF(RMG)
R573,574
RD14B2E103JT(PSNB)
R575,576
RD14B2E333JT(PSNB)
R585,586
RS14B3D100JNBF RSFKL
D501,502
D505-508
D513-516
R997-999
RD14B2E102JT(PSNB)
ZD471
VR201
V14V20FW104K
VR202
V14V20FA103K
VR203
V14V20FA303K
VR351
V1820V30FB303
V06QB472
CK45E2EAC472MC
R201,202
RD14B2E102JT(PSNB)
C103
CE04W1H101MC(RFS)
R209,210
RD14B2E154JT(PSNB)
C121
CE04W1H010MT(ASF)
RD14B2E362JT(PSNB)
C151
C207,208
CE04W1H220MT(ROB)
CE04W1H100MT (SME)
RESISTORS GROUP
R233,234
R251,252
R463
RD14B2E102JT(PSNB)
C209,210
R471,472
RD14B2E101JT(PSNB)
C211,212
R473,474
RD14B2E105JT(PSNB)
C217,218
CF93A1H333JT (JL)
R475-478
RD14B2E104JT(PSNB)
C219,220
CE04W1HR22MT (SME)
C221,222
CE04W1H0R1MT (SME)
R501,502
RD05A2H332JF(RMG)
C223,224
CE04W1HR47MT (SME)
R503-506
RD14B2E472JT(PSNB)
C225,226
R507,508
RD14B2E221JT(PSNB)
R509,510
RD05A2H105JF(RMG)
C351
CF93B1H105K(GSG)
CE04D1V100MBPT (SME)
CK45F1H223ZT(DD-3)
R511,512
RD14B2E132JT(PSNB)
C354
R513,514
RD05A2H333JF(RMG)
C355
R515,516
RD05A2H122JF(RMG)
14
PMA-2000IVR
Ref. No.
Part No.
Part Name
Remarks
Ref. No.
Part No.
Part Name
Remarks
Q'ty
C463
CE04W1H220MT(ASF)
F101
KEU
C471,472
CQ93P2A101JT(NH2)
F108,109
KEU
F108,109
G2A
FF101
G2A,KEU
C473-476
CE04W1H100MT(ASF)
C481
CE04W1H220MT(ASF)
C482
CE04W1H470MT(ASF)
C501,502
C503,504
CQ93P2A101JT(NH2)
FH101
C505,506
C507,508
C509,510
JK306
C517,518
CQ93P2A271JT(NH2)
JK501
C519,520
CQ93P2A101JT(NH2)
CE04W1H220MT(RFS)
C521-524
CE04W1H221MC(RFS)
RL101
C527,528
CQ93P2A101JT(NH2)
RL403
C529-534
C537-540
2
1
CE04W1H221MC(RFS)
C541,542
CF93B2E104K(WAG)
S101
C545-548
CE04W2A101MC(RFS)
S201
C557,558
CE04W1H470MT(RFS)
S202
C561,562
CE04W1H220MT(RFS)
Q'ty
CW101
CX021
CX022
CX033
CX041
CX051
CX052
CX053
CX056
CX062
CX081
CX101
CY022
CY035
CY061
CY103
CZ057
CZ081
F101
G1C,G1H,G2A
ST201
Style pin
ST203
Style pin
ST205
T101
G1C,G1H,G2A
T101
KEU
W352
W501
G1C,G1H,G2A
G2A
Vinyl wire
Vinyl wire
KEU
KEU
15
PMA-2000IVR
Part No.
Part Name
Remarks
Ref. No.
Part No.
Part Name
SEMICONDUCTORS GROUP
ZD603
IC701
ZD604
ZD605
IC901
Remarks
IC902
ZD902
IC903
ZD903
TR301
TR302
TR608
TR611
TR612
TR613
TR614
TR615
TR902
TR903
TR904
TR907
TR908
RESISTORS GROUP
R301-310
RD14B2E334JT(PSNB)
R313,314
RD14B2E334JT(PSNB)
R607,608
RD14B2E393JT(PSNB)
R614
RD14B2E103JT(PSNB)
R623-626
R627
RD14B2E222JT(PSNB)
R705,706
RD14B2E101JT(PSNB)
R707,708
RD14B2E473JT(PSNB)
R709,710
RD14B2E100JT(PSNB)
R711-714
RD14B2E302JT(PSNB)
R715,716
RD14B2E201JT(PSNB)
R717,718
RD14B2E202JT(PSNB)
R719,720
RD14B2E820JT(PSNB)
R721,722
RD14B2E821JT(PSNB)
R723,724
RD14B2E225JT
R725,726
RD14B2E473JT(PSNB)
R727,728
RD14B2E392JT(PSNB)
R729,730
RD14B2E220JT(PSNB)
R731,732
RD14B2E221JT(PSNB)
R733,734
RD14B2E471JT(PSNB)
R735,736
RD14B2E624JT(PSNB)
R737,738
RD14B2E6R8JT(PSNB)
R739,740
D601,602
D603,604
D606,607
D701,702
D801
D802
D901,902
D903,904
CAPACITORS GROUP
D908-922
C311
CE04W1E101MT(ASF)
C312
CE04W1H101MC(RFS)
C313-317
CE04W1E101MT (SME)
C319
CE04W1H470MT(RFS)
C320
ZD301
ZD601
ZD602
R901
R996-998
RD14B2E100JT(PSNB)
JV124
G1C,G1H
JV124
G2A
16
PMA-2000IVR
Ref. No.
Part No.
Part Name
Remarks
Ref. No.
Part No.
Part Name
Remarks
C603
C604
CE04W1V222MC(RE3)
CX031
Q'ty
C607
CE04W1HR22MT (SME)
CX035
C608,609
CE04W1H010MT (SME)
CX061
C610
CE04W0J331MT(ASF)
CX102
C611
CE04W1C221MT (SME)
CX111
C612
CE04W1H4R7MT (SME)
C613
CE04W1H220MT(ASF)
C615
CE04W1H221MC(ROB)
CY033
C616
CY041
C619
CY051
C620
CY054
CE04W1H101MT(ASF)
C703,704
CY062
C705,706
CY111
CZ102
C707,708
C711,712
CE04W1H101MT(ASF)
C713,714
CE04W1H101MT(ASF)
C715,716
CE04W1H100MT(ASF)
C717,718
C719,720
C721,722
C723,724
RL601
C731,732
CE04W1H470MT(ROB)
S301
C805,806
CE04W2A2R2M(ARSAG2)
S701
C808
CF93B1H105K(GSG)
S901
C903
CE04W1E101MT(ASF)
W602
C905
CE04W1E101MT(ASF)
W807,808
C906
W809
XL901
JK305
C907
C908
CE04W1C332MC(SMG)
C909
CE04W1E101MT(ASF)
C910
CF93A1H104JT (JL)
Vinyl wire
C911
Radiator
C913
CF93A1H104JT (JL)
C914
CE04W1HR22MT (SME)
C915
C920
CE04W1H100MT(ASF)
C926
CE04W1H2R2MT (SME)
C927
CE04W1H100MT(ASF)
1
2
2
17
PMA-2000IVR
Part No.
Part Name
Remarks
Ref. No.
Part No.
Part Name
Remarks
SEMICONDUCTORS GROUP
C413,414
TR406
C423,424
TR407
C425,426
TR408
C427-430
C431,432
C433-436
C439,440
C441-444
CE04W1H101MC(RFS)
C451
CE04W1H221MC(RFS)
C453
CE04W1H221MC(RFS)
TR451
C455,456
C461,462
D421-426
D451,452
CE04W1H470MT(RFS)
C415,416
CE04W1H101MC(RFS)
C421,422
R401-404
RD14B2E102JT(PSNB)
R421,422
RD14B2E105JT(PSNB)
R423,424
RD14B2E221JT(PSNB)
R425,426
RD14B2E333JT(PSNB)
R427,428
RD14B2E473JT(PSNB)
R429-432
RD14B2E102JT(PSNB)
R433,434
RD14B2E331JT(PSNB)
R435,436
RD14B2E681JT(PSNB)
R437,438
RD14B2E105JT(PSNB)
R439,440
RD14B2E562JT(PSNB)
R441,442
RD14B2E102JT(PSNB)
R443,444
RD14B2E101JNBST
R445-448
R449,450
RD14B2E474JT(PSNB)
R451-454
RS14B3A470JNBS(RSFSV)
R457,458
RD14B2E101JT(PSNB)
F401,402
CE04W1H4R7MT(RFS)
CE04W1H470MT(ASF)
Q'ty
CW055
CW056
CW931
CX057
CX103
CY031
RESISTORS GROUP
CE04W1H100MT(RFS)
ST401-403
Style pin
Radiator
2
3
4
4
CAPACITORS GROUP
C401,402
C405,406
CE04W2A470MC(ARS/2)
C407,408
CE04W1H470MT(RFS)
C409,410
CE04W1H471MC(RFS)
C411,412
18
PMA-2000IVR
EXPLODED VIEW
1
101
104
104
89
109
5
77
101
46
101
76
52
74
55
101
51
101
117
113
108
44
101
10
105
106
86
115
30
53
67
2-3
74
23
91
90
105
77
94
35
40
43
1-9
29
108
22
72
101
49
31
64
101
93
48
91
48
28
107
106
1-2
45
108
101
24
101
101
110
1-4
107
1-6
13
6
12
112
11
25
1-7
101
23
73
113
1-3
79
101
101
109
50
113
57
46
71
95
19
60
20
36
2-4
18
2-1
107
58
76
109
47
2-2
119
101
85
14
1-5
101
109
113
106
83
26
74
31
104
101
92
29
101
101
86
27
102
42 97
96
65
37
84
42
66
33 32
70
23
71
69
1-8
115
66
103
71
116
30
114
113
47
38
101
15
46
101 101
103
87 , 88
85
48
1-1
8
WARNING:
Parts marked with this symbol
have critical
characteristics.
Use ONLY replacement parts recommended by the
manufacturer.
G2A only
102
109
101
104
7
35
7
48
104
39
21
107
101
20
59
31
101
16
41
34
41
101
81
17
101
101
63
61
101
56
62
101
19
19
PMA-2000IVR
Note: The symbol in the column "Remarks" indicate the following destinations.
G1C: China model
G1H: Hong Kong model
G2A: Singapore model
KEU: U.S.A. model
27
28
29
30
31
32
33
Part No.
Part Name
1U-3432B
1U-3432A
1U-3130H
1U-3433
206 1015 016
206 1046 027
206 1015 016
206 1046 027
204 8480 004
214 0195 006
212 1176 002
212 1157 005
233 6257 007
233 6267 007
211 0798 103
211 0834 012
211 0834 009
211 0873 002
203 3975 003
203 3974 004
214 0195 006
212 4331 006
212 4728 004
212 0407 002
204 8530 006
204 8531 005
411 1341 515
445 0048 016
411 1346 248
462 0089 054
105 1339 075
105 1339 091
105 1339 062
105 1411 003
205 1014 218
412 4141 003
415 9092 017
513 3457 004
462 0089 025
205 0071 016
477 0018 014
Remarks
G1C,G1H
G2A
Q'ty
1
1
Ref. No.
34
35
36
37
38
39
40
41
42
F108,G2A
KEU
F109,G2A
KEU
JK501
RL501,502
S101
S201
G1C,G1H,G2A
KEU
VR201 (BALANCE)
VR202 (TREBLE)
VR203 (BASS)
VR351 (VOLUME)
G2A
KEU
RL501,502
S301
S701 (MM/MC)
S901 (INPUT SELECTOR)
JK301-304
JK305
G1C
G1H
G2A
KEU
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
2
1
1
1
4
1
1
1
1
1
1
1
1
1
2
1
2
2
3
1
2
43
44
45
46
47
48
49
50
51
52
53
55
56
57
58
59
60
61
62
63
64
65
66
67
69
70
71
72
73
74
76
77
79
81
Part No.
Part Name
Shield plate
TC bracket
P.C.B holder
P.W.B bracket (A)
AC inlet
Bottom cover
Slide switch
Foot ass'y
Foot ass'y
Power trans
Power trans
Power trans
P.C.B holder (T)
Electrolytic 12000uF/71V
Power radiator (R)
Transistor 2SK2967
Insulating sheet
P.W.B bracket (B)
Radiator bracket (R)
Radiator bracket (B)
Power radiator (L)
Radiator bracket (L)
Radiator bracket (A)
Support bracket (L)
Front panel ass'y
Front panel ass'y
Rotary remote switch
Plate (M)
Plate (F)
Power knob ass'y
Power knob ass'y
Knob (M) ass'y
Knob (M) ass'y
Knob ass'y (F)
Knob ass'y (F)
Knob (MARU) ass'y
Knob (NARU) assy
Support bracket (R)
Top cover
Top cover
Spacer
Plate (T/C)
Short pin
Fuse (4.0A)
Fuse (10A)
Teflon spacer
Trans bracket
3 TWB
Washer
3 Washer
Plate (RD)
Push knob ass'y
Push knob ass'y
Teflon washer (VR)
Remarks
Q'ty
1
2
4
1
1
1
S202
1
4
KEU
4
G1C,G1H
2
G2A
2
KEU
2
4
CE62W==123M
2
1
TR521-524
4
4
4
1
1
1
1
1
1
1
KEU
1
(REC OUT SELECTOR) 1
1
1
1
KEU
1
1
KEU
1
1
KEU
1
4
KEU
4
1
1
KEU
1
2
1
2
F101 G1C,G1H,G2A 1
KEU
1
7
1
1
12
2
2
1
KEU
1
1
Ref. No.
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
A
B
C
D
E
F
G
H
I
J
K
L
M
N
O
P
Q
R
S
T
Part No.
Part Name
Rubber sheet
Card spacer (L=14)
CU plate
Push rivet
Spacer
Rubber pad
PVC sheet
Serial No.sheet
Bush
Shield plate (A)
P.W. spacer
C. holder
Plate (T/C)
Shield plate
Spacer
3P VH-VH Connector cord
3P VH-VH Connector cord
3P KR-KR ribbonN 350
3P KR-KR ribbon 250
4P KR-KR ribbon 350
5P EH-EH Connector cord
5P PH-PH Connector cord
5P KR-KR ribbon 350
5P EH-EH Connector cord
5P EH-EH Connector cord
6P EH-EH Connector cord
6P KR-KR ribbon 350
10P KR-KR ribbon 550
10P EH-EH Connector cord
11P KR-KR ribbon 375
Vinyl wire
Vinyl wire
Vinyl wire
Vinyl wire
Vinyl wire
Wire clamper
3P contact ass'y
UL tube (16) BK
3TWB (ZN)
1P contact ass'y
UL tube
Wire clamper
Cord holder (L76)
PVC sheet
Fuse caution label
Fuse caution label
Remarks
G2A,G1C,G1H
G2A
G2A
G2A,G1C,G1H
CN022
CN031
CN033
CN035
CN041
CN051
CN052
CN053
CN054
CN057
CN061
CN062
CN102
CN103
CN111
for AC inlet
for AC inlet
for foil side
Red
Blue
Q'ty
2
1
2
8
1
1
1
1
2
1
4
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
2
18
1
10
2
1
1
2
2
95
4
14
1
1
Ref. No.
Part No.
Part Name
Remarks
Q'ty
SCREWS
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
6
6
8
11
14
10
14
2
16
2
13
2
8
1
1
1
1
1
1
1
21
20
PMA2000_Exp List.p65
Page 20-21
02/03/12, 17:26
PMA-2000IVR
PACKING VIEW
210
209
201
202
212
209
211
212
Note: The symbol in the column "Remarks" indicate the following destinations.
G1C: China model
G1H: Hong Kong model
G2A: Singapore model
KEU: U.S.A. model
205
206
Part No.
505 9102 019
504 9102 029
505 8006 019
206 2189 006
206 2209 009
262 2210 001
262 2157 009
399 0523 005
Part Name
Poly cover
Stilen paper
Envelope
AC cord
AC cord (BS3P)
AC cord
AC cord
Remote control unit (RC-858)
Battery (R03X2)
Remarks
G1C
G1H
G2A
KEU
Q'ty
1
1
1
1
1
1
1
1
1
Ref. No.
207
208
209
210
211
212
213
215
216
Part No.
511 3893 002
511 3917 001
515 0921 005
503 1221 109
502 0944 002
501 2019 068
Part Name
Instruction manual
Instruction manual
S.S.list (EX)
Cushion ass'y
Cushion ass'y
Carton case
Control card
Carton label
Color label (Gold)
DEL warranty home
Remarks
KEU
G1C
KEU
Q'ty
1
1
1
1
1
2
1
1
1
1
21
PMA-2000IVR
WIRING DIAGRAM
5
10P-EH
H/P-L
GND
H/P-R
SP-MUTE
GND
+15V
-15V
L-TAP
L-CH
L-TONE
GND
GND
R-TONE
R-CH
R-TAP
CY035
RELAY 1 3P-KR
1
2
3
4
5
AUX-2 2
COMMON 3
+55V
GND
-55V
1
2
3
4
CX054
5
5P-EH
6
7
8
9
CX10310
+15V
RELAY
-15V
GND
L
DIRECT
GND
NC
GND
OUT-L
FLAT AMP UNIT
GND
+15V
1U-3433
OUT-R
-15V
IN-L
R
GND
GND
IN-R
GND
+15V
-15V
L
GND
R
RELAY
GND
DIRECT
NC
OUT-L
GND
OUT-R
IN-L
GND
IN-R
CONTROL UNIT
1U-3432-3
GND 3
NC 4
CW101
CX101
CX035
+15V
-15V
L-TAP
L-CH
L-TONE
GND
GND
R-TONE
R-CH
R-TAP
1 CX061
2
6P-EH
3
4
5
6
+15V
GND
-15V
L-CH
GND
R-CH
1
2
3
4
5
6
1 CX102
2
3
4
5
6
7
8
9
10
1 CX081
2
3
4
8P-EH
5
6
7
8
CW081
FUNCTION SW UNIT
1U-3130-5
1
2
3
4
5
6
7
8
+15V
-15V
L
L-TAP
GND
GND
R-TAP
R
CX055 1 +15V
5P-EH 2 -15V
POWER AMP(L)UNIT
1U-3432-1
3 R
4 GND
5 GND
SP-RELAY
ASO
POSISTOR
GND
L-OUT
+
+
BLKx2
BLKx2
1 CX053
2 5P-KR
3
4
5
SPEAKER OUTPUT
L-ch
CX056 1 +15V
5P-EH 2 -15V
UP
MAIN VR UNIT
1U-3432-9
3 R
4 GND
5 GND
1 2 3
SP-RELAY
ASO
POSISTOR
GND
R-OUT
AMP(R)UNIT GND
POWER
1U-3432-2
1 CX062
2 6P-KR
3
4
5
6
+
+
BLKx2
BLKx2
BLKx2
WHTx2
SPEAKER OUTPUT
R-ch
C
1 2 3 4
1 2 3
SP-RELAY
ASO
POSISTOR
GND
L-OUT
1 CY053
2 5P-KR
3
4
5
SP-RELAY
ASO
POSISTOR
GND
R-OUT
GND
1 CY062
2 6P-KR
3
4
5
6
AC-LOW
GND
AC-LOW
12V
P ON/OFF
5 CY051
4 5P-EH
3
2
1
1U-3130-3
BLK
BLU
BLK
BLU
D
PROTECTOR UNIT
1U-3130-2
1 2 3 4 5
H/P-L
GND
H/P-R
SP-MUTE
GND
TAPE1
AUX2
AUX1
TUNER
CD
PHONO
5V
FUNCTIN
STOPACT.
GND
1 2 3 4 5 6 7 8 9 10
UP
2
3
4
5
6
7
8
9
10
11
3C(RED,BLK,BLU)x2
BLKx2
CY054
CY033
RELAY
H/P-MUTE
GND
NC
CY111 1 TAPE2
CY041
GND
NC
DRIVE
T2
T1
AU2
AU1
TU
CD
PH
1 CX111
2
3
4
5 11P-KR
6
7
8
9
10
11
BLKx2
CY057
CZ102
10P-KR
TAPE2
TAPE1
AUX2
AUX1
TUNER
CD
PHONO
5V
FUNCTIN
STOPACT.
GND
WHTx2
3C(RED,BLK,BLU)x2
+15V
-15V
L
L-TAP
GND
GND
R-TAP
R
CY061
GND
NC
DRIVE
T2
T1
AU2
AU1
TU
CD
PH
2
3
4
5
1 2 3 4 5
1 2 3 4 5 6 7 8 9 10
RELAY 1
AUX-2 2
COMMON 3
1 CW056
CX057
5P-EH
10P-EH
EQUALIZER/
INPUT UNIT
1U-3130-1
1 CW055
2
3
4
5
1 2 3 4 5
1 2 3 4 5 6 7 8 9 10
+15V
GND
-15V
L-CH
GND
R-CH
1 2 3
RELAY 1 CX041
H/P-MUTE 2 4P-KR
1U-3432-10
PRE OUT UNIT
CY031
1 2 3 4 5 6 7 8 9 10
DOWN
CY103
DOWN
WHT
YEL
CX051
LED UNIT
1U-3432-4
LED MUTE
+5V
DATA
LED
GND
1 CX052
2
3
4 5P-KR
5
CY052 1
2
3
4
5
LED MUTE
+5V
DATA
LED
GND
5
4
3
2
1
AC-LOW
GND
AC-LOW
12V
P. ON/OFF
WHT
AC OUTLET UNIT
1U-3432-8
1
YEL
POWER SW UNIT
1U-3432-6
E
AC INLET
22
PMA-2000IVR
10
11
A
9.5V
9.4V
8.8V
11.5V
12.7V
11.5V
12.7V
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
NOTICE
+ B LINE
- B LINE
SIGNAL LINE
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
23
PMA-2000IVR
10
11
9.5V
9.4V
B
8.8V
11.5V
12.7V
11.5V
12.7V
NOTICE
+ B LINE
- B LINE
SIGNAL LINE
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
23
PMA-2000IVR
10
11
A
9.5V
9.4V
8.8V
11.5V
12.7V
11.5V
12.7V
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
NOTICE
+ B LINE
- B LINE
SIGNAL LINE
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
23
PMA-2000IVR
10
11
A
9.5V
9.4V
8.8V
11.5V
12.7V
11.5V
12.7V
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
NOTICE
+ B LINE
- B LINE
SIGNAL LINE
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
23
PMA-2000IVR
10
11
A
9.5V
9.4V
8.8V
11.5V
12.7V
11.5V
12.7V
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
NOTICE
+ B LINE
- B LINE
SIGNAL LINE
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
23
PMA-2000IVR
10
11
A
9.5V
9.4V
8.8V
11.5V
12.7V
11.5V
12.7V
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
NOTICE
+ B LINE
- B LINE
SIGNAL LINE
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
23
PMA-2000IVR
10
11
11V
+ B LINE
11V
- B LINE
SIGNAL LINE
NOTICE
ALL RESISTANCE VALUES IN OHM. k=1,000 OHM M=1,000,000 OHM
ALL CAPACITANCE VALUES IN MICRO FARAD. P=MICRO-MICRO FARAD
EACH VOLTAGE AND CURRENT ARE MEASUERD AT MO SIGNAL INPUT
CONDITION.
CIRCUIT AND PARTS ARE SUBJECT TO CHANGE WITHOUT PRIOR
NOTICE.
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
24
PMA-2000IVR
10
11
11V
11V
+ B LINE
- B LINE
SIGNAL LINE
NOTICE
ALL RESISTANCE VALUES IN OHM. k=1,000 OHM M=1,000,000 OHM
ALL CAPACITANCE VALUES IN MICRO FARAD. P=MICRO-MICRO FARAD
EACH VOLTAGE AND CURRENT ARE MEASUERD AT MO SIGNAL INPUT
CONDITION.
CIRCUIT AND PARTS ARE SUBJECT TO CHANGE WITHOUT PRIOR
NOTICE.
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
24
PMA-2000IVR
10
11
11V
+ B LINE
11V
- B LINE
SIGNAL LINE
NOTICE
ALL RESISTANCE VALUES IN OHM. k=1,000 OHM M=1,000,000 OHM
ALL CAPACITANCE VALUES IN MICRO FARAD. P=MICRO-MICRO FARAD
EACH VOLTAGE AND CURRENT ARE MEASUERD AT MO SIGNAL INPUT
CONDITION.
CIRCUIT AND PARTS ARE SUBJECT TO CHANGE WITHOUT PRIOR
NOTICE.
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
24
PMA-2000IVR
10
11
11V
+ B LINE
11V
- B LINE
SIGNAL LINE
NOTICE
ALL RESISTANCE VALUES IN OHM. k=1,000 OHM M=1,000,000 OHM
ALL CAPACITANCE VALUES IN MICRO FARAD. P=MICRO-MICRO FARAD
EACH VOLTAGE AND CURRENT ARE MEASUERD AT MO SIGNAL INPUT
CONDITION.
CIRCUIT AND PARTS ARE SUBJECT TO CHANGE WITHOUT PRIOR
NOTICE.
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
24
PMA-2000IVR
10
11
11V
+ B LINE
11V
- B LINE
SIGNAL LINE
NOTICE
ALL RESISTANCE VALUES IN OHM. k=1,000 OHM M=1,000,000 OHM
ALL CAPACITANCE VALUES IN MICRO FARAD. P=MICRO-MICRO FARAD
EACH VOLTAGE AND CURRENT ARE MEASUERD AT MO SIGNAL INPUT
CONDITION.
CIRCUIT AND PARTS ARE SUBJECT TO CHANGE WITHOUT PRIOR
NOTICE.
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
24
PMA-2000IVR
10
11
11V
+ B LINE
11V
- B LINE
SIGNAL LINE
NOTICE
ALL RESISTANCE VALUES IN OHM. k=1,000 OHM M=1,000,000 OHM
ALL CAPACITANCE VALUES IN MICRO FARAD. P=MICRO-MICRO FARAD
EACH VOLTAGE AND CURRENT ARE MEASUERD AT MO SIGNAL INPUT
CONDITION.
CIRCUIT AND PARTS ARE SUBJECT TO CHANGE WITHOUT PRIOR
NOTICE.
WARNING:
Parts marked with this symbol
have critical characteristics.
Use ONLY replacement parts recommended by the manufacture.
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
24
PMA-2000IVR
NOTICE
WARNING:
CAUTION:
Before returning the unit to the customer, make sure you make either (1) a
leakage current check or (2) a line to chassis resistance check. If the leakage
current exceeds 0.5 milliamps, or if the resistance from chassis to either side
of the power card is less than 460kohms, the unit is defective.
+ B LINE
- B LINE
Lch SIGNAL LINE
Rch SIGNAL LINE
WARNING:
DO NOT return the unit to the customer until the problem is located and
corrected.
25